COZY 78111 - Manual
COZY 78111 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.
Table of Contents:
- Page 2 – MODELS WITH LOW-BTU STANDING PILOT; CONTENTS
- Page 3 – SAFETY RULES; Adequate air for combustion and venting must be provided.; READ CAREFULLY BEFORE INSTALLING UNIT
- Page 4 – FIGURE A
- Page 5 – COMBUSTION AND VENTILATION AIR
- Page 6 – Side Wall; MODEL NUMBER; ” Minimum; FIGURE 2; Header Plate; FIGURE 3
- Page 8 – INSTALLATION / WHEN RECESSED; INSTALLATION
- Page 9 – FIGURE B; CONTROLS; NATURAL GAS; SPECIFIC ELEVATIONS; PILOT ADJUSTMENT; STANDING PILOT
- Page 10 – causing property damage, personal injury or loss of life.; WHAT TO DO IF YOU SMELL GAS:; LIGHTING INSTRUCTIONS
- Page 13 – TERMINAL BLOCK WIRING DIAGRAM; AUXILIARY LIMIT SWITCH; the heating season or as often as needed.
- Page 14 – Thermostat; Motor; MOTOR
- Page 15 – IGNITION
- Page 16 – ROUGH-INS FOR REAR OR SIDE DISCHARGE; Install plastergrounds as shown in Figure 12 and Figure 13.; OPTIONAL ACCESSORY KITS
- Page 17 – SIDE DISCHARGE ON CASING; OPTIONAL KITS - CONTINUED; MODEL; 4PEK-A PLUG EXTENSION KIT INSTRUCTIONS
- Page 18 – TROUBLE SHOOTING CHART - PILOT AND VALVE
- Page 19 – FOR BLOCKED FLUE SWITCH PROBLEMS; TROUBLE SHOOTING CHART - PILOT AND VALVE - CONTINUED
- Page 20 – COUNTERFLOW WALL FURNACE / STANDING PILOT; CONTROL ASSEMBLY
- Page 21 – HOW TO PROPERLY ORDER PARTS
- Page 23 – HOW TO PROPERLY ORDER PARTS:
- Page 26 – TAMPERING IS DANGEROUS
- Page 27 – L I M I T E D W A R R A N T Y; LOUISVILLE TIN & STOVE COMPANY; TABLE A
COUNTERFLOW
WALL FURNACE
INSTALLATION AND
OPERATING INSTRUCTIONS
P/N 78111
REV. 10/08
MODEL NUMBERS
WARNING: Operation of this furnace when not connected to a properly installed and maintained venting
system can result in Carbon Monoxide (C.O.) poisoning and possible death. For your safety, this furnace
and the venting system should be inspected at least annually by a qualified service person.
The coating selected to provide longer life to the heat exchanger may smoke slightly upon initial firing. Please provide
adequate ventilation if this occurs.
This unit is not approved for installation in mobile homes, greenhouses, or environments involving dusty, wet, corrosive, or
explosive conditions. Such conditions will invalidate the warranty and may create unsafe conditions.
R
R
24 VOLT SYSTEM
NATURAL GAS CF357C-H CF557C-H
WITH INTERMITTENT
IGNITION (I.I.D.)
L.P. GAS CF358C-H CF558C-H
-
Do not store or use gasoline or other flammable vapors and liquids in
the vicinity of this or any other appliance.
WHAT TO DO IF YOU SMELL GAS:
¾
¾
¾
¾
¾
Do not try to light any appliance.
¾
¾
¾
¾
¾
Do not touch any electrical switch; do not use any phone in your
building.
¾
¾
¾
¾
¾
Immediately call your gas supplier from a neighbor’s phone.
Follow the gas supplier’s instructions.
¾
¾
¾
¾
¾
If you cannot reach your gas supplier, call the fire department.
-
INSTALLATION AND SERVICE MUST BE PERFORMED
BY A QUALIFIED INSTALLER, SERVICE AGENCY OR
THE GAS SUPPLIER.
WARNING: If the information in this manual is not followed exactly, a fire or
explosion may result causing property damage, personal injury or loss of life.
24 VOLT SYSTEM NATURAL GAS CF353C-H CF503C-H CF653C-H
WITH LOW-BTU
PILOT
L.P. GAS CF354C-H CF504C-H CF654C-H
This appliance is equipped
with a blocked flue switch
designed to protect against
improper venting of combus-
tion products.
THIS UNIT IS NOT TO BE
INSTALLED IN MOBILE
HOMES.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.
Summary
INTRODUCTION THIS IS A GAS-FIRED, GRAVITY VENTED WALL FURNACE THAT WILL OPERATE SAFELY AND PROVIDE AN EFFICIENTSOURCE OF HEAT WHEN INSTALLED, OPERATED AND MAINTAINED AS RECOMMENDED IN THESE INSTALLATIONAND OPERATING INSTRUCTIONS. READ THESE INSTRUCTIONS THOROUGHLY BEFORE INSTALLING, SERVICING, ORUSI...
SAFETY RULES 1. Improper installation, adjustment, alteration, service or maintenance can cause property damage, bodily injury or death. If youdo not understand these instructions or your local codes, call local authorities, a qualified installer, service agency, gas supplier,or the manufacturer. 2....
VENTING - CONTINUED This appliance is equipped with a blocked flue switch. WARNING: Do not bypass the blocked flue switch. Todo so could expose the consumer to property damage,personal injury or possible death. This switch, when activated, will interrupt the electrical circuit betweenthe transformer...
