Page 2 - Statement of Commitment; 10 Admiral Boulevard
Statement of Commitment 410 Admiral Boulevard Mississauga, Ontario Canada L5T 2N6 www.vermontcastings.com For more information about our growing family of barbecue grills, fireplaces, and outdoor products, please visit our website at: - A CFM Company - TM Congratulations and thank you for your purch...
Page 3 - Table of Contents; Chapter 1 - INSTALLATION
Table of Contents Chapter 1 - INSTALLATION Necessary Information . . . . . . . . . . . . . . . . . . . . . . . . . . .Choosing a Safe Location . . . . . . . . . . . . . . . . . . . . . . . . .Portable L.P. Gas Grills . . . . . . . . . . . . . . . . . . . . . . . . . . . L.P. Gas Dealer Instructions ...
Page 4 - Installation; Chapter; Choosing a Safe Location; Portable Gas Grill
· Do not operate this barbecue in garages, breeze ways, sheds or any enclosed area. · · · · · Operating this or any gas-fired appliance in an enclosed area can produce a build-upof carbon-monoxide, which could result ininjury or death. or, in the absence of local codes, with either the National Fuel...
Page 5 - Barbecue Grills
5 The L.P. Fuel Supply System The L.P. Fuel Supply System Hot drippings from cooking food could damage the fuel supply system. Liquid Propane (abbreviated L.P.) gas is stored under high pressure inside a cylinderand will vaporize when released. It isimportant that there are no leaky connectionson th...
Page 8 - Take These Instructions to the L.P. Gas Dealer
Example B Type 1 (cut away to see fitting) Example A CGA-510 POL Filling a Type 1 Cylinder Valve Example A: shows a CGA-510 POL fitting. Example B: shows using a Type 1 POL fitting. The L.P. gas cylinder has a Type 1 cylinder valve with a back-check module in its outletthat will not permit gas to fl...
Page 9 - Assembly Instructions
Getting Started Unpacking the Grill Parts Liquid Propane Models Natural Gas Models 1. Please follow the steps in the order that they are presented. 2. Assemble the grill where you plan to use it.3. You may want to place an old towel or cloth at the assembly site to prevent nuts andbolts from becomin...
Page 10 - Assembly Step 1 - Identifying the Grill Parts
1 0 Assembly Step 1 - Identifying the Grill Parts handlestandoff (2) handle (1) warming rack (1) cast ironcooking grids (1) rock grate (1) side table (2) base (1) 6100 series cylinder retainerwire (1) (2 locking casters and2 non-locking castersInstalled) 8100 series (2) grill lid (1) grill bottomass...
Page 11 - Assembly Step 2; - Attach the Base to the Pillar
Tools Needed: 3/8” wrench 7/16” wrench 1. 2. 3. 4. 5. 11 Assembly Step 2 - Attach the Base to the Pillar Lock the pre-assembled casters on base bypushing down on the latch. Set the pillar upside down. Set the base upside down onto the pillarbottom as shown, aligning the holes in thebase with holes i...
Page 12 - Assembly Step 3; - Attach Grill Bottom to Pillar
1. 2. 3. 12 Assembly Step 3 - Attach Grill Bottom to Pillar Working from the back (open) side of the pillar,set the heat shield on top of the pillar. Set the grill bottom on top of the heat shield. Lineup the burner tubes with the control valve orificesinside the pillar. Adjust the grill bottom and ...
Page 14 - Assembly Step 4; - Attach the Side Tables
14 Assembly Step 4 - Attach the Side Tables 1. 2. 3. USE HARDWARE BAG C : 1/4-20 x 3/4” bolt (8) 1/4-20 hex nut (8) LOCATE THESE PARTS: 7/16” wrench Tools Needed: 3/8” wrench side table (2) Insert the 3/4” boltsthrough the holes inthe support bracketsof the side table. Attach the side tableto the fo...
Page 15 - Assembly Step 5; - Assemble the Grill Lid
15 Assembly Step 5 - Assemble the Grill Lid 1. 2. 3. 4. Place the heat indicator onto the front of thegrill lid, lining up the 3 prongs with the 3mounting holes. From the inside of the lid, secure the heatindicator with the 2 push nuts. Position the back of the lid so that the rearholes are in line ...
Page 17 - Assembly Step 6; - Installing the Internal Grill Parts
17 Assembly Step 6 - Installing the Internal Grill Parts cast ironcooking grids6000 series (1)80 (2) 00 series LOCATE THESE PARTS: rock grate (1) warming rack (1) ceramic briquettes (1 package) 1. 2. Place the single rock grate into the grillbottom. Open the package containing theceramic briquettes ...
