Lennox 33/40 DV INS - Manual

Lennox 33/40 DV INS

Lennox 33/40 DV INS – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
25 Page 25
26 Page 26
27 Page 27
28 Page 28
29 Page 29
30 Page 30
31 Page 31
32 Page 32
33 Page 33
34 Page 34
35 Page 35
36 Page 36
37 Page 37
38 Page 38
Page: / 38

Table of Contents:

  • Page 2 – READ THIS MANUAL IN ITS ENTIRETY AND UNDER-; WARNING
  • Page 3 – Requirements for the
  • Page 4 – Millivolt Valve & Electrical; These appliances may be installed in an aftermarket permanently; CODES AND APPROVALS; Table 2; Table 1; Fuel; Table 3; Table 2
  • Page 5 – Manufactured Home Installations - These appliances must conform; Questions To Ask Local Building Official; discuss with local building officials include:
  • Page 6 – The following requirements reference various Massachusetts
  • Page 7 – Figure 1; Center; SPECIFICATIONS: ShorelineTM
  • Page 8 – CL; Figure 2 - Existing Fireplace Minimum Dimensions; Hearth Protection; Table 4; should review your plans prior to installation.; Refer to; MINIMUM CLEARANCES TO COMBUSTIBLES; fireplace hearth/floor protection materials.
  • Page 9 – THIS FIREPLACE HAS BEEN ALTERED TO; Fireplace Requirements; fuel, wood burning fireplace (listed to UL 127 or ULC S610) only. All; CAUTIONS; Figure 5 - Fireplace Warning Label; INSTALLATION
  • Page 10 – Venting Requirements; Approved Vent Systems:; Figure 6b; Do not substitute the heat-rated flex liner (UL1777) for the; Masonry and Factory Built Fireplaces; Figure 6a - Terminating Air Inlet in Chimney
  • Page 11 – Vertical Venting; measured from the flue collar of the unit to the end of the vent pipe,; DETAIL B; Figure 8; DETAIL C; Table 5; Insert Leveling; Figures 7 and 8
  • Page 12 – Tab; Figure 9; Note: The Shoreline insert comes with the door already on the; SHORELINETM DOOR ASSEMBLY INSTALLATION OR REMOVAL
  • Page 13 – CAUTION; Before you install the refractory brick panels and log; Brick Panel Set, Standard
  • Page 14 – Log supports; Start with the rear log (A). Set it down on the log supports located; SHORELINETM LOG SET INSTALLATION INSTRUCTIONS
  • Page 15 – pin; Glowing Embers
  • Page 16 – wall surface open the right surround access door and make any; Tools Needed: No tools are needed; Hook A; Surround Kits; Description; Table 9; To Install Surround Panels:; Hang the surround on hooks attached to insert (labeled A and B).; SHORELINETM SURROUND ASSEMBLY INSTALLATION; openings on the appliance.
  • Page 17 – Adjustment Procedure:; Pictures A and B; Step 4 You can then test close the surround access door to ensure it; SURROUND BALL SCREW MOUNT ADJUSTMENT
  • Page 18 – Gas Pressure Requirements; of the insert and ensure there are no operating problems.; LP and Natural Gas Supplies; ShorelineTM; show the units' gas pressure requirements for; GAS LINE INSTALLATION
  • Page 19 – To Turn Off Gas To Appliance; For complete shutdown: See “To Turn Off Gas To Appliance” above.; Lighting Instructions; STOP! Read the safety information on the front cover of the manual; NOTE: The knob cannot be turned from “PILOT” to “OFF” unless the knob; Figure 31 - Gas Controls; Pilot Hood
  • Page 20 – Flame Appearance and Sooting; Your ShorelineTM fireplace insert is designed for maximum heating; Figure 34 - Proper Burner Flame Appearance; Air Shutter Adjustment; . Moving the air shutter lever to the right opens the air
  • Page 21 – Blower Operation; Figures; Figure 36 - Blower Wiring Diagram; WHITE; BLOWER; BLACK; Quiet Operation; See Shoreline Main Burner Operation
  • Page 22 – ShorelineTM Main Burner Operation; Thermostat Wire; Millivolt Control System; Figure 37 Millivolt Wiring Diagram
  • Page 23 – Maintenance Checklist; Annual inspection should be made and the following checks; WARNINGS; MAINTENANCE AND SERVICING; Glass Maintenance; Figure 39 - Proper Pilot Flame Appearance
  • Page 24 – CAUTION: Label all wires prior to disconnection when servicing; Do not slam or strike glass door or damage may
  • Page 25 – MAINTENANCE SCHEDULE
  • Page 26 – accomplished by a qualified service technician.; SYMPTOM; TROUBLESHOOTING
  • Page 27 – SHORELINETM REPLACEMENT PARTS LIST - MODELS SHR33 & SHR40
  • Page 28 – PART IDENTIFICATION
  • Page 29 – Pilot Cassette Assembly
  • Page 32 – -Piece Surround Assembly
  • Page 34 – attractive finished look.; OPTIONAL ACCESSORIES
  • Page 35 – Model; Flex Kit, DVI 3” X 35’
  • Page 36 – SAFETY / LISTING LABEL
  • Page 37 – LIGHTING INSTRUCTIONS LABEL
  • Page 38 – WARRANTY; The installation date of the appliance.; Natural Gas
Loading the manual

Report No. 050-F-22-5

INSTALLATION AND OPERATION MANUAL

Direct-Vent Gas

Fireplace Heater Inserts

Do not store or use gasoline or other flammable

vapors or liquids in the vicinity of this or any other

appliance.

