Champion Power Equipment 41535 - Manuals

REV 41535-20120723 2 41535 ENGLISH MANUAL CONVENTIONS This manual uses the following symbols to help differentiate between different kinds of information . The safety symbol is used with a key word to alert you to potential hazards in operating and owning power equipment .Follow all safety messages ...

3 REV 41535-20120723 ENGLISH 41535 SAfETy RULES Generator exhaust contains carbon monoxide, a colorless, odorless, poison gas . Breathing carbon monoxide will cause nausea, dizziness, fainting or death . If you start to feel dizzy or weak, get to fresh air immediately . Operate generator outdoors on...

REV 41535-20120723 4 41535 ENGLISH SAfETy RULES Improper treatment or use of the generator can damage it, shorten its life and void your warranty . Use the generator only for intended uses .Operate only on level surfaces .DO NOT expose generator to excessive moisture, dust, or dirt .DO NOT allow any...

5 REV 41535-20120723 ENGLISH 41535 Read this owner’s manual before operating your generator . Familiarize yourself with the location and function of the controls and features . Save this manual for future reference . Generator CONTROLS ANd fEATURES (1) Fuel Tank – 5 .9 gallon (22 .4 L) capacity fuel...

REV 41535-20120723 6 41535 ENGLISH Power Panel 1 6 5 8 3 2 CONTROLS ANd fEATURES 4 7 (1) Intelligauge – Three mode digital meter for displaying running hours, voltage and hertz . (2) Battery Switch – Enables /disables starting electrically – via remotely or by Ignition Switch . (3) Circuit Breakers ...

7 REV 41535-20120723 ENGLISH 41535 CONTROLS ANd fEATURES Wireless Remote Control This generator is equipped with a wireless remote control system for starting and stopping . The system consists of (4) main components:1 . Receiver Control Module (RCM)2 . Wireless Remote3 . Battery Switch4 . Ignition ...

REV 41535-20120723 8 41535 ENGLISH Parts Included Your 41535 Gasoline Powered Generator ships with the following parts: Wheel Kit – 10” Wheel 2 – Flange Bolt (M10x120 for Wheel) 2 – Bushing 2 – Flat Washer 10 2 – Nut (M10) 2 – Support Leg w/ Vibration Mounts 1 – Flange Bolt (M8x16 for Support Leg) 2...

9 REV 41535-20120723 ENGLISH 41535 ASSEMBLy Your generator requires some assembly . This unit ships from our factory without oil . It must be properly serviced with fuel and oil before operation .If you have any questions regarding the assembly of your generator, call our help line at 1-877-338-0999...

REV 41535-20120723 10 41535 ENGLISH 1 . Place the generator on a flat, level surface . 2 . Remove oil fill cap /dipstick to add oil .3 . Add 1 .16 qt (1 .1 L) of oil (included) and replace oil fill cap/dipstick . See “Specifications” pages for oil recommendations based on operating conditions . 4 . ...

11 REV 41535-20120723 ENGLISH 41535 ASSEMBLy Add fuel Cont’d. Grounding Your generator must be properly connected to an appropriate ground to help prevent electric shock . A ground terminal connected to the frame of the generator has been provided on the power panel . For remote grounding, connect o...

REV 41535-20120723 12 41535 ENGLISH Surge Protection Electronic devices, including computers and many programmable appliances use components that are designed to operate within a narrow voltage range and may be affected by momentary voltage fluctuations . While there is no way to prevent voltage flu...

13 REV 41535-20120723 ENGLISH 41535 Recoil Start 1 . Make certain the generator is on a flat, level surface .2 . Turn off all electrical loads connected to the generator . Never start or stop the generator with electrical devices plugged in and turned on . 3 . Turn the Fuel Valve to the “ON” positio...

REV 41535-20120723 14 41535 ENGLISH Connecting Electrical Loads 1 . Let the engine stabilize and warm up for a few minutes after starting 2 . Plug in and turn on the desired 120/240 Volt AC single phase, 60 Hz electrical loads . – DO NOT connect 3-phase loads to the generator . – DO NOT connect 50 H...

REV 41535-20120723 16 41535 ENGLISH The owner/operator is responsible for all periodic maintenance . Complete all scheduled maintenance in a timely manner . Correct any issue before operating the generator . Never operate a damaged or defective generator . Tampering with the factory set governor wil...

17 REV 41535-20120723 ENGLISH 41535 Adjustments The air-fuel mixture is not adjustable . Tampering with the governor can damage your generator and your electrical devices and will void your warranty . CPE recommends that you contact our service line at1-877-338-0999 for all other service and/or adju...

REV 41535-20120723 18 41535 ENGLISH MAINTENANCE ANd STORAGE Storage The generator should be started at least once every 14 days and allowed to run for at least 20 minutes . For longer term storage, please follow these guidelines . Generator Storage 1 . Add a properly formulated fuel stabilizer to th...

19 REV 41535-20120723 ENGLISH 41535 SPECIfICATIONS fCC Statement for Remote Control device 1 . This device complies with Part 15 of the FCC Rules . Operation is subject to the following two conditions: (1) This device may not cause harmful interference .(2) This device must accept any interference r...

REV 41535-20120723 20 41535 ENGLISH Wiring diagram SPECIfICATIONS

21 REV 41535-20120723 ENGLISH 41535 SPECIfICATIONS Parts diagram

REV 41535-20120723 22 41535 ENGLISH Parts List # Part Number Description Qty 1 ST160F-1070007 Fuel Line Clip 7mm 2 2 ST05FD-04712003-CARB Air Cleaner Hose 1 3 ST168FD-1070408-CARB Clip 2 4 509 .070014 .00 Rollover Valve Hose 1 5 GB5789-FB8-12 Flange Bolt M8 ×12 4 6 ST05FD-04712100-CARB Charcoal Cani...

23 REV 41535-20120723 ENGLISH 41535 SPECIfICATIONS Engine Parts diagram

25 REV 41535-20120723 ENGLISH 41535 TROUBLESHOOTING for further technical support : Technical ServiceMon – Fri 8:30 AM – 5:00 PM (PST/PDT)Toll Free: 1-877-338-0999tech@ championpowerequipment .com Problem Cause Solution Generator will not start No fuel Add fuel Faulty spark plug Replace spark plug U...

REV 41535-20120723 26 41535 ENGLISH WARRANTy WARRANT y CHAMPION POWER EQUIPMENT 2 YEAR LIMITED WARRANTY Warranty Qualifications Champion Power Equipment (CPE) will register this warranty upon receipt of your Warranty Registration Card and a copy of your sales receipt from one of CPE’s retail locatio...