Blodgett KLT-12G - Manual
Blodgett KLT-12G – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 5 – indicating that the ignition and burner are active.
- Page 6 – WARNING
- Page 7 – GAS CONNECTION; Test pipe connections thoroughly for gas leaks.
- Page 8 – INSTALLATION; gases generated by the unit.
- Page 10 – NOTICE
- Page 11 – CLEANING; The gas fired tilting kettle should be cleaned after each use.
- Page 12 – To obtain access to the pressure switch, remove the front panel.
- Page 14 – Unit does not come on:; Tilt micro switch out of alignment or faulty.; Unit is on electrically but does not heat:; The kettle is not in the upright position.; Unit is slow to preheat and slow to recover:
- Page 16 – Clear yellow liquid. Odourless. Avoid temperatures above 450
- Page 20 – HAZARDOUS POLYMERIZATION: Will not occur.; TOXICOLOGICAL INFORMATION; (See Section 3 for Potential Health Effects. For; ECOLOGICAL INFORMATION; (For detailed Ecological data, write or call the address or; DISPOSAL CONSIDERATIONS; (See Section 15 for Regulatory Information)
- Page 21 – (Not meant to be all-inclusive – selected regulations
- Page 23 – CANADIAN REGULATIONS; This product is not a “Controlled Product” under WHMIS.; OTHER INFORMATION; MSDS STATUS: Revised to 16 section format.
1
IMPORTANT NOTES FOR INSTALLATION AND OPERATION
KLT-12G
GAS FIRED FLOOR MODEL TILTING KETTLE
INSTALLATION – OPERATION
–
MAINTENANCE
BLODGETT OVEN COMPANY
www.blodgett.com
44 Lakeside Avenue, Burlington, Vermont 05401 USA Telephone (800) 331-5842, (802) 860-3700 Fax: (802) 864-0183
S00073 Rev A (5/04)
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
5 3.0 INTRODUCTION DESCRIPTION Model KLT-12G (12 gallon capacity) gas fired, self-contained, tilting kettle. The kettle has a jacketof double-wall construction forming a sealed reservoir around the lower two-thirds of the kettle.The reservoir is charged with distilled water. The kettle is equipped w...
6 4.0 INSTALLATION INSTRUCTIONS GENERAL Gas installation to conform to local codes or in absence of local codes to the National Fuel GasCode - ANSI Z223.1 - latest edition. In Canada, installation to be according to CAN/CGA- B149.1(NAT) or CAN/CGA-B149.2 (LP) installation codes as applicable. 1. The...
7 GAS CONNECTION 1. The Serial and Rating Plate on the unit indicates the type of gas your unit is equipped to burn.DO NOT connect to any other gas type. 2. A 3/4" NPT line is provided at rear for the connection. The unit is equipped with an internalpressure regulator which is set at 4" W.C....
