Hayward W3SP1580X15 - User Manual
Hayward W3SP1580X15 Pump – User Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – USE ONLY HAYWARD GENUINE REPLACEMENT PARTS; – Separation Hazard.
- Page 4 – Installation Instructions; Pump Location
- Page 5 – Voltage
- Page 6 – Open all valves before starting system.; Storage/Winterization; Drain water level below all inlets to the pool.
- Page 7 – Start-Up for Winterized Equipment; Securely mount pump to base.; Shaft Seal Change Instructions; IMPORTANT SAFETY INSTRUCTIONS; To reduce risk of injury, do not permit children to use this product.
- Page 8 – Troubleshooting; Motor Will NOT Start – Check For:; Mechanical binding and electrical overload.; Motor Hums, But Does NOT Start – Check For:; Centrifugal switch stuck in OPEN position.; Pump Won’t Prime; Check voltage to ensure that the motor is rotating at full RPM’s.
- Page 9 – Noisy Pump – Check For:; Air leak in suction piping causing rumbling in pump.; Maintenance; Keep motor clean. Insure air vents are free from obstruction.
- Page 10 – Replacement Parts; Parts Diagram
- Page 11 – HAYWARD
- Page 12 – Po; owerFlo L; werFlo IITM; mp Series; Wa
USE ONLY HAYWARD GENUINE REPLACEMENT
PARTS
1
PowerFlo LX
™
/ PowerFlo II
™
/ EP
Pump Series
Owner’s Manual
INSTALLATION, OPERATION, & PARTS
IMPORTANT SAFETY INSTRUCTIONS
Hayward Pool Products
620 Division Street, Elizabeth, NJ 07207
Phone: (908) 355-7995
www.haywardnet.com
Contents
Product Warnings……….………2
Installation……….……………..…4
Start-Up & Operation…….…….6
Shaft Seal Replacement……….7
Troubleshooting…………………..8
Replacement Parts………..….…10
Warranty …………………………..…11
Registration………………………….12
ISPFSERIES Rev G
Basic safety precautions should always be followed, including the following: Failure to follow instructions can
cause severe injury and/or death.
This is the safety-alert symbol. When you see this symbol on your equipment or in this manual, look for
one of the following signal words and be alert to the potential for personal injury.
WARNING warns about hazards that could cause serious personal injury, death or major property
damage and if ignored presents a potential hazard.
CAUTION warns about hazards that will or can cause minor or moderate personal injury and/or property
damage and if ignored presents a potential hazard. It can also make consumers aware of actions that are
unpredictable and unsafe.
The NOTICE label indicates special instructions that are important but not related to hazards.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 3 WARNING – Separation Hazard. Failure to follow safety and operation instructions could result in violent separation of pump and/or filter components. Strainer cover must be properly secured to pump housing with strainer cover lock ring. Before servicing p...
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 4 Installation Instructions Pump Location The PowerFlo LX™ and EP series pumps MUST be installed below the pool water line (see Figure to right). Self-priming PowerFlo II™ pumps may be installed up to four (4) feet above the pool water line. Install pump on...
USE ONLY HAYWARD GENUINE REPLACEMENT PARTS 5 Fittings Fittings restrict flow. For better efficiency, use the fewest possible fittings. Avoid fittings that could cause an air trap. Electrical WARNING – Ground motor before connecting to electrical power supply. Failure to ground pump motor can cause s...
