Desa CGG3630N - Manual
Desa CGG3630N – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – UNVENTED NATURAL GAS LOG HEATER; WARNING: Any change to; WARNINGS; DANGER: Carbon monoxide
- Page 3 – OWNER’S MANUAL; LOCAL CODES; American National Standards Institute,Inc.; OPERATION; UNPACKING; CAUTION: Do not remove the; Do not pick up
- Page 4 – Unusually Tight Construction; per
- Page 5 – Determining if You Have a Confined or Unconfined Space
- Page 6 – Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Do not provide openings for; Figure 2 - Ventilation Air from Inside Building
- Page 7 – INSTALLATION; CHECK GAS TYPE; Minimum Firebox Size; MINIMUM FIREPLACE; B. Clearances from the top of the fireplace
- Page 8 – If using a mantel, proceed to If Using
- Page 9 – Figure 6 - Minimum Mantel Clearances Without Using Hood; MANTEL CLEARANCES; Figure 7 - Minimum Mantel Clearances When Using Hood; flue damper open; FLOOR CLEARANCES; A. If installing appliance on the floor level,
- Page 10 – Installation Items Needed; Figure 10 - Attaching Damper Clamp
- Page 11 – CAUTION: Avoid damage to; Figure 13 - Gas Connection
- Page 12 – Test Pressures In Excess Of 1/2 PSIG; WARNING: Never use an open; Figure 14 - Manual Shutoff Valve; Figure 15 - Checking Gas Joints; Correct all leaks at once.
- Page 13 – WARNING: Failure to position; INSTALLING LOGS; Figure 17 - Installing Bottom Middle Log; Figure 18 - Installing Front Log
- Page 14 – LIGHTING; • If fireplace has glass doors,; FOR YOUR SAFETY
- Page 15 – Shutting Off Heater; WARNING: Damper handle
- Page 16 – • turn heater off (see To Turn Off Gas to; Figure 24 - Correct Pilot Flame Pattern; WARNING: Do not operate
- Page 17 – WARNING: Turn off heater; • If you remove logs for cleaning, refer to; Figure 29 - Pilot Inlet Air Hole
- Page 18 – TROUBLESHOOTING; POSSIBLE CAUSE; All troubleshooting items are listed in
- Page 19 – OBSERVED PROBLEM; nance, page 17) or replace burner orifice
- Page 20 – IMPORTANT; REMEDY
- Page 21 – Do not remove the screw. Make
- Page 22 – SERVICE HINTS; When Gas Pressure Is Too Low; Model; SPECIFICATIONS; FIREPLACE HOOD
- Page 23 – PARTS UNDER WARRANTY
- Page 25 – PARTS LIST; KEY
- Page 26 – Thermostat-Controlled Model
- Page 28 – KEEP THIS WARRANTY; WARRANTY INFORMATION; NOT A UPC; INTERNATIONAL
1
103424
OWNER’S MANUAL
Save this manual for future reference.
®
WARNING: Improper installation, ad-
justment, alteration, service, or main-
tenance can cause injury or property
damage. Refer to this manual for cor-
rect installation and operational proce-
dures. For assistance or additional in-
formation consult a qualified installer,
service agency, or the gas supplier.
WARNING: This appliance is for in-
stallation only in a solid-fuel burning
masonry or UL127 factory-built fire-
place, or in an approved ventless fire-
box. It is design-certified for these
installations in accordance with ANS
Z21.11.2.
Exception: Do not install this appli-
ance in a factory-built fireplace that
includes instructions stating it has
not been tested or should not be used
with unvented gas logs.
WARNING: This is an unvented gas-fired heater. It uses air (oxygen) from the room in
which it is installed. Provisions for adequate combustion and ventilation air must be
provided. Refer to
Air for Combustion and Ventilation section, page 4, in this manual.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do
not use any phone in your building.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas sup-
plier, call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency, or the gas supplier.
CGG2618N,
CGG3324N(T), and
CGG3630N
Thermostat and
Variably-Controlled
Models
UNVENTED (VENT-FREE)
NATURAL GAS LOG HEATER
This appliance may be installed in an aftermarket* manufactured (mobile) home, where not prohibited
by state or local codes.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
VARIABLE MANUALLY-CONTROLLED MODELS ALSO DESIGN-CERTIFIED
AS VENTED DECORATIVE APPLIANCES
OWNER’S OPERATION AND INSTALLATION MANUAL
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 UNVENTED NATURAL GAS LOG HEATER 103424 WARNING: Any change to this heater or its controls can bedangerous. SAFETYINFORMATION Carbon Monoxide Poisoning: Early signs of carbon monoxide poisoning re-semble the flu, with headaches, dizziness,or nausea. If you have these signs, the heatermay not be wor...
3 103424 OWNER’S MANUAL LOCAL CODES Install and use heater with care. Follow alllocal codes. In the absence of local codes, usethe latest edition of The National Fuel GasCode ANS Z223, also known as NFPA 54*. *Available from: American National Standards Institute,Inc. 1430 Broadway New York, NY 1001...
4 UNVENTED NATURAL GAS LOG HEATER 103424 AIR FORCOMBUSTION ANDVENTILATION Today’s homes are built more energy efficientthan ever. New materials, increased insula-tion, and new construction methods help re-duce heat loss in homes. Home owners weatherstrip and caulk around windows and doors tokeep the...
