Page 2 - Safe Operation Practices for Ride-On Mowers; WARNING; The engine exhaust from this product con-; GENERAL OPERATION; SAFETY RULES
2 Safe Operation Practices for Ride-On Mowers I M P O R T A N T : T H I S C U T T I N G M A C H I N E I S C A P A B L E O F A M P U T A T I N G H A N D S A N D F E E T A N D T H R O W I N G O B J E C T S .F A I L U R E T O O B S E R V E T H E F O L L O W I N G S A F E T Y I N S T R U C T I O N S C O...
Page 3 - PRODUCT SPECIFICATIONS; CUSTOMER RESPONSIBILITIES
3 PRODUCT SPECIFICATIONS HORSEPOWER: 12.0 GASOLINE CAPACITY 2 GALLONS AND TYPE: UNLEADED REGULAR OIL TYPE (API-SF/SG): SAE 30 (above 32 ° F) SAE 5W-30 (below 32 ° F) OIL CAPACITY: 3.0 PINTS SPARK PLUG: CHAMPION RJ19LM (GAP: .030") VALVE CLEARANCE: INTAKE: .005" - .007" EXHAUST: .009"...
Page 4 - TABLE OF CONTENTS; INDEX
4 TABLE OF CONTENTS A Adjustments: Brake ............................................ 20Carburetor .................................... 23Mower Front-To-Back ......................... 19 Side-To-Side ........................... 19Throttle Control Cable .................. 22 Air Filter, Engine .........
Page 5 - CONTENTS OF HARDWARE PACK; Parts packed separately in carton
5 CONTENTS OF HARDWARE PACK Parts packed separately in carton Parts Bag contents shown full size Parts bag contents not shown full size Slope Sheet (2) Hex Bolts 1/4-20 x 3/4 (2) Washers 9/32 x 5/8 x 16 Ga. (2) LockWashers 1/4 (2) Hex Nuts1/4-20 Seat Manual SteeringWheel Parts Bag Steering Wheel Ins...
Page 6 - ASSEMBLY; TOOLS REQUIRED FOR ASSEMBLY; UNPACK CARTON; BEFORE ROLLING TRACTOR OFF SKID
ASSEMBLY 6 Your new tractor has been assembled at the factory with exception of those parts left unassembled for shipping purposes.To ensure safe and proper operation of your tractor all parts and hardware you assemble must be tightened securely. Usethe correct tools as necessary to insure proper ti...
Page 8 - CHECKLIST; CHECK TIRE PRESSURE; CHECK BRAKE SYSTEM
ASSEMBLY 8 ✓ CHECKLIST BEFORE YOU OPERATE AND ENJOY YOUR NEWTRACTOR, WE WISH TO ASSURE THAT YOU RECEIVETHE BEST PERFORMANCE AND SATISFACTION FROMTHIS QUALITY PRODUCT. PLEASE REVIEW THE FOLLOWING CHECKLIST: ✓ All assembly instructions have been completed. ✓ No remaining loose parts in carton. ✓ Batte...
Page 9 - OPERATION
OPERATION 9 These symbols may appear on your tractor or in literature supplied with the product. Learn and understand their meaning. BATTERY CAUTION OR WARNING REVERSE FORWARD FAST SLOW ENGINE ON ENGINE OFF OIL PRESSURE CLUTCH LIGHTS ON LIGHTS OFF FUEL CHOKE MOWER HEIGHT DIFFERENTIAL LOCK PARKING BR...
Page 10 - KNOW YOUR TRACTOR; LIGHT SWITCH POSITION: Turns the headlights on.
OPERATION 10 KNOW YOUR TRACTOR READ THIS OWNER'S MANUAL AND SAFETY RULES BEFORE OPERATING YOUR TRACTOR Compare the illustrations with your tractor to familiarize yourself with the locations of various controls and adjustments. Savethis manual for future reference. FIG. 7 Our tractors conform to the ...
