Bakers Pride XX & CH - Manual
Bakers Pride XX & CH – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CONTENTS; I. INSTALLATION INSTRUCTIONS; IMPORTANT FOR FUTURE REFERENCE; Model Number Serial Number Date Purchased
- Page 3 – BE SURE TO CAP WHICHEVER SIDE IS NOT CONNECTED.; ACCEPTABLE CLEARANCES:; Series XX; I MASSACHUSETTS; All gas products must be installed by a “Massachusetts” licensed; MINIMUM CLEARANCE FROM NON-COMBUSTIBLE CONSTRUCTION
- Page 4 – FIGURE 1 Typical Ceramic Briquette Installation
- Page 5 – Wait five minutes before attempting to re-light.; ADDITIONAL INSTALLATION INSTRUCTIONS; open and unobstructed.; INSTALLATION WITH CASTERS; has been returned to its originally installed position.
- Page 6 – Optional Smoker Base; II. OPERATING INSTRUCTIONS; Helps to release the burger from the grates.
- Page 7 – IMPORTANT SAFETY INFORMATION:; AT THE END OF THE MEAL SERVICE, IF; CARE AND CLEANING OF TOP GRATES:
- Page 8 – III. TROUBLE SHOOTING GUIDE; BURNER FLAME ADJUSTMENT:
- Page 9 – IMMEDIATELY; ONE BURNER FAILS TO LIGHT:; If the pilot is not lit; Pilot will not remain lit; TROUBLESHOOTING CHART
- Page 10 – VALVE ASSEMBLY VIEWS: (; Orifice
- Page 11 – Gas Char Broiler; BAKERS; Description; Figure B; Burner / Accessories
- Page 12 – Figure A; Fish Grate
- Page 13 – Item Part # Description Item Part # Description
- Page 14 – Exploded View
- Page 15 – Page 3 of 4
- Page 16 – V. BAKERS PRIDE LIMITED WARRANTY
BAKERS PRIDE OVEN CO., INC
.
30 Pine Street
New Rochelle, NY 10801
(914) 576-0200 Phone
(914) 576-0605 Fax www.bakerspride.com
Web Address
(800)
431-2745
US & Canada
This equipment has been engineered to provide you with year round dependable service when used
according to the instructions in this manual and standard commercial kitchen practices.
P/N U6023A 9/08
INSTALLATION
AND OPERATING INSTRUCTIONS
Dante
SERIES
GAS CHAR BROILERS
Models:
XX & CH
INTENDED FOR OTHER THAN HOUSEHOLD USE
RETAIN THIS MANUAL FOR FUTURE REFERENCE
BROILER MUST BE KEPT CLEAR OF COMBUSTIBLES AT ALL TIMES
IMPORTANT INSTRUCTIONS
After the gas supply has been connected to your unit, it is extremely important to check piping for possible
leaks. To do this, use soap and water solution or solutions which are expressly made for this purpose. DO
NOT USE matches, candles, flames, or other sources of ignition since these methods are extremely
dangerous.
Post in a prominent location instructions to be followed in the event you smell gas. Obtain these instructions
from your local gas supplier.
!
!
WARNING
Improper installation, adjustment, alteration, service or maintenance can cause
property damage, injury or death. Read the Installation, Operating and
Maintenance Instructions thoroughly before installing or servicing this equipment.
!
!
FOR YOUR SAFETY
Do not store or use gasoline or other flammable vapors
and liquids in the vicinity of this or any other appliance.
CERTIFIED
R
1
MANIFOLDMANIFOLDAABURNER VALVEMANIFOLDBURNERORIFICEORIFICE HOLDERBURNERORIFICEORIFICE HOLDERBURNER VALVEVALVE EXTENSION(STRAIGHT)
FIG.4 SIDE VIEW XXE SERIESFIG.1 XXE SERIES FRONT VIEWFIG.2 CHE SERIES FRONT VIEW
A- AIR MIXER CAP HOLD-DOWN SCREWVALVE HANDLEVALVE HANDLE
MANIFOLD AND VALVE ASSEMBLY VIEWS
AIR MIXER CAPA
FLAME SENSORPILOT BURNERFLAME SENSORPILOT BURNER
AIR MIXER CAPA
Bakers Pride Oven Co.30 Pine Street, New Rochelle, NY 10801Tel :(914) 576-0200 Fax: (914) 576-0605ILLUSTRATION DGW. # 1008-30 REV. 08-04-99FIG.3 SIDE VIEW CHE SERIES
VALVE EXTENSION(CURVED)MANIFOLDAIR MIXER CAPAIR MIXER CAP
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 CONTENTS I. INSTALLATION INSTRUCTIONS SECTION ITEM PAGE 1 General Description 3 2 Installation 3 3 Clearances 3 4 Gas Connection 3 5 Burners 4 6 Radiants 4 7 Top Grates 5 8 Lighting 5 9 Griddle Plates 5 10 Additional Installation Requirements 5 11 Installation with Casters 5 12 Optional Smoker Box...
4. GAS CONNECTION: The gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. water column for natural gas or 10 in. water column for propane gas. No pressure regulator is required for propane gas in Canada...
The broiler and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of ½ psig (3.45 kPa). The broiler must be isolated from the gas supply piping system by closing its individual manual shutoff val...