WHAT TO DO IF YOU SMELL GAS:
• Do not light any appliance.

• Do not touch any electrical switch; do not

Use any phone in your building.

• Immediately call your gas supplier from a

neighbor’s phone. Follow your gas supplier's

instructions.

• If your gas supplier cannot be reached, call

the fire department.

Installation and service must be performed by a quali-

fied installer, service agency or the gas supplier

.

POUR VOTRE SÉCURITÉ: Ne pas entreposer ni utiliser

d’essence ni d’autre vapeurs ou liquides inflammables dans

le voisinage de cet appareil ou de tout autre appareil.
POUR VOTRE SÉCURITÉ: Que faire si vous sentez une odeur

de gaz:
• Ne pas tenter d’allumer d’appareil.

• Ne touchez à aucun interrupteur. Ne pas vous servir

des téléphones se trouvant dans le batiment où vous

vous trouvez.

• Evacuez la piéce, le bâtiment ou la zone.

• Appelez immédiatement votre fournisseur de gaz depuis

un voisin. Suivez les instructions du fournisseur.

• Si vous ne pouvez rejoindre le fournisseur de gaz,

appelez le service dos incendies.
L’installation et service doit être exécuté par un qualifié instal-

leur, agence de service ou le fournisseur de gaz.

WARNING: If the information in this manual is not

followed exactly, a fire or explosion may result

causing property damage, personal injury or loss

of life.

AVERTISSEMENT: Assurez-vous de bien suivre les

instructions donné dans cette notice pour réduire au

minimum le risque d’incendie ou pour éviter tout dom-

mage matériel, toute blessure ou la mort.

Shoreline™ 33/40 DV INS

US

I

n the Commonwealth of Massachusetts:

• Installation must be performed by a licensed plumber or gas fitter

• See Table of Contents for location of additional Commonwealth of

Massachusetts requirements

TM

Retain These Instructions For Future Reference

A French manual is available upon request. Order P/N 850,050CF. Ce manuel d’installation

est disponible en francais, simplement en faire la demande. Numéro de la pièce 850,050CF.

P/N 850,050M Rev. C, 01/2008

The Shoreline™ fireplace insert is factory equipped for 40,000 BTU

input and can be converted to 33,000 using the smaller orifice provided.

WARNINGS

• Hot! Do not touch! The glass and surfaces of this appliance will be hot during operation and will

retain heat for a while after shutting off the appliance. Severe burns may result.

• Carefully supervise children in the same room as appliance.

• If small children are present in the home, it is recommended that this appliance be fitted with a

screen door or screen panel kit. See

Page 33

for ordering information.

•

Suitable for installation into masonry or factory built fireplaces. These appliances may be installed in an after-

market permanently located, manufactured (mobile) home (USA only), where not prohibited by local codes.

This appliance is only for use with the type of gas indicated on the rating plate.

•

This appliance is not convertible for use with other gases unless a certified kit is used.

• Lennox™ gas-burning appliances are designed for use as a supplemental heater. They are not intended for

continuous use as a primary heat source.

DR

AF

T

1-1

7-2

00

8

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - READ THIS MANUAL IN ITS ENTIRETY AND UNDER-; WARNING

1. FOR YOUR SAFETY do not install or operate your fireplace insert without first reading and understanding this manual. Any installation or operation of the appliance deviating from that which is stated in this manual WILL void the warranty and may be hazardous. . INSTALLATION AND REPAIR SHOULD ONLY...

Page 3 - Requirements for the

3 CONGRATULATIONS ON THE PURCHASE OF YOUR NEW GAS APPLIANCE MANUFACTURED BY LENNOX HEARTH PRODUCTS. When you purchased your new gas-fired heater, you joined the ranks of thousands of individuals whose answer to their home heating needs reflects their concern for efficiency and our environment. We ex...

Page 4 - Millivolt Valve & Electrical; These appliances may be installed in an aftermarket permanently; CODES AND APPROVALS; Table 2; Table 1; Fuel; Table 3; Table 2

4 NOTE: DIAGRAMS AND ILLUSTRATIONS ARE NOT TO SCALE Millivolt Models with Manually-Modulated Gas Valves Natural Gas Propane (LP) Gas Model Input Rate (BTU/HR) Input Rate (BTU/HR) SHR33 19,500 to 33,000 19,500 to 33,000 SHR40 4,000-40,000 1,500 to 37,500 Table 1 Note: These appliances are designed as...

Other Lennox Models

All Lennox Other