Briggs & Stratton 91200, 92200, 94200 - Manual

Briggs & Stratton 91200, 92200, 94200

Briggs & Stratton 91200, 92200, 94200 – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
Page: / 20

Table of Contents:

  • Page 2 – THE POWER IN POWER EQUIPMENT; ” gas
  • Page 3 – BEFORE OPERATING ENGINE; DANGER; HAZARD SYMBOLS AND MEANINGS; WARNING
  • Page 4 – SAFETY; Fire or explosion can cause severe burns or death.; WHEN ADDING FUEL; Fill fuel tank outdoors or in well-ventilated area.; WHEN STARTING ENGINE; Do not crank engine with spark plug removed.; WHEN OPERATING EQUIPMENT; Do not choke carburetor to stop engine.; WHEN TRANSPORTING EQUIPMENT; WHEN TESTING FOR SPARK; Use approved spark plug tester.; Starting engine creates sparking.
  • Page 5 – Start and run engine outdoors.; Severe thermal burns can occur on contact.; Operate equipment with guards in place.
  • Page 6 – ENGINE PARTS; GENERAL INFORMATION; ENGINE MODEL; TUNE-UP SPECIFICATIONS; THE INTERNATIONAL SYMBOLS USED
  • Page 7 – OIL; OIL CAPACITY; Do not use special additives.; C) will result in higher; SAE Viscosity Grades; Check oil level before starting the engine.; Oil Fill
  • Page 8 – FUEL; TYPE OF FUEL TO USE; Do not use gasoline which contains Methanol.; ADDING FUEL; fuel can fills to the; Fuel Fill
  • Page 9 – STARTING; Do not use pressurized starting fluids.; STARTING AND OPERATING TIPS; Store and fuel equipment in level position.
  • Page 10 – STARTING AND STOPPING; TO START ENGINE; Move choke control lever to CHOKE.; TO STOP ENGINE
  • Page 11 – MAINTENANCE; Task; CHANGING OIL; Change oil after first 5 hours of use.; Typical drain plugs
  • Page 12 – CHANGING OIL IN GEAR REDUCTION (if; Replace both oil plugs.; AIR CLEANER; REMOVING AND RE-INSTALLING AIR CLEANER; Loosen screws and remove cover.; CLEANING PRE-CLEANER AND CARTRIDGE
  • Page 13 – Finger Guard
  • Page 14 – ADJUSTMENTS; THROTTLE ADJUSTMENT; TO ADJUST REMOTE THROTTLE*; CARBURETOR ADJUSTMENT; TO ADJUST CARBURETOR*
  • Page 15 – Briggs & Stratton Corporation; Parts List
  • Page 16 – STORAGE; Engines stored over 30 days need special attention.; both sides of this order form carefully
Loading the manual

Model Series

Covered in

This Manual

91200
92200
94200

Operating & Maintenance

Instructions

Model

Type

Code

Month Day

Year

Note: General Model Series numbers noted above include many specific numbers
like the ones on your engine. To get replacement parts or technical assistance in
the future, write your engine Model, Type, Code and date of purchase here.

TABLE OF CONTENTS
Safety

3-5

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Engine Information

6

. . . . . . . . . . . . . . . . . . . . . . . .

Oil

7

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuel

8

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Starting Information

9

. . . . . . . . . . . . . . . . . . . . . . .

Starting and Stopping

10

. . . . . . . . . . . . . . . . . . . . .

Maintenance

11-13

. . . . . . . . . . . . . . . . . . . . . . . . .

Adjustments

14

. . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Parts and Service & Storage

15-16

. . . . . . . . . . . .

Warranty Information

17

. . . . . . . . . . . . . . . . . . . . .

WARNING

Briggs & Stratton does not approve or authorize the use of
these engines on 3-wheel All Terrain Vehicles (ATVs), motor
bikes, aircraft products or vehicles intended for use in
competitive events. Use of these engines in such applications
could result in property damage, serious injury (including
paralysis), or even death.

In the USA and Canada our 24 hour hotline is

1-800-233-3723

Briggs & Stratton Corporation

Milwaukee, Wisconsin 53201

www.briggsandstratton.com

PRINTED IN U.S.A.

Copyright 2000 by Briggs & Stratton Corporation

FORM NO. 274778-9/00

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - THE POWER IN POWER EQUIPMENT; ” gas

2 THE POWER IN POWER EQUIPMENT  Thank you for selecting a Briggs & Stratton engine to power your equipment. Briggs & Stratton is committed to producing a line of engines which will make your life’s chores easier toperform. We have, at the same time, improved the design of our engines so the...

Page 3 - BEFORE OPERATING ENGINE; DANGER; HAZARD SYMBOLS AND MEANINGS; WARNING

3 BEFORE OPERATING ENGINE • Read entire Operating & Maintenance Instructions ANDthe instructions for the equipment this engine powers.* • Failure to follow instructions could result in serious injuryor death. THE OPERATING & MAINTENANCE INSTRUCTIONSCONTAIN SAFETY INFORMATION TO • Make you aw...

Page 4 - SAFETY; Fire or explosion can cause severe burns or death.; WHEN ADDING FUEL; Fill fuel tank outdoors or in well-ventilated area.; WHEN STARTING ENGINE; Do not crank engine with spark plug removed.; WHEN OPERATING EQUIPMENT; Do not choke carburetor to stop engine.; WHEN TRANSPORTING EQUIPMENT; WHEN TESTING FOR SPARK; Use approved spark plug tester.; Starting engine creates sparking.

4 SAFETY WARNING Gasoline and its vapors are extremely flammableand explosive. Fire or explosion can cause severe burns or death. WHEN ADDING FUEL • Turn engine OFF and let engine cool at least 2minutes before removing gas cap. • Fill fuel tank outdoors or in well-ventilated area. • Do not overfill ...

Other Briggs & Stratton Models

All Briggs & Stratton Other