Lennox RDV40 - Manual
Lennox RDV40 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – Table of Contents
- Page 4 – WARNING; IMPORTANT: When installing these appliances into a fac-
- Page 5 – The following requirements reference various Massachusetts
- Page 6 – RATINGS
- Page 7 – * Top air duct will need to be removed for short ZC applica-; Width of insert behind Surround Panels; CAUTIONS
- Page 8 – Clearances to Combustibles
- Page 9 – Do not substitute the heat-rated flex liner (UL1777) for the; FKDVI; Installation; Figure
- Page 11 – NEVER; Packaging List
- Page 12 – Gas Line Installation; lp; Air Shutter Adjustment; Robertshaw Millivolt Gas Valve
- Page 13 – Operating Instructions; Lighting Instructions; WARNING: IF YOU DO NOT FOLLOW THESE INSTRUCTIONS
- Page 14 – Flame Color & Behavior
- Page 16 – Millivolt Control; Thermostat Wire
- Page 17 – Maintenance & Servicing
- Page 19 – INTAKE OR OUTLET VENTS.; Troubleshooting
- Page 20 – Replacement Parts; Part Number
- Page 21 – HOT WHILE IN OPERATION. DO NOT TOUCH. SEVERE BURNS MAY RESULT. KEEP; MINIMUM CLEARANCES; SAFETY / LISTING LABEL
- Page 22 – Lighting Label
- Page 23 – Natural Gas
Report No. 050-S-15c-5
INSTALLATION AND OPERATION MANUAL
Direct-Vent Gas
Fireplace Inserts
Retain These Instructions For Future Reference
WARNINGS
•
Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will
retain heat for a while after shutting off the appliance. Severe burns may result.
•
Carefully supervise children in the same room as appliance.
FOR YOUR SAFETY
Do not store or use gasoline or other flammable
vapors or liquids in the vicinity of this or any other
appliance.
WHAT TO DO IF YOU SMELL GAS:
• DO NOT light any appliance.
• DO NOT touch any electrical switches.
• DO NOT use any phone in your building.
• Immediately call your gas supplier from a
neighbor’s phone. Follow your gas supplier's
instructions.
• If your gas supplier cannot be reached, call
the fire department.
Installation and service must be performed by a quali-
fied installer, service agency or the gas supplier
.
POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser d'essence
ni d'autres vapeurs ou liquides inflammables à proximité de
cet appareil ou de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une odeur
de gaz:
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucun interrupteur.
• Ne pas vous servir des téléphones se trouvant dans le bâti-
ment
• Appelez immédiatement votre fournisseur de gaz depuis un
voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz, appelez
le service des incendies.
L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
WARNING: If the information in this manual is not
followed exactly, a fire or explosion may result
causing property damage, personal injury or loss
of life.
AVERTISSEMENT: Assurez-vous de bien suivre les instruc-
tions données dans cette notice pour réduire au minimum
le risque d’incendie ou d’explosion ou pour éviter tout
dommage matériel, toute blessure ou la mort.
A French manual is available upon request. Order P/N 775,218CF.
Ce manuel d’installation est disponible en francais, simplement
en faire la demande. Numéro de la pièce 775,218CF.
•
Suitable for installation into masonry or factory built fireplaces. These appliances may be installed in an after-
market permanently located, manufactured (mobile) home, where not prohibited by local codes. This appliance
is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with
other gases unless a certified kit is used.
•
Lennox™ gas-burning appliances are designed for use as a supplemental heater. They are not intended for
continuous use as a primary heat source.
Ravenna™ 33/40 (RDV33/40)
P/N 775,218M Rev. A, 05/2007
I
n the Commonwealth of Massachusetts:
• Installation must be performed by a licensed plumber or gas fitter
• See Table of Contents for location of additional Commonwealth
of Massachusetts requirements
Shown with Cast Pillar face
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
Table of Contents C autions & s afety ..................................................................................... 3 o rifiCe s ize / a ltitude a djustment .................................................................... 4 f ireplaCe r equirements ......................................
4 NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. Orifice Size/Altitude Adjustment For altitudes above 2,000 feet (In Canada 4,500 FT/1370 M),the orifice should be de-rated by 4% for every 1,000 feet to maintain the proper ratio of gas to air. Improper orifice sizing may result in damage and un...
5 Inspection The state or local gas inspector of the side wall horizontally vented gas fueled equipment shall not approve the installation unless, upon inspection, the inspector observes carbon monoxide detectors and signage installed in accordance with the provisions of 248 CMR 5.08(2)(a)1 through ...
