Polaris PR 150-34 2NV OR 2PV - Manual

Polaris PR 150-34 2NV OR 2PV

Polaris PR 150-34 2NV OR 2PV – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
Page: / 32

Table of Contents:

  • Page 2 – Your safety and the safety of others are very important.; Important Instructions; Table of Contents
  • Page 3 – INSTALLATION INSTRUCTIONS; Consumer Information; OBSERVE ALL GOVERNING CODES AND ORDINANCES.; Installer and Owner Responsibilities; Unpacking the Water Heater; Removing Packaging Materials; Excessive Weight Hazard
  • Page 4 – Location Requirements; Due to the; Figure 1: Garage Installation; Do not store or use gasoline or other; FIRE AND EXPLOSION HAZARD; Can result in serious injury or death; Site Location
  • Page 5 – CONDENSATE LINE; Condensate Trap Assembly; Figure 2: Minimum Clearance Locations; Clearances and Accessibility; Figure 3B: 3” Condensation Trap Installation
  • Page 6 – Condensate Drain Line; VENT PIPE SYSTEM; Carbon Monoxide Hazard; Venting; Figure 4: Condensate Drain
  • Page 7 – Figure 5: Correct and Incorrect Pipe Fittings
  • Page 8 – Vent Termination Locations; Use only 2 inch pipe or a 2 inch concentric vent on; Figure 6: Minimum Clearances for Inlet/Outlet and Concentric Vent; US Installations
  • Page 9 – Standard Horizontal Termination; Alternative Horizontal Termination; Figure 8A: Alternate Horizontal Termination
  • Page 11 – Figure 10A: 2 Inch Concentric Vent
  • Page 12 – Figure 8B: Alternative Horizontal Termination
  • Page 15 – Figure 14: Input Graph; Gas Input Rate; WATER PIPING SYSTEM; Piping Installation; (To prevent damage to; Corrosion and Water Quality
  • Page 16 – Figure 15: Typical One-Temperature System Piping Installation; Tempering Valve Installation; General Information; The manufacturer of this water heater
  • Page 17 – Figure 17: Air Handler Piping Installation
  • Page 18 – Explosion Hazard; Figure 18: Polaris with Auxillary Storage Tank - One or Two
  • Page 19 – GAS SUPPLY AND PIPING; Gas Requirements; Gas Piping; Figure 19: Gas Piping Installation; Gas Pressure; Important
  • Page 20 – Gas Pressure Testing; at; less
  • Page 21 – Electrical Shock Hazard; ELECTRICAL CONNECTIONS
  • Page 22 – WIRING DIAGRAM
  • Page 23 – INSTALLATION CHECKLIST; Horizontal
  • Page 24 – OPERATING YOUR WATER HEATER; Water Heater Operation; Green; Figure 21: Sequence of Operation; Thermostat Sensor
  • Page 25 – Temperature Dial; Emergency Shut Down
  • Page 26 – Water Heater Sounds; Draining and Flushing; refi ll
  • Page 28 – TROUBLESHOOTING
  • Page 29 – SOFTWARE OPERATION SEQUENCE; IGNITION CONTROL MODULE SOFTWARE OPERATION SEQUENCE
  • Page 30 – REPAIR PARTS LIST/DIAGRAM; TOOLS REQUIRED FOR SERVICING; Repair Parts List; ALL MODELS EXCEPT
  • Page 32 – POLARIS MODELS & DIMENSIONS
Loading the manual

1

This manual covers model numbers:

United States

Canada

PG10* 34-100-2NV or 2PV
PG10* 34-130-2NV or 2PV
PG10* 50-130-2NV or 2PV
PG10* 34-150-2NV or 2PV
PG10* 50-175-3NV or 3PV
PG10* 50-199-3NV or 3PV
PG10* 100-199-3NV or 3PV

PR 100-34 2NV or 2PV
PR 130-34 2NV or 2PV
PR 130-50 2NV or 2PV
PR 150-34 2NV or 2PV
PR 175-50 3NV or 3PV
PR 199-50 3NV or 3PV
PR 199-100-3NV or 3PV

* Indicates warranty period

Note:

The manufacturer of this water heater recommends that it
be professionally installed by trained and qualified service
professionals.

Polaris

®

Residential Gas

Water Heater

Installation

Instructions and

Use & Care Guide

To obtain technical, warranty or service assistance during or
after the installation of this water heater, visit our website at:

http://www.americanwaterheater.com

or call toll free:

1-800-456-9805.

When calling for assistance, please have the following
information ready:

1. Model number
2. 7 Digit product number
3. Serial number
4. Date of installation
5. Place of Purchase

Table of Contents .......................................................... 2

Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch;
do not use any telephone in your
building.

• Immediately call your gas supplier
from a neighbor’s telephone. Follow
the gas supplier’s instructions.

• If you cannot reach your gas
supplier, call the fire department.

Installation and service must be performed
by a qualified installer, service agency or
the gas supplier.

WARNING: If the information in these
instructions is not followed exactly, a fire
or explosion may result causing property
damage, personal injury or death.

6510336

December 2004

INSTALLER:

• Affi x these instructions to or adjacent to the water

heater.

OWNER:

•

Retain these instructions and warranty for future
reference. Retain the original receipt as proof of
purchase.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - Your safety and the safety of others are very important.; Important Instructions; Table of Contents

2 Your safety and the safety of others are very important. We have provided many important safety messages in this manual and on your appliance. Always read and obey all safety messages. This is the safety alert symbol. This symbol alerts you to potential hazards that can kill or hurt you and others...

Page 3 - INSTALLATION INSTRUCTIONS; Consumer Information; OBSERVE ALL GOVERNING CODES AND ORDINANCES.; Installer and Owner Responsibilities; Unpacking the Water Heater; Removing Packaging Materials; Excessive Weight Hazard

3 INSTALLATION INSTRUCTIONS Consumer Information OBSERVE ALL GOVERNING CODES AND ORDINANCES. This water heater is design-certified by CSA International as a Category IV, direct vented water heater which takes its combustion air from the outside of the structure and exhausts all products of combustio...

Page 4 - Location Requirements; Due to the; Figure 1: Garage Installation; Do not store or use gasoline or other; FIRE AND EXPLOSION HAZARD; Can result in serious injury or death; Site Location

4 Location Requirements The water heater design has been tested by CSA International and complies with ANSI Z21.10.1, Section 2.35 Flammable Vapors Resistance. In garage installation avoid damage to your water heater by installing a vehicle stop as shown in figure below. Check state and local codes ...

Other Polaris Models