Lennox SHRL 33/40 DV INS - Manual

Lennox SHRL 33/40 DV INS

Lennox SHRL 33/40 DV INS – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
39 Page 39
40 Page 40
41 Page 41
42 Page 42
Page: / 42

Table of Contents:

  • Page 5 – These appliances may be installed in an aftermarket permanently; GENERAL INFORMATION; Table 1; Millivolt Valve & Electrical; Table 3; Table 2
  • Page 6 – CODES AND APPROVALS; discuss with local building officials include:; SMOKE DETECTORS
  • Page 7 – COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS; Massachusetts Horizontal Vent Requirements
  • Page 8 – Figure 1; ratings and dimensions are subject to change without notice.; SPECIFICATIONS: ShorelineTM; Center
  • Page 9 – Figure 2 - Existing Fireplace Minimum Dimensions; Minimum Fireplace Dimensions; Table 4; should review your plans prior to installation.; Refer to; MINIMUM CLEARANCES TO COMBUSTIBLES; fireplace hearth/floor protection materials.; CL; Figure 3 - Minimum Clearances; Hearth Protection; Refer to Table 4; Figure 4 - Hearth Protection
  • Page 10 – WARNING; THIS FIREPLACE HAS BEEN ALTERED TO; Fireplace Requirements; CAUTIONS; Figure 5 - Fireplace Warning Label; INSTALLATION
  • Page 11 – Venting Requirements; Do not substitute the heat-rated flex liner (UL1777) for the; Figure 6a - Terminating Air Inlet in Chimney
  • Page 12 – Vertical Venting; ) or it can terminate inside the chimney (see; Vertical Termination Height Minimum; angled roof is as follows:; Table 5; Roof Pitch; Insert Leveling; for each adjusting leg. To adjust the legs in the front use a 9/16” open
  • Page 13 – Description; Figure 9; Shoreline Door Kit - Packaging List; Note: The Shoreline insert comes with the door already on the unit.; SHORELINETM DOOR ASSEMBLY INSTALLATION OR REMOVAL
  • Page 14 – Figure; CAUTION; Before you install the refractory brick panels and log; Brick Panel Set, Tan
  • Page 15 – Log supports; Start with the rear log (A). Set it down on the log supports located; Log Set - Packaging List; No tools are needed; SHORELINETM LOG SET INSTALLATION INSTRUCTIONS
  • Page 16 – pin; Glowing Embers; Bag of Glowing
  • Page 17 – wall surface open the right surround access door and make any; One of the following surround kits is required (Purchased sepa-; Table 9; To Install Surround Panels:; Hang the surround on hooks attached to insert (labeled A and B).; SHORELINETM SURROUND ASSEMBLY INSTALLATION; openings on the appliance.
  • Page 18 – Adjustment Procedure:; Picture B; SNUG ONLY, DO NOT OVERTIGHTEN; SURROUND BALL SCREW MOUNT ADJUSTMENT
  • Page 19 – Gas Pressure Requirements; of the insert and ensure there are no operating problems.; LP and Natural Gas Supplies; ShorelineTM; GAS LINE INSTALLATION
  • Page 20 – ). To properly complete the installation of this; LENNOX HEARTH PRODUCTS; La chimenea caliente; Un foyer chaud peut causer; ADVERTENCIA; INSTALLER INSTRUCTIONS -; Hot Fireplace Will Cause; ) ou sur le thermostat; LENNOX HEARTH PRODUCTS; ) y en el transmisor; LENNOX HEARTH PRODUCTS; AVERTISSEMENT
  • Page 21 – Lighting Instructions; Your ShorelineTM gas appliance must always be; Pre-Lighting Checklist; in front of the insert.; OPERATING INSTRUCTIONS
  • Page 22 – To Turn Off Gas To Appliance; For complete shutdown: See “To Turn Off Gas To Appliance” above.; WARNINGS; Figure 31 - Gas Controls; Pilot Hood
  • Page 23 – Flame Appearance and Sooting; Your ShorelineTM fireplace insert is designed for maximum heating; Figure 34 - Proper Burner Flame Appearance; Air Shutter Adjustment; ). Moving the air shutter lever to the right opens the air
  • Page 24 – Figure 36 - Blower Wiring Diagram; WHITE; BLOWER; BLACK; See Shoreline Main Burner Operation
  • Page 25 – ShorelineTM Main Burner Operation; IMPORTANT NOTE: If a wall thermostat is to be installed, install the; CAUTION: Label all wires prior to disconnection when servic-; Millivolt Control System; which opens a valve allowing gas to flow to the pilot assembly. The; Figure 37 Millivolt Wiring Diagram; étiquetez tous les fils avant de les débrancher. Des erreurs
  • Page 26 – Annual inspection should be made and the following checks; Figure 39 - Proper Pilot Flame Appearance; Turn off gas and electrical power to the fireplace; CAUTION: Label all wires prior to disconnection when servicing
  • Page 27 – ). If the surface later becomes stained or
  • Page 28 – MAINTENANCE SCHEDULE
  • Page 29 – accomplished by a qualified service technician.; SYMPTOM; TROUBLESHOOTING
  • Page 30 – SHORELINETM REPLACEMENT PARTS LIST - MODELS SHR33 & SHR40; can result in poor performance and safety hazards.
  • Page 31 – PART IDENTIFICATION
  • Page 32 – Gasket Kit
  • Page 35 – -Piece Surround Assembly; Surround Flange Hinge
  • Page 37 – Surround Kits; for additional information; Model; OPTIONAL ACCESSORIES; operation (sold separately). Never operate this appliance without
  • Page 39 – SAFETY / LISTING LABEL; SHR; MINIMUM; HOT WHILE IN OPERATION. DO NOT TOUCH. SEVERE BURNS MAY RESULT. KEEP; DÉGAGEMENTS; DATE OF MANUFACTURE / DATE DE FABRICATION
  • Page 40 – LIGHTING INSTRUCTIONS LABEL
  • Page 41 – NOTES
  • Page 42 – WARRANTY; Natural Gas
Loading the manual

