Raymarine RS12 - Manual

6 A60 Installation Manual CAUTION: CompactFlash Card InstallationWhen installing CompactFlash cards ensure that the card is inserted in the correct orientation. DO NOT try to force the card into position as this may result in irreparable damage to the card. CAUTION: CompactFlash Card DamageDO NOT us...

Important Information 7 EMC Conformance All Raymarine equipment and accessories are designed to the best industry standards for use in the recreational marine environment. Their design and manufacture conforms to the appropriate Electromagnetic Compatibility (EMC) standards, but correct installation...

8 A60 Installation Manual The following illustration shows typical cable suppression ferrites sometimes used with Raymarine equipment. To ensure EMC compliance, always use these ferrites, if supplied by Raymarine for use with this equipment. If not supplied by Raymarine, a ferrite is not required fo...

9 Chapter 1: Introduction This manual provides information and instructions for installing your A60 display and RS12 GPS sensor. 1.1 Selecting the Display Unit Location Your A60 can be mounted using the mounting bracket supplied, or console mounted using the optional flush mount kit. Before you inst...

10 A60 Installation Manual 1.2 What Comes in the Box Unpack the display carefully, to prevent damage. Save the carton and packing, in case the unit has to be returned for service. Mount Screws, M4 (x2) Bracket Screws, No.10 x 3/4 (x3) D9613-1 Owner’s Handbook, part no. 81295 A60 Owner’s Handbook GPS...

Chapter 1: Introduction 11 1.3 Optional Equipment The following optional items are also available to complete your system: Part No. Description E63070 DSM25, Digital Sounder Module, 200/50KHz, 500W E36017 Flush Mount Kit, A60 R69086 Network Cable, A60, 3.5m E36015 Network Cable, A60, 8.5m E36016 Net...

12 A60 Installation Manual 1.4 Unit Size The dimensions for your A60 display are as follows: D9614-1 Bracket Mount Flush Mount RANGE PAGE ACTIVE DATA MENU WPTS MOB CANCEL PWR 9.61in (244mm) 6.81in (173mm) 7.83in (199mm) 9.88in (251mm) 11.02in (280mm) 2.56in (65mm) 2.40in (61mm) .866in (22mm) 3.11in ...

13 Chapter 2: Installing the Display Unit The A60 display unit is waterproof to IPX-7 and can be installed either above or below deck using either the mounting bracket or by flush mounting into the console. 2.1 Mounting Note: The mounting bracket and the mount frame to which the bracket attaches mus...

14 A60 Installation Manual 5. Use the screws and nuts supplied to securely attach the bracket to the mount- ing surface. 6. Attach the display unit to the bracket.7. Adjust the unit angle for clear vision and tighten the knobs. Flush Mounting Flush mounting your display on the console requires the o...

16 A60 Installation Manual . Making the Cable Connections The cable connections are located on the back of the display unit as shown below: Power Input Cable (R08003) This 1.5m (5 ft) cable is supplied for connecting to your boat’s DC power supply. DC power is connected at the 3-pin POWER connector ...

Chapter 2: Installing the Display Unit 17 Power Supply The A60 is intended for use on boat’s DC power systems rated from 10.7 to 18 VDC. The power connection to the unit should be made at either the output of the battery isolator switch or at a DC power distribution panel. Power should be fed direct...

18 A60 Installation Manual Use commonly practiced methods to determine proper wire gauge based on wire length, current, and wire tables. You may also trim the power cable supplied with the A60 to reduce overall wire length. Only use enough wire to connect the unit to the power source, including a se...

19 Chapter 3: Installing the GPS Antenna The RS12 package contains the following items: 1. Low profile GPS Receiver, with 10 m (33 ft) cable2. Flush mount gasket3. Mounting studs (x2) and thumb nuts (x2)4. Pole mount kit * Note: * If you intend to mount the receiver on a pole, you will need to obtai...

20 A60 Installation Manual Cabling Route When planning the location for the unit, consider the best route for running the cable between the receiver and GPS display unit or to the rest of an integrated system. Ideally, you should try to route the cable so it is:• hidden from view• separated as far a...

Chapter 3: Installing the GPS Antenna 21 . Surface Mounting 1. Use the template supplied in this handbook to mark the two 6 mm (0.25 in) mounting holes. 2. OPTION A: If the cable is going to pass through the mounting surface drill a 19 mm (0.75 in) center hole.OPTION B:If the cable is to exit from t...

22 A60 Installation Manual Making the Cable Connections Connect the cable to the connector Labeled GPS on the back of the display unit as shown below: . D8690-1 1 2 3 4 2 3 4 Top view Underside view A B RS12 Display Unit GPS D8506-2 GPS SONAR AUX NMEA POWER 87081.book Page 22 Wednesday, December 20,...

