Monessen CR - Manual
Monessen CR – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Designer Series Gas Fireplaces; CoNTENTS
- Page 3 – Cleaning and Maintenance; INSTaLLER; Please leave these instructions with the owner.; owNER; Please retain these instructions for future reference.; IMPoRTaNT SaFETy INFoRMaTIoN; CaRBoN MoNoxIdE PoISoNING:; RNING
- Page 4 – National Electrical; Listed vented Gas Fireplace heater; tured Home Construction and Safety Standard,; Standard for Manufactured home Installations, aNSI/NCSBCS a225.1; WARNING
- Page 6 – FIREPLaCE dIMENSIoNS
- Page 7 – It is best to build firebox framing; aFTER; the appliance is set in place. Refer to the dimensions for; FIREPLaCE FRaMING; Framing Specifications; Top view; Peninsula Framing
- Page 8 – FRaMING FIREPLaCE; FRaMING SEE ThRouGh FIREPLaCE; below for specifications.
- Page 9 – CLEaRaNCES; The combustible area above the facing must not
- Page 10 – INSTaLLaTIoN INFoRMaTIoN; PLEASE READ THE FOLLOWING CAREFULLY
- Page 11 – INSTaLLaTIoN; Figure 8
- Page 12 – oPTIoNaL ToP vENT INSTaLLaTIoN; Figure 9
- Page 13 – INSTaLLaTIoN PRECauTIoNS; until; vENTING CLEaRaNCES
- Page 14 – vENTING INSTaLLaTIoN; Horizontal Termination; FoR hoRIZoNTaL TERMINaTIoN; Horizontal Termination Configu-; FoR vERTICaL TERMINaTIoN; Installing Vent System in a Chase; INSTaLLING a vENT SySTEM IN aN ouTSIdE ChaSE
- Page 15 – GENERaL vENTING INFoRMaTIoN - TERMINaTIoN LoCaTIoN; Canadian Installations
- Page 16 – From the point of this intersection, draw a vertical line to the; Dimensions in
- Page 17 – REaR waLL vENT INSTaLLaTIoN; Noncombustible walls:
- Page 19 – The maximum number of 90° elbows per side wall instal-
- Page 21 – Refer to Page 18, Figure 17
- Page 22 – Up to two 45° elbows may be used within the
- Page 23 – Refer to Figure 32; FLaT CEILING INSTaLLaTIoN; Page
- Page 24 – Connect a section of pipe and extend up through the hole.
- Page 25 – FIREPLaCE INSTaLLaTIoN
- Page 26 – NoTE
- Page 27 – ELECTRICaL wIRING
- Page 28 – REMoTE waLL MouNTEd SwITCh; . Do not extend beyond; ELECTRICaL INSTaLLaTIoN
- Page 29 – Position the wall switch. Do not extend beyond the 15 feet of wire.; oPTIoNaL dC REMoTE SySTEMS; These instructions replace the section entitled
- Page 30 – GLaSS REMovaL
- Page 31 – LoG PLaCEMENT; on grate. Log #1 will always be to the left of the control panel.; Before you begin; with your bare hands.
- Page 32 – Position left end of bottom center back log
- Page 34 – aIR RESTRICToR adjuSTMENT; the screw all the way out.
- Page 35 – oPERaTING INSTRuCTIoNS; FoR youR SaFETy REad BEFoRE LIGhTING; INITIaL LIGhTING; Continued on next page
- Page 36 – aPPRovEd LEaK TESTING METhod; LIGhTING PILoT; NGER; LIGhTING PILoT FoR ThE FIRST TIME
- Page 37 – control knob on; OFF; LIGhTING BuRNER; MaIN BuRNER SwITCh; Depress and turn the knob counterclockwise; PILoT PoSITIoN; Depress and turn knob clockwise; To TuRN oFF GaS
- Page 38 – A qualified agency should examine the venting system annually.; Refer to Pages 34 through 36.; au; Visually check pilot and burner flames periodically.
- Page 39 – TRouBLEShooTING; SyMPToM
- Page 40 – Correct if necessary.
