Desa CGP10A - Manuals

Desa CGP10A – Manual in PDF format online.

Manuals:

Manual

Manual Desa CGP10A

Summary

Page 2 - PROPANE/LP GAS HEATER; Carbon Monoxide Poisoning:; WARNINGS; DANGER: Carbon monoxide

2 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 1. This appliance is only for use with thetype of gas indicated on the rating plate.This appliance is not convertible for usewith other gases. 2. Do not place propane/LP supply tank(s)inside any structure. Locate propane/LP supply tank(s) outdoors. 3. I...

Page 3 - OWNER’S MANUAL; LOCAL CODES; American National Standards Institute,; UNPACKING; Remove heater from carton.; SAFETY PILOT; WARNING: This heater shall

3 101871 OWNER’S MANUAL PRODUCTIDENTIFICATION LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes,use the latest edition of The National FuelGas Code ANSI Z223.1, also known asNFPA 54*. *Available from: American National Standards Institute, Inc. 1430 B...

Page 4 - Unusually Tight Construction; Gas water heater

4 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 WARNING: If the area in which the heater may be operated issmaller than that defined as anunconfined space, provide ad-equate combustion and ventila-tion air by one of the methodsdescribed in the National Fuel Gas Code, ANSI Z223.1, 1992,Section 5.3 or ...

Page 5 - Figure 2 - Ventilation Air from Inside Building; Ventilation Air From Outdoors; Do not provide openings

5 101871 OWNER’S MANUAL FRESH AIR FORCOMBUSTION ANDVENTILATION Continued Or Remove Door into Adjoining Room, Option 3 Ventilation Grills Into Adjoining Room, Option 2 12" 12" Ventilation Grills into Adjoining Room, Option 1 VENTILATION AIR Ventilation Air From InsideBuilding This fresh air w...

Page 6 - For convenience and efficiency, install heater; Marking Screw Locations; Determine where you will locate heater.; Figure 5 - Mounting Screw Locations; JOINING WALL; CHECK GAS TYPE

6 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 For convenience and efficiency, install heater • where there is easy access for opera- tion, inspection, and service • in coldest part of room Figure 4 - Mounting Clearances As ViewedFrom Front of Heater INSTALLING HEATER TOWALL Marking Screw Locations ...

Page 7 - Installing Two Mounting Screws; Wall anchors and mounting screws; Attaching to wall stud method; For attaching mounting screw to wall stud; Figure 6 - Folding Anchor; Figure 8 - Tightening Anchors; Removing Front Panel Of Heater; Mark screw location on wall.

7 101871 OWNER’S MANUAL Installing Two Mounting Screws Note: Wall anchors and mounting screws are in hardware package. The hardwarepackage is provided with heater. Attaching to wall stud method For attaching mounting screw to wall stud 1. Drill hole at marked location using9/64" drill bit. 2. In...

Page 8 - Figure 13 - Gas Connection; CAUTION: Never connect

8 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 IMPORTANT: Hold pressure regulator with wrench when connecting it to gas piping and/ or fittings. Figure 13 - Gas Connection Tee Joint ReducerBushing to1/8" NPT 1/8" NPTPlug Tap TestGaugeConnection * TeeJoint PipeNipple Cap PressureRegulator Hea...

Page 9 - WARNING: Never use an open; Correct all leaks at once.; Figure 14 - Manual Shutoff Valve; Figure 15 - Checking Gas Joints

9 101871 OWNER’S MANUAL CHECKING GASCONNECTIONS WARNING: Test all gas pip- ing and connections for leaksafter installation or servicing.Correct all leaks at once. WARNING: Never use an open flame to check for a leak. Apply amixture of liquid soap and waterto all joints. Bubbles formingshow a leak. C...

Page 10 - Shutting Off Heater

10 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 TO TURN OFF GASTO APPLIANCE 1. Remove front panel (see Figure 10,page 12). 2. Follow steps 1 through 5 under Light-ing Instructions. 3. With control knob pressed in, strikematch. Hold match to pilot until pi-lot lights. 4. Keep control knob pressed in ...

