Char-Broil 463211512 - Manual

Page 2 - TABLE OF CONTENTS; Do not store or use gasoline or other; For residential use only. Do not use for commercial; DANGER; Safety Symbols; DANGER; THIS GRILL IS FOR OUTDOOR USE ONLY.; CAUTION

TABLE OF CONTENTS For Your Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3 Grilling Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4-7 Use and Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-13 Limit...

Page 3 - Wash your hands after handling this product.; National Fuel Gas; over tighten screws and

3 WARNING CALIFORNIA PROPOSITION 651. Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. 2. This product contains chemicals, including lead and lead compounds, known to the State of C...

Page 4 - Turn on the appropriate control knob and light the grill per the; Pre-Heating Your Grill; GRILLING GUIDE – Getting Started; Regulator

4 First Time Use Read your Assembly Manual and ensure the grill is put together properly. Remove all Point-of-Purchase advertising material from all grill surfaces before first use. We recommend operating your grill on its highest setting for 15-20 minutes prior to your first use. This aids in remov...

Page 5 - GRILLING GUIDE – Grilling 101

5 Outdoor grilling is really quite simple. You'll succeed with burgers, dogs, or steaks usually on your very first try. With experience, you will learn how to work with your grill, creating more imaginative meals all the time. This knowledge makes up the art of grilling. Before you start grilling, o...

Page 7 - GRILLING GUIDE – Cleaning Your Grill; Storing Your Grill

7 Why Clean? We've all heard the saying 'An ounce of prevention is worth a pound of cure'. This is great advice when it comes to keeping your grill clean. Routine Care Periodic cleaning of this grill is necessary,as grill fires can occur when grease andfood debris collect in the bottom of the grill....

Page 8 - USE AND CARE; OPD Hand Wheel; LP Cylinder Filling; LP Cylinder Valve

8 • NEVER store a spare LP cylinder under or near the appliance or in an enclosed area. • Never fill a cylinder beyond 80% full.• An over filled or improperly stored cylinder is a hazard due to possible gas release from the safety relief valve. This could cause an intense fire with risk of property ...

Page 9 - Connecting Regulator to the LP Cylinder; full stop; Safety Relief Valve; Strap and Cap; LP Cylinder Exchange; Exchange your cylinder only; LP Cylinder Leak Test; Do not use household cleaning agents.

9 WARNING If “growing” bubbles appear do not use or move the LP cylinder. Contact an LP gas supplier or your fire department! Connecting Regulator to the LP Cylinder 1. LP cylinder must be properly secured onto grill. (Refer to assembly section.) 2. Turn all control knobs to the OFF position. 3. Tur...

Page 10 - Leak Testing Valves, Hose and Regulator; rushing sound; immediately

10 6. Turn the coupling nut clockwise and tighten to a full stop. The regulator will seal on the back-check feature in the LP cylinder valve, resulting in some resistance. An additional one-half to three-quarters turn is required to complete the connection. Tighten by hand only – do not use tools. N...

Page 11 - Lighting instructions are continued on the next page; Do not let children operate or play near grill.

11 Safety Tips s Before opening LP cylinder valve, check the coupling nut for tightness. s When grill is not in use, turn off all control knobs and LP cylinder valve. s Never move grill while in operation or still hot. s Use long-handled barbecue utensils and oven mitts to avoid burns and splatters....

Page 12 - Troubleshooting Section; LOW

12 Burner Flame Check • Remove cooking grates and flame tamers. Light burners, rotate knobs from HI to LOW . You should see a smaller flame in LOW position than seen on HI . Perform burner flame check on sideburner, also. Always check flame prior to each use. If only low flame is seen refer to "...

Page 13 - Cleaning the Burner Assembly; Turn gas OFF at control knobs and LP cylinder.; Cleaning the Burner; Firebox

13 Cleaning the Burner Assembly Follow these instructions to clean and/or replace parts of burnerassembly or if you have trouble igniting grill.1. Turn gas OFF at control knobs and LP cylinder. 2. Remove cooking grates and flame tamers. 3. Remove carryover tubes and burners. 4. 5. Carefully lift eac...

Page 14 - ITEMS MANUFACTURER WILL NOT PAY FOR:; DISCLAIMER OF IMPLIED WARRANTIES and LIMITATION OF REMEDIES; LIMITED WARRANTY; SCOPE OF COVERAGE

14 This warranty only applies to units purchased from an authorized retailer. Manufacturer warrants to the original consumer-purchaser only that this product shall be free from defects in workmanship and materials after correct assembly and under normal and reasonable home use for the periods indica...

Page 15 - PARTS LIST; Key

PARTS LIST 15 NO T E: S om e gr i ll p ar t s sh ow n i n th e as s em bl y s te ps m a y di ff e r sl ig h tl y in a p pe ar a nc e fr o mt ho se o n y ou r pa r ti cu l ar g ri l l mo de l . Ho we ve r, t he m et h o d of a s se mb l y re ma i ns t he s a me . Key Qty Description A 1 FIREBOX B 1 T...

Page 16 - PARTS DIAGRAM

PARTS DIAGRAM 16 I A D C J Q S R P O H G E U V W M L K G Y T N S B X Z Z AA CC DD EE FF GG HH LL MM RR II TT KK PP OO NN XX QQ SS VV WW T T T S S YY Y AA C C E E F F F F zz UU BB AAA JJ JJ TT AAA M

Page 17 - ASSEMBLY; Rear

17 ASSEMBLY 1 2 CAUTION: When unpacking grill components, two people should raise grill head from the shipping box. ASSEMBLY Take the leg assembly out from the shipping box, place it as shown. Place bottom shelf to bottom shelf brace.Tighten the pre-installed screws to bottom shelf. Bottom Shelf Rig...

Page 22 - Grease Cup

22 10 Grease Cup B A Place left side shelf to the left side of firebox (A).Tighten the pre-installed screws to the left side shelf (B).Remove the nut from injecter, insert the injecter to the hole on the sideburner brace, re-install and tighten the nut to fix the to sideburner brace (C).Remove the s...

Page 24 - • Failure to install tank correctly may allow gas hose to

24 13 14 Failure to install grease cup clip and cup will cause hot grease to drip from bottom of grill with risk of fire or property damage. CAUTION CAUTION • Failure to install tank correctly may allow gas hose to be damaged in operation, resulting in the risk of fire. LP tank is sold separately. U...

Page 25 - Troubleshooting

25 DANGER: If a gas leak cannot be stopped, or a fire occurs due to gas leakage, call the fire department. Emergencies Problem Gas leaking from cracked/cut/burned hose. Gas leaking from LP cylinder. Gas leaking from LP cylinder valve. Gas leaking between LP cylinder and regulator connection. Fire co...

Page 26 - continued; Problem

26 Troubleshooting ( continued ) Problem Burner(s) will not light using ignitor.(See Electronic Ignition Troubleshooting also) Burner(s) will notmatch light. Sudden drop in gasflow or low flame. Flames blow out. Flare-up. Persistent grease fire. Flashback...(fire in burner tube(s)). Unable to fill L...

Page 27 - Troubleshooting - Electronic Ignition; SECTION I

27 Troubleshooting - Electronic Ignition Problem (Ignition) SECTION I No sparks appear at any electrodes when Electronic Ignition Button is pressed; no noise can be heard from spark module. SECTION II SECTION III Sparks are present but not at all electrodes and/or not at full strength Possible Cause...

Page 28 - NOTES

Page 31 - STICKER ON PRODUCT; Please register your product online at: