Amtrol 600-LBC - Manual

EXTROL

®

LBC SERIES

PRESSURIZED EXPANSION TANKS (ASME)

INSTALLATION & OPERATION INSTRUCTIONS

Models 35-LBC through 600-LBC

READ CAREFULLY THE PRODUCT

INSTALLATION & OPERATION INSTRUCTIONS.

FAILURE TO FOLLOW THE INSTRUCTIONS AND WARNINGS IN

THE MANUAL MAY RESULT IN SERIOUS OR FATAL INJURY AND/

OR PROPERTY DAMAGE, AND WILL VOID THE PRODUCT

WARRANTY. THIS PRODUCT MUST BE INSTALLED BY A

QUALIFIED PROFESSIONAL. FOLLOW ALL APPLICABLE LOCAL

AND STATE CODES AND REGULATIONS, IN THE ABSENCE OF

SUCH CODES, FOLLOW THE CURRENT EDITIONS OF THE

NATIONAL PLUMBING CODE AND NATIONAL ELECTRIC CODE,

AS APPLICABLE.

EXPLOSION OR RUPTURE HAZARD. THE

EXPANSION TANK MUST BE OPERATED SO

THAT THE PRESSURE DOES NOT EXCEED THE MAXIMUM

WORKING PRESSURE.
CALIFORNIA PROPOSITION 65 WARNING!

This product contains a

chemical known by the State of California to cause cancer and to cause

birth defects or other reproductive harm. (California Installer/Contractor

- California law requires that this notice be given to consumer/end user

of this product.)

For more information: www.amtrol.com/prop65.html

EXPLOSION OR RUPTURE HAZARD

A relief

valve must be installed to prevent pressure in

excess of local code requirement or maximum working pressure

designated in the Product Manual, whichever is less. Do not expose

Product to freezing temperatures or temperatures in excess of 240° F.

Do not adjust the pre-charge or re-pressure this Product except for any

adjustments required at the time of initial installation, especially if

Product corroded, damaged or with diminished integrity. Adjustments to

pre-charge must be done at ambient temperature only. Failure to

properly size the Product or follow these instructions may result in

excessive strain on the system lead to Product failure, serious or fatal

personal injury, leakage and/or property damage.

Potable Water and Radiant Heating Warning.

This Product must not be used in radiant heating,

potable water or open systems of any kind. These systems contain

oxygenated water which will cause internal corrosion and premature

Product failure. Use a Therm-X-Trol

®

for potable water systems and a

Radiant Extrol

™

for radiant heating systems. Mount vertically only. Do

not install on dead-end pipe.

NOTE:

Inspect for shipping damage and notify freight carrier or store where purchased immediately if damage is present. To avoid risk of personal

injury and property damage, if the product appears to be malfunctioning or shows signs of corrosion, call a qualified professional immediately. Current

copies of the Product manual can be viewed at www.amtrol.com. Use proper safety equipment when installing.

THIS IS THE SAFETY ALERT SYMBOL. IT IS USED TO ALERT YOU TO POTENTIAL PERSONAL INJURY AND OTHER

HAZARDS. OBEY ALL SAFETY MESSAGES THAT FOLLOW THIS SYMBOL TO REDUCE THE RISK OF PERSONAL

INJURY AS WELL AS PROPERTY DAMAGE.