- Page 41 – BLowER; No substitute materials may be used.; oPTIoNaL BLowER aCCESSoRy - BLoT; wIRING dIaGRaM FoR BLowER
- Page 42 – REPLaCEMENT PaRTS; qty
- Page 43 – REPLACEMENT PARTS ARE AVAILABLE THROUGH YOUR RETAILER
- Page 44 – STaNdING PILoT – MILLIvoLT CoNTRoL
- Page 45 – ELECTRoNIC IGNITIoN; Gas Valve Assy
- Page 46 – vENT CoMPoNENTS
- Page 50 – NoTE REGaRdING vENTEd PRoduCTS
- Page 51 – LIMITEd LIFETIME waRRaNTy PoLICy; LIFETIME waRRaNTy; serial number of your MHSC product.
- Page 52 – Model
Model:
624dv(ST,PF,CR,CL)NvC/PvC,
NEC/PEC
designer Series direct
vent Gas Fireplace
IF ThE INFoRMaTIoN IN ThESE INSTRuCTIoNS IS NoT
FoLLowEd ExaCTLy, a FIRE oR ExPLoSIoN May
RESuLT CauSING PRoPERTy daMaGE, PERSoNaL
INjuRy oR LoSS oF LIFE.
–
do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
– whaT To do IF you SMELL GaS
• do not try to light any appliance.
• do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a neighbor's
phone. Follow the gas supplier's instructions.
• If you cannot reach your gas supplier, call the fire
department.
– I n s t a l l a t i o n a n d s e r v i c e m u s t b e p e r f o r m e d
by a qualified installer, service agency or the
gas supplier.
waRNING: Improper installation, adjustment, alteration,
services or maintenance can cause injury or property
damage. Refer to this manual. For assistance or additional
information consult a qualified installer, service agency
or the gas supplier.
This appliance may be installed in an aftermarket*,
permanently located, manufactured home (uSa only) or
mobile home, where not prohibited by local codes.
This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not
convertible for use with other gases, unless a certified
kit is used.
* aftermarket: Completion of sale, not for purpose of resale, from the
manufacturer.
waRNING
INSTaLLER: Leave this manual with the appliance.
CoNSuMER: Retain this manual for future refer-
ence.
42D0200 2/10 Rev. 14
420200
6000DV cover
d u E T o h I G h T E M P E R aT u R E S , T h E
aPPLIaNCE ShouLd BE LoCaTEd ouT oF
TRaFFIC aNd away FRoM FuRNITuRE aNd
dRaPERIES.
ChILdREN aNd aduLTS ShouLd BE aLERTEd
T o T h E h a Z a R d S o F h I G h S u R Fa C E
TEMPERaTuRE aNd ShouLd STay away To
avoId BuRNS oR CLoThING IGNITIoN.
youNG ChILdREN ShouLd BE SuPERvISEd
whEN ThEy aRE IN ThE SaME RooM aS ThE
aPPLIaNCE.
CLoThING oR oThER FLaMMaBLE MaTERIaL
ShouLd NoT BE PLaCEd oN oR NEaR ThE
aPPLIaNCE.
KEEP ThE RooM aREa CLEaR aNd FREE
FRoM CoMBuSTIBLE MaTERIaLS, GaSoLINE,
aNd oThER FLaMMaBLE va PoRS aNd
LIquIdS.
Installation and Operating
Instructions
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 42D0200 Designer Series Gas Fireplaces CoNTENTS Important Safety Information ...................................... 3 Code approval .............................................................. 4 Product Features .......................................................... 5 High Elevations ..........
42D0200 Designer Series Gas Fireplaces 3 4. Never install the fireplace • in a recreational vehicle • where curtains, furniture, clothing, or other flammable objects are less than 42" from the front, top, or sides of the fireplace • in high traffic areas • in windy or drafty areas 5. This firepl...
4 42D0200 Designer Series Gas Fireplaces IMPoRTaNT SaFETy INFoRMaTIoN and CodE aPPRovaL 14. Do not use any solid fuels (wood, coal, paper, card- board, etc.) in this fireplace. Use only the gas type indicated on rating plate. 15. This appliance, when installed, must be electrically grounded in accor...
