Desa CGD3018P - Manual
Desa CGD3018P – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – CONTENTS; SECTION; SAFETY; WARNINGS; DANGER; Carbon monoxide poisoning may lead to death!; Early signs of carbon monoxide poisoning resemble; Propane Gas; Safety Information continues on next page
- Page 3 – Continued
- Page 5 – WARNING; Unconfined Space; PROVIDING ADEQUATE VENTILATION; Unusually Tight Construction; and
- Page 6 – Determining if You Have a Confined or Unconfined Space
- Page 7 – VENTILATION AIR; Ventilation Air From Inside Building; Figure 3 - Ventilation Air from Outdoors; Ventilation Air From Outdoors; Figure 2 - Ventilation Air from Inside Building
- Page 8 – INSTALLING; Never install the heater; CHECK GAS TYPE
- Page 9 – Minimum Wall and Ceiling Clearances (see Figure 4); should not be less than 16 inches.; LOG SIZING REQUIREMENTS
- Page 10 – NOTICE; Installing Damper Clamp; Minimum Non Combustible Material Clearances; If you cannot meet these minimum clearances, you must operate; Requirements for; Non combustible material okay.
- Page 11 – If Using Mantel; Mantel Clearances
- Page 12 – Floor Clearances
- Page 13 – Area of Various Standard Round Flues; Damper; Manufactured Fireplace
- Page 14 – CAUTION; Make sure the heater burner is level. If heater is not level, heater; Installation Items Needed; Hold gas regulator with wrench when connecting flexible gas hose.; Figure 11 - Attaching Flexible Gas Hose to Heater Gas Regulator; Fitting
- Page 15 – • external regulator (supplied by; Masonry Screw; Figure 12 - Attaching Base Assembly to Fireplace Floor
- Page 16 – Figure 13 - External Regulator With Vent Pointing Down
- Page 17 – Figure 14 - Gas Connection; Pressure Testing gas Supply Piping system; Test Pressures In Excess Of 1/2 PSIG; Connecting to Gas Sup-; CHECKING GAS CONNECTIONS
- Page 18 – opening propane supply tank valve.; Test Pressures Equal To or Less Than 1/2 PSIG; propane supply tank valve.; Pressure Testing Heater Gas Connections; internal joints for leaks.; Figure 15 - Manual Shutoff Valve; Open; Figure 16 - Checking Gas Joints; Control Valve Location
- Page 19 – INSTALLING LOGS
- Page 20 – FOR YOUR SAFETY READ BEFORE LIGHTING; LIGHTING INSTRUCTIONS; fireplace screen is closed before running heater.
- Page 21 – TO TURN OFF GAS TO APPLIANCE; Shutting Off Heater; Shutting Off Burners Only (pilot stays lit); Do not operate heater between PILOT and HIGH positions.; VARIABLE CONTROL OPERATION
- Page 22 – Check pilot flame pattern and burner flame patterns often.; PILOT FLAME PATTERN; Figure 23 - Correct Pilot; Pilot Burner; Figure 24 - Incorrect Pilot; MANUAL LIGHTING PROCEDURE; release control knob. Now follow step 8 on page 21.; OPERATING
- Page 23 – Turn off heater and let cool before cleaning.; SHOOTING; shooting items are; REMEDY; LOGS
- Page 26 – If you smell gas; Operating heater where impurities in air exist may create odors.; See Warning
- Page 27 – SPECIFICATIONS; When gas pressure is too low; SERVICE
- Page 28 – age for parts replaced under warranty.; Parts Under Warranty; Parts Not Under Warranty; When calling DESA International, have ready; REPLACEMENT
- Page 29 – ACCESSORIES
- Page 31 – PARTS LIST
- Page 32 – KEEP THIS WARRANTY; WARRANTY INFORMATION; Model; LIMITED WARRANTY; For information about this warranty write:
Save this manual for future reference.
®
YELLOW FLAME DESIGN
UNVENTED (VENT-FREE)
PROPANE/LP GAS LOG HEATER
— Also Designed Certified as Vented Decorative Appliance —
This appliance may be installed in an aftermarket* manufactured (mobile) home, where
not prohibited by state or local codes. This appliance is only for use with the type of gas
indicated on the rating plate. This appliance is not convertible for use with other gases.
* Aftermarket: Completion of sale, not for purpose of resale, from the manufacturer
OWNER’S OPERATION AND INSTALLATION MANUAL
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
— Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
— WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch;
do not use any phone in your build-
ing.
• Immediately call your gas supplier
from a neighbor’s phone. Follow the
gas supplier’s instructions.
• If you cannot reach your gas sup-
plier, call the fire department.
— Installation and service must be per-
formed by a qualified installer, service
agency, or the gas supplier.
WARNING: Improper installation, adjust-
ment, alteration, service, or maintenance
can cause injury or property damage.
Refer to this manual for correct installa-
tion and operational procedures. For
assistance or additional information
consult a qualified installer, service
agency, or the gas supplier.
WARNING: This gas log set is for instal-
lation in a masonry solid fuel burning
fireplace or a U.L. listed manufactured
solid fuel burning fireplace.
WARNING: This is an unvented gas-
fired heater. It uses air (oxygen) from
the room in which it is installed. Provi-
sions for adequate combustion and ven-
tilation air must be provided. Refer to
Air for Combustion and Ventilation sec-
tion in this manual.
18", 24", and
30" Variable
Manually-
Controlled
Models
CGD3018P
CGD3924P
CGD3930P
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
2 102987 CONTENTS SECTION PAGE SAFETY INFORMATION WARNING ICON G 001 WARNINGS IMPORTANT: Read this owner’s manual carefully and completely beforetrying to assemble, operate, or service this heater. Improper use of thisheater can cause serious injury or death from burns, fire, explosion,electrical sh...
3 102987 SAFETY INFORMATION Continued WARNING ICON G 001 WARNINGS Continued WARNING: Any change to this heater or its controls can be dangerous. 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases. 2. Do not...
5 102987 AIR FOR COMBUSTION AND VENTILATION WARNING ICON G 001 WARNING This heater shall not be installed in a confined space unlessprovisions are provided for adequate combustion and ventilationair. Read the following instructions to insure proper fresh air forthis and other fuel-burning appliances...
