Rheem Water Heater- User Manual

Rheem Water Heater

Rheem Water Heater– User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
43 Page 43
44 Page 44
45 Page 45
46 Page 46
47 Page 47
48 Page 48
49 Page 49
50 Page 50
51 Page 51
52 Page 52
53 Page 53
54 Page 54
55 Page 55
56 Page 56
57 Page 57
58 Page 58
59 Page 59
60 Page 60
61 Page 61
62 Page 62
63 Page 63
64 Page 64
65 Page 65
66 Page 66
67 Page 67
68 Page 68
69 Page 69
70 Page 70
71 Page 71
72 Page 72
73 Page 73
74 Page 74
75 Page 75
76 Page 76
77 Page 77
78 Page 78
79 Page 79
80 Page 80
Page: / 80

Table of Contents:

  • Page 2 – WARNING: Plumber – Be Aware; Refer to Warning on page
  • Page 3 – CONTENTS; HOUSEHOLDER – We recommend you read pages 4 to 20.
  • Page 4 – ABOUT YOUR WATER HEATER; MODEL TYPE; Congratulations for choosing a Rheem; HOW HOT SHOULD THE WATER BE?; C is reached in the; HOTTER WATER INCREASES THE RISK OF SCALD INJURY; C at the bathroom and ensuite. The risk of scald
  • Page 5 – TEMPERATURE ADJUSTMENT; C and a minimum temperature; WARNING
  • Page 6 – TO TURN OFF THE WATER HEATER; Open all of the hot water taps in the house (don’t forget the shower).; HOW DO I KNOW IF THE WATER HEATER IS INSTALLED CORRECTLY?; Installation requirements are
  • Page 7 – of copper and fully insulated with closed cell polymer; you must read page; have your water quality checked against the conditions
  • Page 8 – HOW LONG WILL THE WATER HEATER LAST?; page; ANODE PROTECTION; “Water Supplies”; FREEZE PROTECTION; “Warranty Exclusions”
  • Page 9 – HOW YOUR WATER HEATER WORKS; SOLAR OPERATION; shown on page
  • Page 10 – ELECTRIC BOOSTING; or timer control switch should be
  • Page 11 – “ONE SHOT CONTROL” SWITCH; electricity
  • Page 12 – TIMER CONTROL SWITCH; and if a second boost period is required
  • Page 13 – SOLAR MONITOR; GOING ON HOLIDAYS; “To Turn Off The Water Heater”
  • Page 14 – REGULAR CARE; TEMPERATURE PRESSURE RELIEF VALVE; Never block the outlet of; It is very important; Failure to do this may
  • Page 15 – EXPANSION CONTROL VALVE; The; COLLECTOR GLASS
  • Page 16 – SAVE A SERVICE CALL; Booster heating unit not operating; Check the electricity supply to; Solar Controller; “Collector Glass”; Collector area is too small
  • Page 17 – Is the relief valve discharging too much water? (Refer to
  • Page 18 – TEMPERATURE PRESSURE RELIEF VALVE RUNNING; “Temperature; must; be switched off at the isolating switch or; EXPANSION CONTROL VALVE RUNNING; it may discharge a small quantity of water instead of the
  • Page 19 – HIGH ELECTRICITY BILLS; Is the relief valve running excessively? (Refer to; ELECTRICITY TARIFFS
  • Page 20 – Warranty; DOES NOT; cover breakage of solar collector glass. Check your
  • Page 21 – INSTALLATION – SOLAR STORAGE TANK; THIS WATER HEATER IS NOT SUITABLE FOR POOL HEATING.; SOLAR WATER HEATER STORAGE TANK LOCATION; “Solar Collector
  • Page 22 – SAFE TRAY
  • Page 23 – MAINS WATER SUPPLY; (refer to diagram on page; TANK WATER SUPPLY
  • Page 24 – RAIN WATER TANK
  • Page 25 – HOT WATER DELIVERY
  • Page 26 – CIRCULATED HOT WATER FLOW AND RETURN SYSTEM; The thermostat must always; Temperature Limiting Device
  • Page 27 – REDUCING HEAT LOSSES
  • Page 28 – SADDLING - PIPE WORK; “Manual Controls”
  • Page 29 – DIMENSIONS AND TECHNICAL DATA
  • Page 30 – TYPICAL INSTALLATION – OUTDOOR LOCATION
  • Page 31 – INSTALLATION – SOLAR COLLECTORS; SOLAR COLLECTOR LOCATION; “Solar Storage Tank Location”
  • Page 32 – LATITUDE OF SOME AUSTRALIAN CITIES
  • Page 33 – PIPE LENGTHS; be of DN15 hard drawn copper pipe.
  • Page 34 – Maximum Height To Collectors; “Auxiliary Pump”
  • Page 36 – CONNECTIONS – PLUMBING; CONNECTION SIZES; Solar circuit pressure relief valve connection: R1⁄2/15; WATER INLET AND OUTLET; “Hot
  • Page 37 – PIPE SIZES; (refer to the installation diagram on
  • Page 38 – Solar Circuit Relief Valve; “Water
  • Page 39 – SOLAR INLET AND OUTLET
  • Page 40 – AUXILIARY PUMP
  • Page 41 – CONNECTIONS – ELECTRICAL; and a satisfactory megger reading is; MEGGER READING; This water heater contains electronic equipment and 500 V; An insulation test result of between 100 K; for sheathed heating elements or appliances or
  • Page 42 – ELECTRICAL CONNECTION; of use
  • Page 43 – wiring connection diagram
  • Page 45 – HOT SENSOR LEAD; The thermostat is adjustable from 60; “Auxiliary Pump – Electrical Connection”
  • Page 46 – MANUAL CONTROLS; or
  • Page 47 – WIRING DIAGRAM
  • Page 49 – “Pipe Lengths”
  • Page 50 – AUXILIARY PUMP – PLUMBING CONNECTIONS; “Auxiliary Pump; fitted up to the connections of; installation diagram
  • Page 52 – AUXILIARY PUMP – ELECTRICAL CONNECTION; The removal of the lower front cover will expose 240 V wiring.
  • Page 53 – facing toward; the front cover opening. The connecting plug is non polarised
  • Page 54 – COMMISSIONING; “Commissioning the Solar Circuit”
  • Page 55 – SOLAR CIRCUIT; checking the drain back function of the solar circuit.; Additional Equipment; a suitable plug for one end of the hose.
  • Page 56 – Closed Circuit Fluid; Although non-toxic, the following first aid advice and procedures
  • Page 57 – PRE-COMMISSIONING WARNINGS; the maximum recommended pipe length is not exceeded.
  • Page 58 – Co; To commission and check the solar circuit:; mmissioning the Solar Circuit
  • Page 59 – Hose
  • Page 60 – Sola
  • Page 61 – “Pipe
  • Page 62 – step
  • Page 63 – “Solar Collector Location”; Drain Back Function
  • Page 64 – evel
  • Page 65 – ount of water to be added to or closed circuit fluid
  • Page 66 – War
  • Page 68 – Pressure Testing the Solar Circuit; Note
  • Page 70 – ve the clear hose from the solar storage tank when satisfied the; Remove Closed Circuit Fluid Level Hose
  • Page 71 – Circuit
  • Page 72 – LER
  • Page 74 – DRAINING THE WATER HEATER; orage Tank; notes; Solar St; at Exchanger
  • Page 76 – AN; WATER SUPPLIES; ODE
  • Page 77 – ATER HEATERS NOT INSTALLED IN ACCORDANCE WITH THE ABOVE; cold water connection detail on page
  • Page 78 – re; NDITIONS; TER HEATER WARRANTY –; reserves the right to trans; WARRANTY CO
  • Page 79 – RHEEM SOLAR WATER HEATER WARRANTY – AUSTRALIA ONLY; WARRANTY EXCLUSIONS
  • Page 80 – WARRANTY; vision Dat
Loading the manual

Owners Guide

and

Installation Instructions

Solar Premier Loline

Electric Boost Water Heater

This water heater must be installed and serviced by an authorised person.

Please leave this guide with the householder.

WARNING: Plumber – Be Aware

Use copper pipe ONLY. Plastic pipe MUST NOT be used.

It is a requirement of a solar water heater installation that all

pipe work be in copper and not plastic, due to the effects of

high water temperatures.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Other Manuals for Rheem Water Heater

Summary

Page 2 - WARNING: Plumber – Be Aware; Refer to Warning on page

Notice to Victorian Customers from the Victorian Plumbing Industry Commission. This water heater must be installed by a licensed person as required by the Victorian Building Act 1993. Only a licensed person will give you a Compliance Certificate, showing that the work complies with all the relevant ...

Page 3 - CONTENTS; HOUSEHOLDER – We recommend you read pages 4 to 20.

CONTENTS HOUSEHOLDER – We recommend you read pages 4 to 20. The other pages are intended for the installer but may be of interest. About Your Water Heater ............................................................4 How Your Water Heater Works...................................................9 Reg...

Page 4 - ABOUT YOUR WATER HEATER; MODEL TYPE; Congratulations for choosing a Rheem; HOW HOT SHOULD THE WATER BE?; C is reached in the; HOTTER WATER INCREASES THE RISK OF SCALD INJURY; C at the bathroom and ensuite. The risk of scald

ABOUT YOUR WATER HEATER MODEL TYPE Congratulations for choosing a Rheem ® water heater. Your Rheem solar Premier Loline water heater is designed for the solar collectors to be roof mounted and the solar storage tank to be installed at ground or floor level. The solar storage tank is suitable for ins...

Other Rheem Models