Page 11 - BURNER FLAME PATTERN; WARNING: If yellow tipping; Figure 20 - Correct Burner Flame Pattern; (Model CGP6 will be lower due to; Figure 21 - Incorrect Burner Flame Pattern; PILOT FLAME PATTERN; Figure 19 - Incorrect Pilot Flame Pattern; CABINET; Air Passageways; WARNING: Turn off heater

11 101871 OWNER’S MANUAL BURNER FLAME PATTERN Figure 20 shows a correct burner flamepattern. Figure 21 shows an incorrect burnerflame pattern. The incorrect burner flamepattern shows yellow tipping of the flame. Italso shows the flame higher than 1/2 theglass panel height. NOTICE: Do not mistake ora...

Page 12 - All troubleshooting items are listed; TROUBLESHOOTING; POSSIBLE CAUSE

12 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 Continued Note: All troubleshooting items are listed in order of operation. TROUBLESHOOTING WARNING: Turn off heater and let cool before servicing. Onlya qualified service person shouldservice and repair heater. POSSIBLE CAUSE 1. Ignitor electrode posi...

Page 13 - OBSERVED PROBLEM

13 101871 OWNER’S MANUAL OBSERVED PROBLEM Burner does not light after ODS/pilot is lit Delayed ignition of burner Burner backfiring during combustion Yellow flame during burner combustion Slight smoke or odor during initial opera-tion Heater produces a whistling noise whenburner is lit Heater produc...

Page 14 - IMPORTANT; REMEDY

14 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 TROUBLESHOOTING Continued WARNING: If you smell gas • Shut off gas supply.• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building. • Immediately call your gas supplier from a neighbor’s phone. Fol...

Page 15 - ACCESSORY; When gas pressure is too low; Parts Under Warranty; SPECIFICATIONS

15 101871 OWNER’S MANUAL MANUAL SHUTOFFVALVE - GA5010 Manual shutoff valvewith 1/8" NPT tap. ACCESSORY Purchase this heater accessory from yourlocal dealer. If they cannot supply this ac-cessory, either contact your nearest PartsCentral (see page 18) or call DESAInternational’s Parts Department ...

Page 16 - HEATER EXPLODED VIEW

16 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 12-2 12-1 ODS/PILOT 10 12 11 1 2 3 4 5 6 7 9 8 GRHpv014C CGP10 10 13 14 15 16 17 18 21 23 24 27 22 26 25 19 20 28 29 HEATER EXPLODED VIEW ILLUSTRATEDPARTS LIST

Page 17 - PARTS LIST; PART NUMBER FOR

17 101871 OWNER’S MANUAL PARTS LIST This list contains replaceable parts used in your heater. When ordering parts, follow the instructionslisted under Replacement Parts on page 15 of this manual. PART NUMBER FOR CGP6 CGP10A KEY NO. DESCRIPTION QTY. 1 098304-01 098304-01 Screw, #10 x 3/8" 2 2 099...

Page 18 - PARTS CENTRALS

18 101871 PROPANE/LP GAS HEATER CGP10A AND CGP6 These Parts Centrals are privately owned businesses. They have agreed to support ourcustomer’s needs by providing original replacement parts and accessories. Baltimore Electric1348 Dixwell AvenueHamden, CT 065141-800-397-7553203-248-7553Parts Departmen...

Page 19 - NOTES

19 101871 OWNER’S MANUAL NOTES _______________________________________________________________________________________________ _______________________________________________________________________________________________ _____________________________________________________________________________...

Page 20 - KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:; INTERNATIONAL

KEEP THIS WARRANTY WARRANTY INFORMATION Always specify model and serial numbers when communicating with the factory. We reserve the right to amend these specifications at any time without notice. The only warranty applicable is our standardwritten warranty. We make no other warranty, expressed or im...