York 048 & 060 - Manual

York 048 & 060

York 048 & 060 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 2 – TABLE OF CONTENTS
  • Page 4 – Unitary Products Group
  • Page 5 – PRODUCT NOMENCLATURE; INSTALLATION SAFETY INFORMATION:; Local plumbing and waste water codes.
  • Page 6 – LOCATION; Unit is designed for outdoor installation only.; RIGGING AND HANDLING; UNIT MODEL NUMBER
  • Page 8 – FILTERS
  • Page 9 – TYPICAL POWER WIRING; SINGLE STAGE
  • Page 10 – ELECTRIC HEAT; MUST BE USED; so that water or moisture; TABLE 2: CONTROL WIRE SIZES; Wire Size
  • Page 11 – ECONOMIZER/MOTORIZED DAMPER AND RAIN HOOD; TABLE 3: ELECTRIC HEATER CFM LIMITATIONS; UNITMODEL SIZE NOMINAL
  • Page 12 – MINIMUM POSITION ADJUSTMENT; FIGURE 4 - ENTHALPY SETPOINT ADJUSTMENT
  • Page 13 – FIGURE 6 - FOUR AND SIX POINT LOADING; DIMENSION; TABLE 5: BCH 4 POINT LOADS WEIGHT DISTRIBUTION; TABLE 6: BCH 6 POINT LOADS WEIGHT DISTRIBUTION; UNIT
  • Page 14 – TABLE 7: PHYSICAL DATA
  • Page 19 – TABLE 11: ELECTRIC HEAT CORRECTION; NOMINAL VOLTAGE; TABLE 12: VOLTAGE LIMITATIONS; POWER SUPPLY
  • Page 20 – FIGURE 8 - UNIT WITH ECONOMIZER RAINHOOD
  • Page 21 – TABLE 14: MINIMUM CLEARANCES
  • Page 25 – TABLE 19: BELT DRIVE BLOWER MOTOR AND DRIVE DATA
  • Page 26 – PHASING; The supply air CFM must be within the limitations; TABLE 20: STATIC RESISTANCES; FIGURE 12 - BELT ADJUSTMENT; PROCEDURE FOR ADJUSTING BELT TENSION:
  • Page 27 – OPERATION; SEQUENCE OF OPERATIONS OVERVIEW; CONTINUOUS BLOWER; FIGURE 13 - PRESSURE DROP ACROSS COIL
  • Page 28 – COOLING OPERATION ERRORS
  • Page 29 – LOW-PRESSURE LIMIT SWITCH; SAFETY CONTROLS; A suction line freezestat to protect against low; COMPRESSOR PROTECTION
  • Page 30 – FORCED DEFROST
  • Page 31 – HEATER
  • Page 32 – TROUBLESHOOTING
  • Page 34 – For units without economizers; UNIT FLASH CODES; MAINTENANCE; NORMAL MAINTENANCE
  • Page 35 – MOTORS
Loading the manual

INSTALLATION
MANUAL

CAUTION:

READ ALL SAFETY GUIDES BEFORE YOU
BEGIN TO INSTALL YOUR UNIT.

SAVE THIS MANUAL

SUNLINE 2000™

SINGLE PACKAGE HEAT PUMP

BCH 036, 048 & 060

177820-YIM-A-0506

CONTENTS

GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

SAFETY CONSIDERATIONS . . . . . . . . . . . . . . . . . 4

INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

REFERENCE. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

RENEWAL PARTS . . . . . . . . . . . . . . . . . . . . . . . . . 4

APPROVALS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4

PRODUCT NOMENCLATURE . . . . . . . . . . . . . . . . 5

INSTALLATION . . . . . . . . . . . . . . . . . . . . . . . . . . . 5

OPERATION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

START-UP (COOLING) . . . . . . . . . . . . . . . . . . . . 31

TROUBLESHOOTING . . . . . . . . . . . . . . . . . . . . . 32

MAINTENANCE . . . . . . . . . . . . . . . . . . . . . . . . . . 34

See the following page for a complete Table of Contents.

NOTES, CAUTIONS AND WARNINGS

The installer should pay particular attention to the words:

NOTE

,

CAUTION

, and

WARNING

. Notes are intended to

clarify or make the installation easier. Cautions are given
to prevent equipment damage. Warnings are given to
alert installer that personal injury and/or equipment dam-
age may result if installation procedure is not handled
properly.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - TABLE OF CONTENTS

177820-YIM-A-0506 2 Unitary Products Group TABLE OF CONTENTS GENERAL . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 SAFETY CONSIDERATIONS . . . . . . . . . . . . . . . . . . 4 INSPECTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 REFERENCE . . . . . . . . . ...

Page 4 - Unitary Products Group

177820-YIM-A-0506 4 Unitary Products Group GENERAL YORK Model BCH units are single package heatpumps. These are designed for outdoor installation ona rooftop or slab. The units are completely assembled on rigid, perma-nently attached base rails. All piping, refrigerantcharge, and electrical wiring i...

Page 5 - PRODUCT NOMENCLATURE; INSTALLATION SAFETY INFORMATION:; Local plumbing and waste water codes.

177820-YIM-A-0506 Unitary Products Group 5 PRODUCT NOMENCLATURE INSTALLATION INSTALLATION SAFETY INFORMATION: Read these instructions before continuing this appli-ance installation. This is an outdoor combination heat-ing and cooling unit. The installer must assure thatthese instructions are made av...

Other York Models

All York Other