Carrier Air V - User Manual

OWNER ’ S GUIDE - OPERATING INSTRUCTIONS GLOSSARY OF CONTROL SYMBOLS OFF LOW FAN HIGH FAN When dial is turned to the OFF position the unit will NOT operate. When leaving your vehicle for any period of time, make sure themaster control dial is set to the OFF position. LOW FAN will circulate relativel...

OWNER ’ S GUIDE - 1 2 1 2 5 AIR SWEEP CONTROL Your unit provides an automatic air sweep to cool the roommore efficiently. When the air sweep switch is set on (|),the horizontal blade moves slowly up and down and dis-tributes the air around the room. The direction of the verti-cal blades can be adjus...

OWNER ’ S GUIDE - 1 2 3 Moving parts can cause personal injury. Be careful when test-running the unit. Do not operate the unit with exterior cover removed. WARNING 6 During extreme outdoor temperatures, the heat gainof the vehicle may be reduced by:- parking the vehicle in a shaded area- keeping the...

OWNER ’ S GUIDE - 7 CASE B. If a roof vent opening is not used, a new opening (See Figure 1) will have to be cut into the vehicle roof. A matchingopening will also have to be cut into the interior vehicle ceiling. Be careful when cutting the ceiling opening becauseif the ceiling opening is carpeted,...

OWNER ’ S GUIDE - 8 • Once the roof top air conditioner has been leveled, some additional shimming may be required above the interiorceiling assembly. The roof top air conditioner and theinterior ceiling assembly must be square with each otherbefore they are secured together. • After the mounting ho...

OWNER ’ S GUIDE - Secure the ceiling assembly frame to the roof topair conditioner with the mounting bolts (See 햳 , Figure 4). You must start (thread) the mountingbolts* by hand to avoid cross-threading. DO NOTSTART THE MOUNTING BOLTS WITH AN AIR GUN.The mounting bolts should be tightened evenly.Do ...

OWNER ’ S GUIDE - STEP 3 - ELECTRICAL WIRING Route a copper, with ground, supply wiring withminimum, #12 A WG from its power source to thejunction box. Do not attach them at this time. Take the roof top air conditioner electrical harness andplug it into the side of the selector switch control box.Ma...

OWNER ’ S GUIDE -12 STEP 4 - COMPLETING THE INSTALLATION IF INSULATED CABLE IS NOT AVAILABLE, APPROPRIATE STRAINRELIEF CONNECTORS OR CLAMPS SHOULD BE USED.THERE SHOULD BE NO CLAMPING OR PINCHING APPLIEDTO THE INDIVIDUAL SUPPLY LEADS. Connect the power line to the black, white andground wires found i...

OWNER ’ S GUIDE - TROUBLE SHOOTING GUIDE 13 If you have problems with your recreation vehicle air conditioner, check this guide before contacting your servicerepresentative. TROUBLE POSSIBLE CAUSES SOLUTION THE UNIT DOESNOT START Check the power supply of the vehicleand make sure it is provided corr...

OWNER ’ S GUIDE - Remove cover and wash the condenser coilRemove cover and clean the water drainsClean the filters**Generally, filters should be cleaned every 30 days.The filters are very efficient in removing airborneparticles.M o r e f r e q u e n t c l e a n i n g m a y b e n e c e s s a r ydepen...

OWNER ’ S GUIDE - 15 NO PART NAME 13 FAN MOTOR SEAL 14 BRACKET ASSY MOTOR 15 CLIP, MOUNTING 16 MOTOR, FAN 17 RING, COMPRESSION 18 COVER ASSY, CONDENSER 19 FAN, PROPELLER 20 ORIFICE, CONDENSER 21 COVER ASSY, EXTERIOR 22 COIL ASSY, COND 23 COMPRESSOR 24 TERMINAL COVER NO PART NAME 25 OVERLOAD PROTECTO...