Page 11 - NOTE: Failure to move throttle control to slow (; HOW TO USE YOUR TRACTOR
OPERATION 11 NOTE: Under certain conditions when tractor is standingidle with the engine running, hot engine exhaust gases maycause “browning” of grass. To eliminate this possibility,always stop engine when stopping tractor on grass areas. CAUTION: Always stop tractor com-pletely, as described above...
Page 12 - TO OPERATE ON HILLS; and; TO TRANSPORT; BEFORE STARTING THE ENGINE; ADD GASOLINE
OPERATION 12 TO OPERATE ON HILLS CAUTION: Do not drive up or downhills with slopes greater than 15 ° and do not drive across any slope. • Choose the slowest speed before starting up or downhills. • Avoid stopping or changing speed on hills. • If slowing is necessary, move throttle control lever tosl...
Page 13 - MULCHING MOWING TIPS; MOWING TIPS
OPERATION 13 FIG. 10 MULCHING MOWING TIPS I M P O R T A N T : F O R B E S T P E R F O R M A N C E , K E E PM O W E R H O U S I N G F R E E O F B U I L T - U P G R A S S A N DT R A S H . C L E A N A F T E R E A C H U S E . • The special mulching blade will recut the grass clip-pings many times and re...
Page 14 - LUBRICATION CHART; GENERAL RECOMMENDATIONS; BEFORE EACH USE; MAINTENANCE SCHEDULE
14 CUSTOMER RESPONSIBILITIES 2 LUBRICATION CHART 2 SPINDLE ZERK FRONT WHEELBEARING ZERK ATTACHMENTCLUTCHPIVOT(S) 1 SPINDLE ZERK FRONT WHEELBEARING ZERK 2 2 3 ENGINE GEARSHIFTPIVOTS 1 2 1 3 GENERAL RECOMMENDATIONS The warranty on this tractor does not cover items that havebeen subjected to operator a...
Page 15 - TRACTOR; BRAKE OPERATION; BATTERY
CUSTOMER RESPONSIBILITIES 15 TRACTOR Always observe safety rules when performing any mainte-nance. BRAKE OPERATION If tractor requires more than six (6) feet stopping distanceat high speed in highest gear, then brake must be adjusted.(See “TO ADJUST BRAKE” in the Service and Adjust-ments section of ...
Page 16 - ENGINE; LUBRICATION; TRANSAXLE COOLING
CUSTOMER RESPONSIBILITIES 16 ENGINE LUBRICATION Only use high quality detergent oil rated with API serviceclassification SF or SG. Select the oil’s SAE viscosity gradeaccording to your expected operating temperature. TEMPERATURE RANGE ANTICIPATED BEFORE NEXT OIL CHANGE SAE VISCOSITY GRADES -20° 0° 3...
Page 17 - MUFFLER; CLEANING
CUSTOMER RESPONSIBILITIES 17 MUFFLER Inspect and replace corroded muffler and spark arrester (ifequipped) as it could create a fire hazard and/or damage. SPARK PLUGS Replace spark plugs at the beginning of each mowingseason or after every 100 hours of operation, whicheveroccurs first. Spark plug typ...
Page 18 - SERVICE AND ADJUSTMENTS; Depress clutch/brake pedal fully and set parking brake.
SERVICE AND ADJUSTMENTS 18 CAUTION: BEFORE PERFORMING ANY SERVICE OR ADJUSTMENTS:• Depress clutch/brake pedal fully and set parking brake. • Place gearshift lever in neutral (N) position. • Place attachment clutch in “DISENGAGED” position. • Turn ignition key “OFF” and remove key. • Make sure the bl...
Page 19 - TO LEVEL MOWER HOUSING
SERVICE AND ADJUSTMENTS 19 NUT "E" TRUNNION FRONT LINKS NUT "F" FIG. 22 TO LEVEL MOWER HOUSING Adjust the mower while tractor is parked on level ground ordriveway. Make sure tires are properly inflated (See“PRODUCT SPECIFICATIONS” on page 3 of this manual).If tires are over or underi...
Page 21 - TO ADJUST STEERING WHEEL ALIGNMENT
21 SERVICE AND ADJUSTMENTS TO START ENGINE WITH A WEAK BATTERY(See Fig. 29) CAUTION: Lead-acid batteries gener-ate explosive gases. Keep sparks, flameand smoking materials away from bat-teries. Always wear eye protectionwhen around batteries. If your battery is too weak to start the engine, it shoul...
Page 22 - TO REPLACE HEADLIGHT BULB
22 SERVICE AND ADJUSTMENTS CABLES NEGATIVE TERMINAL POSITIVE TERMINAL CHASSIS CHARGEDBATTERY POSITIVE TERMINAL NEGATIVE TERMINAL FIG. 29 TO REPLACE HEADLIGHT BULB • Raise hood. • Pull bulb holder out of the hole in the backside of thegrill. • Replace bulb in holder and push bulb holder securelyback ...
Page 24 - STORAGE; FUEL SYSTEM; ENGINE OIL; OTHER
24 STORAGE Immediately prepare your tractor for storage at the end ofthe season or if the tractor will not be used for 30 days ormore. CAUTION: Never store the tractor withgasoline in the tank inside a buildingwhere fumes may reach an open flameor spark. Allow the engine to coolbefore storing in any...
Page 25 - TROUBLESHOOTING POINTS; PROBLEM
25 TROUBLESHOOTING POINTS Will not start 1. Out of fuel. 1. Fill fuel tank. 2. Engine not “CHOKED” properly. 2. See “TO START ENGINE” in Operation section. 3. Engine flooded. 3. Wait several minutes before attempting to start. 4. Bad spark plug. 4. Replace spark plug. 5. Dirty air filter. 5. Clean/r...
Page 27 - SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION
27 15° MAX. SIGHT AND HOLD THIS LEVEL WITHSKY LINE OR TREE. CUT OUT ON DOTTED LINES THIS IS A 15° SLOPE SIGHTING GUIDE ONLY RIDE UP AND DOWN HILL,NOT ACROSS HILL SUGGESTED GUIDE FOR SIGHTING SLOPES FOR SAFE OPERATION Operate your Tractor up and down the face of slopes (notgreater than 15°), never ac...
Page 28 - WARRANTY STATEMENT
28 WARRANTY STATEMENT SECTION 1: LIMITED WARRANTY Husqvarna Forest & Garden Company (“Husqvarna”) warrants Husqvarna product to the original purchaser to be free from defects in material and workmanship from the date of purchase for the “WarrantyPeriod” of the product as set forth below: Lifetim...
Page 29 - SCHEMATIC
27 TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 SCHEMATIC BATTERY FUSE 30 AMP. IGNITION SWITCH RED RED RED BLACK IGNITION UNIT HEADLIGHTS NON-REMOVABLE CONNECTIONS REMOVABLE CONNECTIONS BLACK BLACK BLACK WHITE WHITE WHITE BLUE BLACK ORANGE BLACK BROWN BLACK STARTER M SEAT SWITCH (...
Page 30 - REPAIR PARTS; ELECTRICAL
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 ELECTRICAL 28 28 29 26 24 42 43 44 44 25 41 19 20 19 20 40 33 32 31 30 22 21 70 9 7 8 6 3 4 2 1 52 16 16 48
Page 31 - KEY
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 ELECTRICAL 29 KEY PART NO. NO. DESCRIPTION 1 532 14 61-39 Battery 12 Volt 25 AMP 2 874 76 04-12 Bolt Hex Hd 1/4-20unc X 3/4 3 819 09 10-16 Washer 9/32 X 5/8 X 16 Ga. 4 810 04 04-00 Washer Lock Hvy Helical 1/4 6 873 22 04-00...
Page 32 - CHASSIS AND ENCLOSURES
30 REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 CHASSIS AND ENCLOSURES 123 122 17 80 29 129 134 28 58 37 20 37 23 51 57 53 52 53 64 14 3 74 3 38 39 60 30 14 4 14 13 14 14 4 11 3 31 1 3 2 140 9 14 14 5 5 37 3 3 144 25 26 26 10 26 144 25 26 60 3 3 3 3 3 142 3 3 3 3 142 ...
Page 34 - DRIVE
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 DRIVE 32 66 29 28 112 14 41 42 40 38 42 39 57 51 42 51 74 75 78 76 77 1 25 19 24 2 53 35 34 37 36 35 62 36 64 65 59 56 19 72 55 63 116 70 77 42 61 31 58 22 27 26 6 113 18 51 5 18 6 85 52 61 30 32 32 30 52 61 11 85 80 4 3 13...
Page 35 - DESCRIPTION
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 DRIVE 33 KEY PARTNO. NO. DESCRIPTION KEY PARTNO. NO. DESCRIPTION 1 - - - - - - - - - Transaxle (See Breakdown)Peerless 930-054A 2 532 14 66-82 Spring Return Brake T/a Zinc 3 532 12 36-66 Pulley Transaxle 18" tires 4 812...
Page 36 - STEERING ASSEMBLY
34 REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 STEERING ASSEMBLY 5 9 5 7 7 9 4 3 32 43 6 43 8 18 19 22 21 20 27 62 23 11 40 66 29 25 5 8 10 40 68 68 11 15 8 6 9 46 46 8 6 9 2 47 67 13 65 47 1 41 17 42 37 36 37 26 30 28 38 63 11 39 44 51 54 29 29 29 29
Page 38 - SEAT ASSEMBLY
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 SEAT ASSEMBLY 36 KEY PARTNO. NO. DESCRIPTION KEY PARTNO. NO. DESCRIPTION 1 532 14 08-38 Seat 2 532 14 05-51 Bracket Pivot Seat 8 720 3 874 76 06-16 Bolt Fin Hex 3/8-16unc X 1 4 819 13 16-10 Washer 13/32 X 1 X 10 Ga 5 532 14...
Page 39 - DECALS
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 DECALS 37 10 4 3 9 KEY PART NO. NO. DESCRIPTION KEY PART NO. NO. DESCRIPTION 1 532 05 91-92 Cap Valve Tire 2 532 06 51-39 Stem Valve 3 532 10 62-22 Tire F Ts 15 X 6 0 - 6 Service 4 532 05 99-04 Tube Front (Service Item Only...
Page 40 - OPTIONAL EQUIPMENT
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 ENGINE 38 2 1 OPTIONAL EQUIPMENT Spark Arrester 29 44 46 32 31 33 37 33 40 62 13 4 72 78 81 3 14 38 15 16 78 35 23
Page 42 - MOWER DECK
REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 MOWER DECK 40 86 38 42 2 15 14 12 128 13 11 10 98 1 21 2 29 27 23 26 28 25 24 21 87 88 21 124 31 32 33 69 55 54 56 36 36 89 123 113 53 30 109 89 122 40 89 108 107 68 2 16 96 101 98 99 100 97 21 2 110 43 45 41 19 4 3 129 92 ...
Page 44 - MOWER LIFT
42 REPAIR PARTS TRACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 MOWER LIFT 15 20 16 17 18 20 20 15 20 4 5 6 2 3 1 6 5 4 7 8 10 12 11 31 32 31 32 19 19 13 13 13 13
Page 46 - PEERLESS TRANSAXLE - MODEL NUMBER 930-054A
44 REPAIR PARTS RACTOR - MODEL NO. LT120 (954140002A), PRODUCT NO. 954 1400-02 PEERLESS TRANSAXLE - MODEL NUMBER 930-054A
