Edelbrock 70410 - Manual
Edelbrock 70410 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 3 – Use only Teflon Paste.
- Page 4 – These tests were conducted with 950psi nitrous bottle pressure.; Never exceed the recommended jetting!; Most aftermarket; performance chips; Nitrous Jetting
- Page 5 – Performer Kit Bill of Materials; Description Item #
- Page 6 – inside the bottle or the bottle valve itself.; Racing Vehicles
- Page 8 – Nitrous Feed Line Mounting; Attach nitrous supply line to bottle.; Solenoid Assembly and Installation
- Page 9 – Nitrous Plate Installation; Remove the two studs from the intake manifold.; Fuel Pressure Take-Off Adapter Installation; Disconnect the connector for the fuel rail pressure sensor.
- Page 10 – Electrical System Installation; Nitrous Electrical Components Bill of Materials (BOM)
- Page 11 – Wide Open Throttle
- Page 12 – Wiring; recommend using an existing ground used by the OEM.; Arming Switch and Installation; for further information.; Final Solenoid and WOT Module Installation Recommendations; wires from shorting out.
- Page 13 – Before You Run Your Vehicle Using Your Edelbrock Nitrous System; Fuel System Check; Solenoid Inspection and Maintenance; Do not open pressurized fuel lines over a hot engine.
- Page 14 – Troubleshooting Your Edelbrock Nitrous System; How to use our Troubleshooting Flowchart:; Symptom #3... Engine runs excessively rich when system is activated.
- Page 15 – Clean or replace filter.; Symptom #6... No change in performance when system is activated.
- Page 16 – Edelbrock Corporation
©2007 Edelbrock Corporation
Brochure #63-0478
Catalog #70410
Rev. 7/07 - DC/mc
Page 1 of 16
EDELBROCK NITROUS SYSTEM
FOR 2005-2007 MUSTANG GT
CATALOG #70410
Table of Contents
Page #
a.
Edelbrock General Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2
b.
Before You Install Your Edelbrock Nitrous System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
c.
What is Nitrous Oxide? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
d.
Safety Steps for Working with Nitrous Oxide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3
1.0 Introduction to your Edelbrock 2005-2007 Mustang GT Nitrous System
1.1
General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.2
Jet Map Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.3
Engine Operation Considerations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
1.4
Performer Kit Bill of Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5
2.0 Nitrous System Installation
2.1
Nitrous Bottle Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
2.2
Bottle Orientation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
2.3
Nitrous Bottle Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
2.4
Nitrous Feed Line Mounting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
2.5
Solenoid Assembly and Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
2.6
Nitrous Plate Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
2.7
Fuel Pressure Take-Off Adapter Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
3.0
Electrical System Installation
3.1
Nitrous Electrical Components Bill of Materials . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
3.2
Wide Open Throttle Module Wiring Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.3
Nitrous Electrical System Installation Procedure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.4
Wide Open Throttle (WOT) Module Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
3.5
Wiring . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.6
Arming Switch and Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3.7
Final Solenoid and WOT Module Installation Recommendations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
4.0
Before You Run Your Vehicle Using Your Edelbrock Nitrous System
4.1
Fuel System Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
4.2
Nitrous System Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
5.0
Solenoid Inspection and Maintenance
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13
6.0
Troubleshooting Guide
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
14-16
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
©2007 Edelbrock CorporationBrochure #63-0478 Catalog #70410 Rev. 7/07 - DC/mc Page 3 of 16 Caution!! Please read this installation manual fully before installing this system. You will need to have available the following tools: Hand Tools: ❑ Socket set including ratchets and extensions ❑ Screwdriver...
Catalog #70410 Rev. 7/07 - DC/mc ©2007 Edelbrock CorporationBrochure #63-0478 Page 4 of 16 1.0 Introduction to your Edelbrock 2005-2007 Mustang GT Nitrous System 1.1 General Information The Edelbrock Performer Nitrous System (Part Number 70410) is designed for the stock to slightly modified2005 to 2...
©2007 Edelbrock CorporationBrochure #63-0478 Catalog #70410 Rev. 7/07 - DC/mc Page 5 of 16 1.4 Performer Kit Bill of Materials Qty. Description Item # ❑ 1 2005-07 Mustang Nitrous Plate 1 ❑ 1 Gasket 2 ❑ 2 4AN x 1/8”NPT Straight Fitting, Red 3 ❑ 1 4AN x 1/8”NPT Nitrous Filter Fitting 4 ❑ 1 3AN x 1/8”N...
