TOA SSDV-3328 - Manual

TOA SSDV-3328

TOA SSDV-3328 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
Page: / 36

Table of Contents:

  • Page 2 – TABLE OF CONTENTS; Please read and understand these; Millivolt; WARNING
  • Page 3 – must be disconnected; greater; by closing their; less than; Table 6
  • Page 4 – CHUSETTS REQUIREMENTS; Massachusetts Horizontal Vent Re-; Flame Height
  • Page 5 – see; Do
  • Page 6 – Figure 4; Typical Locations; This appliance may be installed in an after-; CAUTIONS
  • Page 7 – VENT TERMINATION CLEARANCES; These instructions should be used as a guide-; Figure 5; Horizontal Vent Termination Clearances; Termination Heights For Vents; Side Elevation View; Figure 6
  • Page 8 – Figure 7; EXTERIOR HORIZONTAL VENT TERMINATION CLEARANCE REQUIREMENTS
  • Page 9 – MINIMUM CLEARANCES TO COMBUSTIBLES; Table 8
  • Page 10 – TYPICAL INSTALLATION SEQUENCE; Pressure Relief Plates; STEP 2. ROUTING GAS LINE; Control Compartment Access / Louver Panel
  • Page 11 – FIREPLACE SPECIFICATIONS; Vent Size; Vertical Venting Through the Ceiling:; Frame ceiling opening; Top View; Notes; required framing depth dimension
  • Page 12 – Table 9; Proper Sizing of Gas Line
  • Page 13 – Approved Vent Components; on
  • Page 14 – Model
  • Page 15 – Pages
  • Page 17 – Ratio V to H ratio is 1:2; VERTICAL VENT FIGURES/TABLES; rate sections of concentric flexible
  • Page 18 – Top Vent - THREE ELBOWS; Figure 31, and Figures 34 to 40 on Pages
  • Page 19 – TYPICAL HORIZONTAL VENT INSTALLATION; refer to Figure
  • Page 20 – including the use of silicone caulking where required.; Step B; IMPORTANT; Termination Guard
  • Page 21 – Wall; Under no circumstances, may separate sections of; HORIZONTAL VENT FIGURES/TABLES; zontal vent run is needed, then; Termination Kit Only
  • Page 22 – See Table 12 on Page 21 as an aid in venting component
  • Page 24 – SECuRE FLEX
  • Page 25 – Step 4. FIELD WIRING; A. SIT and Honeywell Millivolt Wiring; WIRING - OPTIONAL FORCED AIR; Caution: do not; B. Electronic Wiring; See
  • Page 26 – Schematic Representation Only; CAUTION; ground screw located on the outlet box. See; Step 6. CONNECTING GAS LINE; Figure; Secure all joints tightly using appropriate; Gas; Gas Flex Line Connector; GAS CONNECTION
  • Page 27 – TEST ALL CONNECTIONS FOR GAS LEAKS; Never use an open flame to; CONTROL COMPARTMENT ACCESS/; Piezo; TION; can be found in the control compartment; SIT and Honeywell Millivolt Appliance; Lower Control
  • Page 28 – Proper twig placement is critical in the
  • Page 29 – REFERENCE; Bag of Glowing; Glowing Embers
  • Page 30 – Step 9. INSTALLING THE GLASS DOOR; Ensure front glass panels are in; Reinstalling Control
  • Page 31 – Main Burner Factory Air Shutter; Burner Air Shutter Adjustment; HOOD INSTALLATION; Page 6; for Cold Climate Insulation; The air shutter door and nearby appliance surfaces are; Burner Air Shutter Adjustment Procedure
  • Page 32 – INSTALLATION ACCESSORIES
  • Page 33 – Item; Open Top Shroud Kits; Closed Top Shroud Termination Kits
  • Page 34 – GAS CONVERSION KITS; * All compressed flex vents can be expanded up to two times.
  • Page 35 – NA; La conversion devra être effectuée
Loading the manual

US

INSTALLATION

INSTRUCTIONS

Millivolt Models

Electronic Models

MODELS

P/N 700,043M REV. A 06/2008

DIRECT VENT GAS FIREPLACE HEATERS

DIRECT VENT

SSDV-3328 SERIES

SSDVT-3328CNM

SSDVR-3328CNM

A French manual is available upon request. Order P/N 700,043CF
Ce manuel d’installation est disponible en francais, simplement en

faire la demande. Numéro de la pièce 700,043CF.

