Rangemaster RMDD3604 - Manual
Rangemaster RMDD3604 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Downdraft Ventilators; PLANNING
- Page 4 – Blower Installation
- Page 5 – PLAN THE WIRING; PREPARE THE DOWNDRAFT
- Page 6 – CUT COUNTERTOP OPENING
- Page 7 – MOUNT THE UNIT; INSTALL DUCTWORK
- Page 8 – INSTALL ELECTRICAL WIRING
- Page 9 – REMOTE UP/DOWN CONTROL INSTALLATION; CUT OUT; All Units; CUT OUT ON DOTTED LINE
- Page 10 – BACKSIDE OF; USE AND CARE
- Page 11 – OPERATION
- Page 12 – SERVICE PARTS
- Page 14 – LEA Y CONSERVE ESTAS INSTRUCCIONES; ADVERTENCIA; MODELO
- Page 15 – PLANIFICACIÓN; Instalación del ventilador interior; TOME MEDIDAS; Todas las unidades; Ventiladores de tiro descendente
- Page 16 – PLANEE EL SISTEMA DE CONDUCTOS
- Page 17 – PLANEE LAS ABERTURAS DEL GABINETE; Instalación del ventilador
- Page 18 – PLANEE EL CABLEADO ELÉCTRICO
- Page 19 – HAGA LA ABERTURA DE LA SUPERFICIE DEL GABINETE
- Page 20 – MONTE LA UNIDAD; INSTALE EL SISTEMA DE CONDUCTOS
- Page 21 – INSTALE EL CABLEADO ELÉCTRICO; INSTALE LA ESTUFA; MÍN
- Page 22 – INSTALACIÓN DEL CONTROL REMOTO DE ASCENSO/DESCENSO (OPCIONAL); RECORTE SOBRE LA LÍNEA PUNTEADA
- Page 23 – PARTE; USO Y CUIDADO
- Page 24 – OPERACIÓN
- Page 25 – PIEZAS DE SERVICO
- Page 26 – PIEZAS DE SERVICIO
- Page 27 – AVERTISSEMENT; LIRE ET CONSERVER CES INSTRUCTIONS; ATTENTION; Ventilateurs séries de créateur; MODÈLE
- Page 28 – PRÉPARATION; PRISE DES MESURES; Installation du ventilateur intérieur
- Page 29 – PRÉPARATION DES CONDUITS
- Page 30 – SORTIE; R É PA R ATION DU DÉCOUPAGE DE L’ARMOIRE; Installation du ventilateur; SORTIE À
- Page 31 – PRÉPARATION DU CÂBLAGE; PRÉPARATION DE LA HOTTE
- Page 32 – DÉCOUPAGE DU COMPTOIR
- Page 33 – INSTALLATION DE L’UNITÉ
- Page 34 – CÂBLAGE ÉLECTRIQUE; Tous les modèles
- Page 35 – COUPER SUR LA LIGNE POINTILLÉE
- Page 36 – UTILISATION ET ENTRETIEN
- Page 37 – UTILISATION
- Page 38 – PIÈCES DE RECHANGE
Downdraft Ventilators
Page 1
WARNING
READ AND SAVE THESE INSTRUCTIONS
WARNING
TO REDUCE THE RISK OF FIRE, ELECTRIC SHOCK, OR
INJURY TO PERSONS, OBSERVE THE FOLLOWING:
1. Use this unit only in the manner intended by the manufacturer.
If you have questions, contact the manufacturer at the address
or telephone number in the warranty.
2. Before servicing or cleaning unit, switch power off at service
panel and lock the service disconnecting means to prevent
power from being switched on accidentally. When the service
disconnecting means cannot be locked, securely fasten a
prominent warning device, such as a tag, to the service panel.
3. Installation work and electrical wiring must be done by a
qualified person(s) in accordance with all applicable codes
and standards, including fire-rated construction codes and
standards.
4. Sufficient air is needed for proper combustion and exhausting
of gases through the flue (chimney) of fuel burning equipment
to prevent backdrafting. Follow the heating equipment
manufacturer’s guideline and safety standards such as those
published by the National Fire Protection Association (NFPA),
and the American Society for Heating, Refrigeration and Air
Conditioning Engineers (ASHRAE), and the local code au-
thorities.
5. When cutting or drilling into wall or ceiling, do not damage
electrical wiring and other hidden utilities.
