Roberts-Gordon CTCU 11 - Manual
Roberts-Gordon CTCU 11 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – TABLE OF CONTENTS
- Page 5 – TABLE OF FIGURES; Figure 1: Installation Clearances and Clearances to
- Page 7 – COMBAT; Product Approval
- Page 8 – SECTION 1: HEATER SAFETY; * Halogenated Hydrocarbons; National Standards and Applicable Codes; CAUTION; Do not use heater in an area containing corrosive
- Page 9 – See Page 5, Section 4
- Page 10 – WARNING; Clearances to Combustibles; * Heaters may be mounted at a higher level if destratification
- Page 11 – SECTION 4: SPECIFICATIONS; Model; End View
- Page 12 – Reduce the maximum length stated by 1 m for each 90° bend installed.
- Page 13 – SECTION 5: HEATER INSTALLATION; For typical suspension,; Figure 2: Suspension Methods
- Page 14 – Figure 3: Shelf Mounting and Hanging Suspension; Hardware provided to construct mounting bracket assembly only.; Push in
- Page 15 – on
- Page 16 – Figure 6: Vertical and Horizontal Flue Termination - Type B
- Page 17 – SECTION 7: AIR SUPPLY; per kilowatt of total rated heat input and; Building Ventilation; and local and national
- Page 18 – SECTION 8: GAS PIPING; Fire Hazard; Option
- Page 19 – SECTION 9: WIRING AND ELECTRICAL INFORMATION; k H
- Page 20 – SITE WIRING
- Page 21 – SECTION 10: COMMISSIONING
- Page 22 – Figure 9: Automatic Burner Control Box Sequence; START; *Purge time begins at pressure switch change over.
- Page 23 – Check Gas Rate
- Page 24 – See
- Page 25 – Simple Fault Finding; The time and/or temperature controls are not
- Page 26 – Installation Code and Annual Inspections:; All
- Page 27 – SECTION 13: CONVERSION BETWEEN GASES
- Page 28 – SECTION 14: TROUBLESHOOTING; Start; Conduct Commissioning procedure as shown
- Page 29 – Troubleshooting For Automatic Ignition Burner Systems; WARN
- Page 30 – Troubleshooting for Flame Supervision System
- Page 31 – Troubleshooting for Solenoid Valves
- Page 32 – SECTION 15: REMOVAL AND REPLACEMENT PARTS; See warnings and notes; Burner Components; Remove the gas supply pipe at the heater inlet.
- Page 33 – Burner Compartment; MODEL
- Page 34 – Ignition Electrode and Flame Probe; Burner Compartment
- Page 35 – Flue Fan Vertical Installation; Carry out a commission after working on or changing a flue fan.; Refit in reverse order.
- Page 36 – See Page 15, Section; Pressure Switch
- Page 37 – Ignition Control; Remove the screws
© Copyright 2006 Roberts-Gordon, LLC
Quality in Any Language™
C mbat
®
Installation, Commissioning,
Operation & Service Manual
Models CTCU 7
CTCU 11
CTCU 15
CTCU 22
CTCU 27
CTCU 32
P/N 111100UK Rev B 10/06
Compact Tubular Unit Heaters
WARNING
FOR YOUR SAFETY
If you smell gas:
1. Open windows.
2. DO NOT try to light any appliance.
3. DO NOT use electrical switches.
4. DO NOT use any telephone in
your building.
5. Leave the building.
6. Immediately call your local gas
supplier after leaving the building.
Follow the gas suppliers
instructions.
7. If you cannot reach your gas
supplier, call the Fire Department.
Fire Hazard
Do not store or use petrol or other
flammable vapours and liquids in the
vicinity of this or any other appliance.
Some objects will catch fire or explode
when placed close to heater.
Failure to follow these instructions can
result in death, injury or property
damage.
WARNING
Installation must be done by a registered installer/
contractor qualified in the installation and service
of gas-fired heating equipment or your gas supplier.
Improper installation, adjustment, alteration, service
or maintenance can result in death, injury or property
damage. Read the installation, operation and service
manual thoroughly before installing or servicing
this equipment.
Installer
Please take the time to read and understand
these instructions prior to any installation.
Installer must give a copy of this manual to the owner.
Owner
Keep this manual in a safe place in order to provide
your serviceman with necessary information.
Roberts-Gordon Europe Limited
Oxford Street
Bilston, West Midlands WV14 7EG UK
Telephone: +44(0) 1902 494425
Fax: +44(0) 1902 403200
Service Telephone: +44(0) 1902 498733
Service Fax: +44(0) 1902 401464
E-mail: [email protected]
E-mail: [email protected]
www.rg-inc.com
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
© 2006 Roberts-Gordon, LLC All rights reserved. No part of this work covered by the copyrights herein may be reproduced or copied in any form or by any means - graphic, electronic, or mechanical, including photocopying, recording, taping or information storage and retrieval systems - without the wri...
TABLE OF FIGURES Figure 1: Installation Clearances and Clearances to Combustibles.............................................................. 4 Figure 2: Suspension Methods ................................................. 7Figure 3: Shelf Mounting and Hanging Suspension .................. 8Figure...
1 COMBAT ® Compact Tubular Unit Heaters are high efficiency heaters and are listed on the Enhanced Capital Allowance Scheme ’Energy Technology Product List’. The ETL symbol is a UK registered certification mark of The Carbon Trust. Product Approval ROBERTS GORDON ® appliances have been tested and CE...