DR

AF

T

3/2

9/2

01

0

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

INSTALLATEUR: Laissez cette notice avec l'appareil.

CONSOMMATEUR: Conservez cette notice pour consul-

tation ultérieure.

- Do not store or use gasoline or other flammable vapors and

liquids in the vicinity of this or any other appliance.

- WHAT TO DO IF YOU SMELL GAS

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any

phone in your building.

• Immediately call your gas supplier from a neighbor’s

phone. Follow the gas supplier’s instructions.

• If you cannot reach your gas supplier, call the fire

department.

- Installation and service must be performed by a quali-

fied installer, service agency or the gas supplier.

WARNING: If the information in these instructions is

not followed exactly, a fire or explosion may result

causing property damage, personal injury or death.

- Ne pas entreposer ni utilizer d’essence ni d’autres

vapeurs ou liquides inflammables dans le voisinage

de cet appareil ou de tout autre appareil.

- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ:

• Ne pas tenter d’allumer d’appareil.

• Ne touchez à aucan interrupteur. Ne pas vous servir

des téléphones se trouvant dans le bâtiment où vous

trouvez.

• Appelez immédiatement votre fournisseur de gaz

depuis un voisin. Suivez les instructions du fournis-

seur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service des incindie.

- L’installation et l’entretien doivent être assurés par un

installateur ou un service d’entretien qualifié ou par

le fournisseur de gaz.

AVERTISSEMENT: Assurez-vous de bien suivre les

instructions données dans cette notice pour réduire

au minimum le risque d’incindie ou d’explosion ou

pour éviter tout dommage matériel, toute blessure

ou la mort.

INSTALLATION AND OPERATION

Ce manuel d’installation est disponible en francais, s implement en faire
la demande. Numéro de la pièce 850,050CF.

MODELS

OTL Report No.

050-F-22-5

US

Portland

DIRECT-VENT GAS FIREPLACE HEATER INSERTS

P/N 850,050M REV. D 03/2010

Direct

-

Vent

SHORELINE™

This appliance may be installed in an aftermarket permanently located, manufactured home (USA only) or mobile

home, where not prohibited by local codes. This appliance is only for use with the type of gas indicated on the rating

plate. This appliance is not convertible for use with other gases, unless a certified kit is used.

WARNING AVERTISSEMENT

TM

SHRL 33/40 DV INS

The Shoreline™ fireplace insert is factory equipped for 40,000 BTU

input and can be converted to 33,000 using the smaller orifice provided.

UNE SURFACE VITRÉE CHAUDE PEUT

CAUSER DES BRÛLURES.

LAISSER REFROIDIR LA SURFACE

VITRÉE AVANT D'Y TOUCHER.

NE PERMETTEZ JAMAIS À UN ENFANT

DE TOUCHER LA SURFACE VITRÉE.

HOT GLASS WILL

CAUSE BURNS.

DO NOT TOUCH GLASS

UNTIL COOLED.

NEVER ALLOW CHILDREN TO

TOUCH GLASS.

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 5 - These appliances may be installed in an aftermarket permanently; GENERAL INFORMATION; Table 1; Millivolt Valve & Electrical; Table 3; Table 2

5 NOTE: DIAGRAMS AND ILLUSTRATIONS ARE NOT TO SCALE Millivolt Models with Manually-Modulated Gas Valves Natural Gas Propane (LP) Gas Model Input Rate (BTU/HR) Input Rate (BTU/HR) SHR33 19,500 to 33,000 19,500 to 33,000 SHR40 24,000-40,000 21,500 to 37,500 Table 1 These appliances may be installed in...

Page 6 - CODES AND APPROVALS; discuss with local building officials include:; SMOKE DETECTORS

6 NOTE: DIAGRAMS AND ILLUSTRATIONS ARE NOT TO SCALE CODES AND APPROVALS Listing and Safety Standards - Gas appliances must be tested and certi- fied by a nationally recognized testing and certification laboratory to ANSI (American National Standard Institute) gas appliance safety standards. This ins...

Page 7 - COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS; Massachusetts Horizontal Vent Requirements

7 NOTE: DIAGRAMS AND ILLUSTRATIONS ARE NOT TO SCALE NEW YORK CITY, NEW YORK (MEA) (NYC MEA Approval #138-07-E) Installation of these appliances are approved for installation in New York City in the US state of New York. COMMONWEALTH OF MASSACHUSETTS REQUIREMENTS (Massachusetts Approval #G3-0508-369)...

Other Lennox Models

All Lennox Other