6. Ducted fans must always be vented to the outdoors.
7. To reduce the risk of fire, use only metal ductwork.
8. Do not install this product with the activating switch directly
behind a burner or element. Minimum distance between the
switch and the edge of the burner should be 4 inches.
9. Loose-fitting or hanging clothing should never be worn when
operating this appliance. They may be ignited by burners/
elements on cooktop.
10. Children should not be left alone or unattended in the area
where this appliance is in use.
11. This unit must be grounded.
TO REDUCE THE RISK OF A RANGE TOP GREASE FIRE:
a) Never leave surface units unattended at high settings.
Boilovers cause smoking and greasy spillovers that may
ignite. Heat oils slowly on low or medium settings.
b) Always turn hood ON when cooking at high heat or when
cooking flaming foods.
c) Clean ventilating fans frequently. Grease should not be
allowed to accumulate on fan or filter.
d) Use proper pan size. Always use cookware appropriate
for the size of the surface element.
TO REDUCE THE RISK OF INJURY TO PERSONS IN THE
EVENT OF A RANGE TOP GREASE FIRE, OBSERVE THE
FOLLOWING
a
:
1. SMOTHER FLAMES with a close-fitting lid, cookie sheet,
or metal tray, then turn off the burner. BE CAREFUL TO
PREVENT BURNS. If the flames do not go out immedi
ately, EVACUATE AND CALL THE FIRE DEPARTMENT.
2. NEVER PICK UP A FLAMING PAN - You may be burned.
3. DO NOT USE WATER, including wet dishcloths or towels
- a violent steam explosion will result.
4. Use an extinguisher ONLY if:
A. You know you have a Class ABC extinguisher, and you
already know how to operate it.
B. The fire is small and contained in the area where it
started.
C. The fire department is being called.
D. You can fight the fire with your back to an exit.
a
Based on “Kitchen Firesafety Tips” published by NFPA.
CAUTION
1. For general ventilating use only. Do not use to exhaust
hazardous or explosive materials and vapors.
2. To avoid motor bearing damage and noisy and/or unbalanced
impellers, keep drywall spray, construction dust, etc. off power
unit.
3. Clean filters and grease-laden surfaces frequently.
4. Do not repair or replace any part of this appliance unless
specifically recommended in this manual. All other servicing
should be done by a qualified technician.
5. Please read specification label on product for further informa-
tion and requirements.
MODEL
WIDTH
BLOWER
RMDD3004
30"
500 cfm Interior
RMDD3604
36"
500 cfm Interior
RMDD4804
48"
500 cfm Interior
RMDD3004EX
30"
Models 331H, 332H, 335, or 336 Exterior (purchase separately)
RMDD3604EX
36"
Models 331H, 332H, 335, or 336 Exterior (purchase separately)
RMDD4804EX
48"
Models 331H, 332H, 335, or 336 Exterior (purchase separately)
WARNING - To reduce the risk of burns or ignition of clothing by reaching across burners, the downdraft remote control MUST
be mounted in the countertop - at least 4" from the burners. See "INSTALL COOKTOP" section on page 8.
!
INSTALLER:
Save this manual for Electrical
Inspector and Homeowner to use.
NOTE:
Model RMDDRBK Remote Up/Down
Control sold separately.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Page 2 Downdraft Ventilators AIRVENT COUNTERTOP BLOWER BOX CHIMNEY TOP COOK TOP GEARMOTORCOVER TYPICAL INSTALLATION 120 VACGROUNDEDOUTLET This downdraft blower systemis designed to be used to ex-haust airborne contaminantswhen cooking with a variety ofgas or electric cooktops. It canbe mounted in is...
Page 4 Downdraft Ventilators CENTER LINEOF COUNTER CUTOUT CENTER LINE OF DUCT CUTOUT ¼" to 7 ¾" 5½ " (4¼" FOR EXTERIOR BLO WER ) 10¼" x 3½" CUTOUT (14¼" x 3½" FOR EXTERIOR BLOWER) (2½ " M AX. FO R EXT ER IOR BLO WE R) (5 " M AX. FO R E XTE RIO R BLO WE R) CENT...
Downdraft Ventilators Page 5 PLAN THE WIRING Interior Blower Installation Exterior Blower Installation 1. The Exterior Downdraft Blower system draws 6 AMPS and requires a 120 VAC, 60 Hz circuit. 2. The unit has a 18 in. long power cord with a 3-pronged plug. Plan to provide a grounded outlet in a lo...
