Desa CGP16RA - Manual
Desa CGP16RA – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CONTENTS; SECTION; SAFETY; WARNINGS; Read this owner’s manual carefully and completely; DANGER; Carbon monoxide poisoning may lead to death!; Early signs of carbon monoxide poisoning
- Page 3 – Continued
- Page 4 – Safety Device; American National Standards Institute, Inc.
- Page 5 – AIR FOR; WARNING; PROVIDING ADEQUATE VENTILATION; Unusually Tight Construction; and
- Page 6 – Determining if You Have a Confined or Unconfined Space
- Page 7 – Figure 2 - Ventilation Air from Inside Building; VENTILATION AIR; Ventilation Air From Inside Building
- Page 8 – Ventilation Air From Outdoors; Do not provide openings for inlet or outlet air into attic if attic; Figure 3 - Ventilation Air from Outdoors
- Page 9 – NOTICE; CHECK GAS TYPE; LOCATING HEATER; This heater is designed to be mounted on a wall.; Never install the heater; CAUTION
- Page 10 – Figure 4 - Mounting Clearances As Viewed From Front of Heater; INSTALLING; If you install the heater in a home garage; For convenience and efficiency, install heater
- Page 11 – INSTALLING HEATER TO WALL; Attaching to wall stud; This method provides the strongest hold. Insert mounting; Attaching to wall anchor; This method allows you to attach mounting bracket to; Figure 6 - Removing Front Panel Of Heater; Removing Front Panel Of Heater
- Page 12 – Marking Screw Locations; Figure 7 - Mounting Bracket Clearances; Attaching Mounting Bracket To Wall; Attaching to wall stud method
- Page 13 – “pop” open anchor wings.; Figure 9 - Popping Open Anchor Wings For Thin Walls; Placing Heater On Mounting Bracket; Figure 10 - Mounting Heater Onto Mounting Bracket; Installing Bottom Mounting Screws; Figure 11 - Installing Bottom Mounting Screws
- Page 14 – Figure 12 - External Regulator With Vent Pointing Down; Typical Pipe Diameter
- Page 15 – Figure 13 - Gas Connection; PRESSURE TESTING GAS SUPPLY PIPING SYSTEM; Test Pressures In Excess Of 1/2 PSIG; Connecting to Gas
- Page 16 – water to gas joints. Bubbles forming show a leak.; Test Pressures Equal To or Less Than 1/2 PSIG; PRESSURE TESTING HEATER GAS CONNECTIONS; internal joints for leaks.; Figure 14 - Manual Shutoff Valve; CHECKING; Figure 15 - Checking Gas Joints
- Page 17 – FOR YOUR SAFETY READ BEFORE LIGHTING; LIGHTING INSTRUCTIONS; Figure 16 - Control Knob In The OFF Position
- Page 18 – OPERATING
- Page 19 – TO SELECT HEATING LEVEL; Slightly press in control knob and turn counterclockwise
- Page 20 – MANUAL LIGHTING PROCEDURE; If pilot flame pattern is incorrect, as shown in Figure 20; INSPECTING; Check pilot flame pattern and burner flame pattern often.; PILOT FLAME PATTERN; Figure 19 - Correct Pilot Flame Pattern; Figure 20 - Incorrect Pilot Flame Pattern
- Page 21 – Figure 22 - Incorrect Burner Flame Pattern; If burner flame pattern is incorrect, as shown in Figure 22; Figure 21 - Correct Burner Flame Pattern
- Page 22 – ODS/PILOT AND BURNER ORIFICE; Air Passageways; SHOOTING; Note: All troubleshooting; Turn off heater and let cool before cleaning.; REMEDY
- Page 25 – If you smell gas; TECHNICAL
- Page 26 – SPECIFICATIONS; When gas pressure is too low; SERVICE; Parts Under Warranty
- Page 28 – HEATER EXPLODED VIEW; ILLUSTRATED; BURNER ASSEMBLY
- Page 29 – PARTS LIST
- Page 32 – KEEP THIS WARRANTY; WARRANTY INFORMATION; LIMITED WARRANTY
Save this manual for future reference.
OWNER’S OPERATION AND INSTALLATION MANUAL
VENT-FREE INFARED PROPANE/LP GAS HEATER
Models: CGP16RA and CGP26D
WARNING: If the information in this manual is not followed exactly, a fire or
explosion may result causing property damage, personal injury, or loss of life.
— Do not store or use gasoline or other flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.
— Installation and service must be performed by a qualified installer, service
agency, or the gas supplier.
®
This appliance may be installed in an aftermarket* manufactured (mobile) home,
where not prohibited by state or local codes.
*Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
This appliance is only for use with the type of gas indicated on the rating plate.
This appliance is not convertible for use with other gases.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 101827 CONTENTS SECTION PAGE Safety Information ......................................................................... 2 Product Identification .................................................................... 4 Local Codes .......................................................................
3 101827 SAFETY INFORMATION Continued WARNINGS Continued WARNING: Any change to this heater or its controls can be dangerous. 1. Use only propane/LP gas. Do not convert heater to use different fuel type. 2. Do not place propane/LP supply tank(s) inside any structure. Locate propane/ LP supply tank(s...
4 101827 PRODUCT IDENTIFICATION GRH/PV 006A COMFORT GLOW PLAQUE FRONT-NON THERMO Burners HeaterCabinet FrontPanel GrillGuard PRODUCT FEATURES Safety Device This heater has a pilot with an Oxygen Depletion Sensor Shutoff System (ODS).The ODS/pilot is a required feature for vent-free room heaters. The...