Page 21 - Natural Gas Grills - Connecting to Natural Gas
A quick-connect coupling sleeve with 3/8” female end is provided. Install the connectorsocket at the pipe end, after the shut-off valve.This must be installed where the grill will be inuse. It is important to observe the safety guidelines for choosing a safe location. Thegas supply must be shut off ...
Page 23 - Use and Care Directions; Lighting Instructions
Use and Care Directions 3 Chapter 23 Lighting Instructions Leak Testing theFuel Supply System Replacement Parts Portable Gas Grill ( ) VC0620P VC0680P VC0680N ( ) 6000, 8000 Series
Page 24 - Leak Testing
Perform a leak test each time the gas supply cylinder is connected to the regulator.Leak test any time a part of the gas systemis replaced. Perform a leak test at least onceeach year whether the L.P. gas supplycylinder has been disconnected or not. Have a dealer check the cylinder for deterioration ...
Page 27 - Using Your Gas Grill
Holes in Burner Holes in Burner GOOD FLAME BAD FLAME Yellow Yellow Blue Blue FLAME CHECK Checking the Burner Flame TO BREAK IN A NEW GRILL BURNER'S FLAME Before using it for the first time; operate the grill with lid closed on a low setting for about15 minutes. This will help burn away oil andthe sm...
Page 28 - Caring for Your Gas Grill
CARING FOR YOUR GRILL REGULAR CLEANING AND UPKEEP Regular care of your grill will help keep it operating properly. Cleaning or maintenancemay be done only when the grill is cool and withthe fuel supply turned off. Clean grill parts andtighten loose hardware as needed. Do not put grill parts in a sel...
Page 29 - Cleaning and Maintenance
Inspect and clean the burner regularly. Remove grill components from the grill bottom necessary toget to the burner inside. Use a wire bristle brushto clean the burner surface. A straightened paperclip is useful to remove debris from the smallburner ports. Spiders and other insects are known to some...
Page 31 - Model 6000 Series Components
Model 6000 Series Components 6000 Series Parts 1 PILLAR ASSEMBLY 1 BASE ASSEMBLY 1 quantity consisting of: Natural Gas Model only: consisting of: 1111 pkg 1118112 14121121 1 122 BOTTOM / BURNER ASSEMBLY consisting of: Grill LidRock GrateCast Iron Cooking GridCeramic Briquettes Cast Brass BurnerVentu...
Page 32 - Model 8000 Series Components
Model 8000 Series Components 32 8000 Series Parts 1 PILLAR ASSEMBLY 1 BASE ASSEMBLY 1 quantity consisting of: Natural Gas Model only: consisting of: 1121 pkg 1181 14121121 1 122 BOTTOM / BURNER ASSEMBLY consisting of: 12 Grill LidRock GrateCast Iron Cooking GridsCeramic Briquettes Cast Brass BurnerV...
Page 33 - Gas Grill Troubleshooting Guide
_______________________________________________________________________________________ insect regulator hose-to-tank connection are heard ______________________________________________ insect _______________________________________________________________________________________ insect Burner Will ...
Page 35 - BEEF; Recipes; Outdoor Cooking
DISAPPEARING SHISH KEBOBS 1/2 cup ketchup1/2 cup sugar1/2 cup soy sauce1 teaspoon garlic powder1 teaspoon ground ginger2 pounds boneless beef sirloin steak (1-1/2 inches thick),cut into 1-1/2-inch cubes 1/2 fresh pineapple, trimmed and cut into 1-inch chunks 2 to 3 small zucchini, cut into 1-inch ch...
Page 36 - PORK; POULTRY
PORK BEST PORK RIBS HMM - HMM HAM STEAK GRILLED HAM & SWISS SANDWICHES 3 pounds country-style pork ribs1/2 teaspoon garlic salt1/2 teaspoon pepper1 cup ketchup1/2 cup packed brown sugar1/2 cup honey1/4 cup spicy brown mustard2 tablespoons Worcestershire sauce1-1/2 teaspoons liquid smoke, optiona...
Page 37 - SIDE DISHES
SIDE DISHES RICE ON THE SIDE AU GRATIN POTATO POUCHES GRILLED BREADS 1-1/3 cups uncooked instant rice1/3 cup sliced fresh mushrooms1/4 cup chopped green pepper1/4 cup chopped onion1/2 cup chicken broth1/2 cup water1/3 cup ketchup1 tablespoon butter or margarine 4 cups frozen O'Brien potatoes (16 oun...
Page 39 - Manufacturer’s Limited Warranty
Manufacturer’s Limited Warranty The Vermont Castings grill is guaranteed against broken or damaged parts at the timeof purchase. Components are guaranteed against defect as follows: All cast-aluminumparts are warranted against burn through, rust, and structural failure excluding paint,neglect, or ab...