This appliance may be installed in an aftermarket

permanently located, manufactured home (USA

only) or mobile home, where not prohibited by

local codes. This appliance is only for use with

the type of gas indicated on the rating plate. This

appliance is not convertible for use with other

gases, unless a certified kit is used.

In the Commonwealth of Massachusetts:

•

Installation must be performed by a licensed plumber or

gas fitter;

• See Table of Contents for location of additional Com-

monwealth of Massachusetts requirements.

FOR YOUR SAFETY: Do not store or use gasoline

or other flammables or liquids in the vicinity of

this or any other appliance.
FOR YOUR SAFETY: What to do if you smell gas:
• DO NOT light any appliance.

• DO NOT touch any electrical switches.

• Do not use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow your gas suppliers

instructions.

• If your gas supplier cannot be reached, call

the fire department.
Installation and service must be performed by

a qualified installer, service agency or the gas

supplier.

WARNING: IF THE INFORMATION IN THIS MANUAL

IS NOT FOLLOWED EXACTLY, A FIRE OR EXPLO-

SION MAY RESULT CAUSING PROPERTY DAMAGE,

PERSONAL INJURY OR LOSS OF LIFE.

POUR VOTRE SÉCURITÉ: Ne pas entreposer ni

utiliser d'essence ni d'autre vapeurs ou liquides

inflammables dans le voisinage de cet appareil ou

de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez

une odeur de gaz:
• Ne pas tenter d'allumer d'appareil.

• Ne touchez à aucun interrupteur. Ne pas vous

servir des téléphones se trouvant dans le bati-

ment où vous vous trouvez.

• Evacuez la piéce, le bâtiment ou la zone.

• Appelez immédiatement votre fournisseur de

gaz depuis un voisin. Suivez les instructions du

fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de

gaz, appelez le service dos incendies.

L'installation et service doit être exécuté par un

qualifié installeur, agence de service ou le fournis-

seur de gaz.

AVERTISSEMENT: ASSUREZ-VOUS DE BIEN

SUIVRE LES INSTRUCTIONS DONNÉ DANS CETTE

NOTICE POUR RÉDUIRE AU MINIMUM LE RISQUE

D'INCENDIE OU POUR ÉVITER TOUT DOMMAGE

MATÉRIEL, TOUTE BLESSURE OU LA MORT.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

SSDVT-3328CNE

SSDVR-3328CNE

OTL Report No. 116-F-29-5

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - TABLE OF CONTENTS; Please read and understand these; Millivolt; WARNING

2 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. TABLE OF CONTENTS Packaging .........................................Page 2Introduction ......................................Page 2General Information ..........................Page 2Requirements for the Commonwealth of Massachusetts .Page 4New Yor...

Page 3 - must be disconnected; greater; by closing their; less than; Table 6

3 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. These appliances and their individual shut-off valves must be disconnected from the gas supply piping system during any pressure testing of that system at pressures greater than 1/2 psig (3.5 kPa) . These appliances must be isolated from the gas sup...

Page 4 - CHUSETTS REQUIREMENTS; Massachusetts Horizontal Vent Re-; Flame Height

4 NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE. NEW YORK CITY, NY AND MASSA- CHUSETTS REQUIREMENTS These appliances are approved for instal- lation in the following USA locations listed in the following: Massachusetts - Installation of these fireplaces are ap- proved for installation in the US st...

Other TOA Models

All TOA Other