Roberts-Gordon CTU 22 TO 115 - Manual

Roberts-Gordon CTU 22 TO 115

Roberts-Gordon CTU 22 TO 115 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
Page: / 51

Table of Contents:

  • Page 3 – TABLE OF CONTENTS; Distribution Duct Work for CTUB, CTUC and CTUD
  • Page 5 – TABLE OF FIGURES; Figure 1: Installation Clearances and Clearances to
  • Page 8 – SECTION 1: HEATER SAFETY; CAUTION; Do not use heater in an area containing corrosive; * Halogenated Hydrocarbons; National Standards and Applicable Codes
  • Page 9 – See Page 5, Section 4
  • Page 10 – WARNING; COMBAT; Clearances to Combustibles
  • Page 11 – SECTION 4: SPECIFICATIONS; Rear View
  • Page 12 – End View; Inlet and outlet duct spigot fitted with 30 mm flange.
  • Page 13 – General Technical Data Table; maximum length stated by 1 m for each 90° bend installed.
  • Page 14 – Technical Data Table; Appliance Category II; Gas rates corrected to standard conditions 1013.25 mbar 15° C.
  • Page 15 – SECTION 5: HEATER INSTALLATION; For typical suspension; Figure 2: Suspension Methods
  • Page 16 – . The joints between the flue
  • Page 17 – Figure 5: Vertical and Horizontal Flue Termination - Type B; Appliances
  • Page 18 – See Page
  • Page 19 – SECTION 8: OPTIONAL HEATER CONFIGURATIONS; on Page
  • Page 20 – SECTION 9: GAS PIPING; To reduce pressure loss, use; Option
  • Page 21 – SECTION 10: WIRING AND ELECTRICAL INFORMATION; All heaters and controls must be correctly earthed.; Models; ROBERTS GORDON; A room thermostat or ROBERTS GORDON
  • Page 22 – IGNITION MODULE
  • Page 23 – SITE WIRING
  • Page 27 – For external fan wiring,
  • Page 28 – SITE
  • Page 29 – CTUD External Motor Alternative Wiring; Frost
  • Page 30 – SECTION 11: COMMISSIONING; through Page; Mechanical Checks
  • Page 31 – Figure 10: Automatic Burner Control Box Sequence; CLOSE; *Purge time begins at pressure switch change over.
  • Page 32 – on; Check Gas Rate
  • Page 33 – External Controls; Give this manual to the user.
  • Page 34 – Press to reset
  • Page 35 – Simple Fault Finding
  • Page 36 – See Page 36, Section
  • Page 37 – SECTION 14: CONVERSION BETWEEN GASES; See Page 35, Section
  • Page 38 – SECTION 15: TROUBLESHOOTING; Start; Conduct Commissioning procedure as shown; Installation Code and Annual Inspections:; All; equipment must be performed by a; manuals and all; ROBERTS; equipment and perform service
  • Page 39 – Troubleshooting For Automatic Ignition Burner Systems; WARN
  • Page 40 – Troubleshooting for Flame Supervision System; START; Troubleshooting for Solenoid Valves; ST
  • Page 41 – SECTION 16: REMOVAL AND REPLACEMENT PARTS; See warnings and notes; Burner Components; Section 4; See
  • Page 42 – Burner Compartment; Ensure gas tight fitting of injectors.; Burner Injectors
  • Page 43 – Ignition Electrode and Flame Probe; front view of the burner compartment.
  • Page 44 – Carry out a commission after working on or changing a flue fan.
  • Page 45 – See Page 24, Section; Pressure
  • Page 46 – Ignition Control; Remove the four screws; and Replacement
  • Page 47 – • Use only genuine ROBERTS GORDON; Figure 14: Centrifugal Fan Orientation
  • Page 51 – Attach this information to the wall near the ROBERTS GORDON
Loading the manual

WARNING

FOR YOUR SAFETY

If you smell gas:

1. Open windows.

2. DO NOT try to light any appliance.

3. DO NOT use electrical switches.

4. DO NOT use any telephone in

your building.

5. Leave the building.

6. Immediately call your local gas

supplier after leaving the building.

Follow the gas supplier’s

instructions.

7. If you cannot reach your gas

supplier, call the Fire Department.

Fire Hazard

Do not store or use petrol or other

flammable vapours and liquids in the

vicinity of this or any other appliance.

Some objects will catch fire or explode

when placed close to heater.

Failure to follow these instructions can

result in death, injury or property

damage.

WARNING

Installation must be done by a registered installer/

contractor qualified in the installation and service

of gas-fired heating equipment or your gas supplier.

Improper installation, adjustment, alteration, service

or maintenance can result in death, injury or property

damage. Read the installation, operation and service

manual thoroughly before installing or servicing

this equipment.

Installer

Please take the time to read and understand

these instructions prior to any installation.

Installer must give a copy of this manual to the owner.

Owner

Keep this manual in a safe place in order to provide

your serviceman with necessary information.

© Copyright 2007 Roberts-Gordon, LLC

Quality in Any Language™

Roberts-Gordon Europe Limited

Unit A, Kings Hill Business Park
Darlaston Road, Wednesbury
West Midlands WS10 7SH UK
Telephone: +44(0)121 506 7700
Fax: +44 (0)121 506 7701
Service Telephone: +44 (0)121 506 7709
Service Fax: +44 (0)121 506 7702
E-mail: [email protected]
E-mail: [email protected]

www.rg-inc.com

Combat

®

Installation, Commissioning,

Operation & Service Manual

Model CTU

22 to 115

P/N X407UK Rev G 10/07

Tubular Unit Heaters

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 3 - TABLE OF CONTENTS; Distribution Duct Work for CTUB, CTUC and CTUD

© 2007 Roberts-Gordon, LLC All rights reserved. No part of this work covered by the copyrights herein may be reproduced or copied in any form or by any means - graphic, electronic, or mechanical, including photocopying, recording, taping or information storage and retrieval systems - without the wri...

Page 5 - TABLE OF FIGURES; Figure 1: Installation Clearances and Clearances to

TABLE OF FIGURES Figure 1: Installation Clearances and Clearances to Combustibles ............................................................. 4 Figure 2: Suspension Methods ................................................. 9Figure 3: Flue and Roof Detail ..............................................

Page 8 - SECTION 1: HEATER SAFETY; CAUTION; Do not use heater in an area containing corrosive; * Halogenated Hydrocarbons; National Standards and Applicable Codes

COMBAT ® CTU U NIT H EATERS I NSTALLATION O PERATION AND S ERVICE M ANUAL 2 SECTION 1: HEATER SAFETY Your Safety is Impor tant to Us!This symbol is used throughout the manual to notify you of possible fire, electrical or burn hazards. Please pay special attention when reading and following the warni...

Other Roberts-Gordon Models

All Roberts-Gordon Other