23 Chapter 4: Maintenance 4.1 Introduction This chapter provides information on maintaining and troubleshooting your A60 GPS Chartplotter and on how to get assistance from Raymarine. At regular intervals, carry out the following servicing procedures:• Routine checks.• Cleaning the Display. Do not at...

24 A60 Installation Manual Cleaning the Display Window A coating is applied to the plastic window of your display. This makes it water repellent and prevents glare. To avoid damaging this coating, the recommended cleaning procedure must be followed. CAUTION: Please read these instructions carefully....

Chapter 4: Maintenance 25 Settings Reset The factory reset will set all values back to their original factory settings. The Waypoint and Route List databases are not reset. There are two ways to carry out a Settings Reset: using hardware keys or via the System Setup Menu. To carry out a Settings Res...

26 A60 Installation Manual Common Problems and How to Solve Them Problem Solution Display is blank 1. Make sure that the power supply cable is sound and that all connections are tight and free from corrosion.2. Check relevant fuses.3. Make sure that Brightness level is not set too low. “NO DATA SOUR...

Chapter 4: Maintenance 27 4.4 Upgrading the Display Raymarine occasionally issues software updates for adding new features and improving product performance. The A60 includes a Software Upgrade Utility for installing these updates when they become available. Product updates are generally available o...

Chapter 4: Maintenance 29 4.5 Technical Support Raymarine provides a comprehensive customer support service, on the world wide web, through our worldwide dealer network and by telephone help line. If you are unable to resolve a problem, please use any of these facilities to obtain additional help. W...

30 A60 Installation Manual Contacting Raymarine in the US You can contact Raymarine in the US either using the Raymarine world wide web as detailed above or by calling one of the telephone numbers below. Accessories and Parts You can obtain many Raymarine accessories and parts directly from your aut...

Chapter 4: Maintenance 31 If you wish to enquire about the repair status of your unit, contact the Repair Center at: 603-881-5200 extension 2118. Contacting Raymarine in Europe You can obtain Technical Support, service and accessories from your authorized Raymarine dealer, or by contacting: Raymarin...

33 Appendix: Specifications A60 LCD Color Display General ApprovalsCE - conforms to 2004/108/EC (EMC), EN60945:2002 Mounting Bracket with dash (flush) mount option Size (H x W x D) 7.8 x 11.0 x 3.1 in (199 x 280x 79 mm), bracket mounted6.8 x 9.6 x 2.4 in (173 x 244 x 61 mm), dash mounted Weight 3.09...

Appendix: Specifications 35 Interfacing DSM connection For communication with DSM25 NMEA Input - NMEA 0183 APB BWC BWR DBT DPT GLL GGA HDG HDM HDT RMA RMB RMC RTE VHW VLW VTG WPL XTE ZDA Auto Pilot sentence “B”Bearing & distance to waypoint, great circleBearing & distance to waypoint, rhumb ...

36 A60 Installation Manual RS12 GPS Antenna ApprovalsCE - conforms to 2004/108/EC (EMC) Dimensions: diameter: 3.7 in (95 mm)height: 1.2 in (30 mm); 2.4 in (62 mm) with pole mount kit Weight: 15.3 oz (0.435 kg) Cable length: 33 ft (10 m) Receiver type: SD-GPS, WAAS/EGNOS/MSAS ready, 12 parallel chann...

37 Index A A60 Bracket mounting 13 Cable connections 16 Cable runs 15 Dimensions 12 Flush mounting 14 Installation 13 NMEA cable 18 Power 17 Specifications 33 B Bracket mounting, A60 13 C Cable Connections, A60 16 Connections, RS12 22 Installation requirements 20 NMEA 18 Power 16 Running, A60 15 Cle...

GPS Antenna Mounting Template Note: Be sure to leave sufficient spacing beneath the mounting surface for the mounting nuts. Cable Exit Channel 18mm (0.7in) 6mm (0.25") dia. pilot hole 19mm (0.75") dia. for cable and plug 6mm (0.25") dia. 2 positions 18mm (0.7in) 36mm (1.4in) 36mm (1.4in)...

Raymarine World Wide Warranty Raymarine World Wide Warranty Raymarine Inc. APPLICABLE TO PRODUCTS SOLD THROUGH OFFICIAL RAYMARINE INC. DEALERS, DISTRIBUTORS AND BOAT BUILDERS WITHIN THE AMERICAS AND CARIBBEAN. Limited warranty Subject to the terms, conditions and limitations set forth in this U.S. L...

Purchased from Dealer address Installed by Installation date Owner’s name Mailing address North and South America Detach and mail this portion within 48 hours.48 hours.48 hours.48 hours.48 hours. To validate the warranty, the customer or dealer must fill in the requested information below and mail t...