Yamaha MZ360- Manuals

vii ENGINE SWITCH OFF CIRCUIT BREAKER OFF PRESS AND HOLD ENGINE SWITCH NEUTRAL BONDED TO FRAME HRS MAINTENANCE Hz Fig. 25 A - Engine switch (commutateur du moteur, interruptor encendido/apagado del motor) A - Spark plug (bougie, bujía) B - Spark plug cap (capuchon de bougie, tapa de la bujía) Fig. 2...

2 — English DANGER: GROUNDING THE GENERATOR To reduce the risk of shock or electrocution, generator must be properly grounded. The nut and ground terminal on the frame must always be used to connect the generator to a suitable ground source. The ground path should be made with #8 size wire. Connect ...

3 — English IMPORTANT SAFETY INSTRUCTIONS DANGER: Carbon Monoxide. Using a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains high levels of carbon monoxide (CO), a poisonous gas you cannot see or smell. If you can smell the generator exhaust, you are breathing CO. But even if you ...

4 — English SPECIFIC SAFETY RULES WARNING: When this generator is used to supply a building wiring system: generator must be installed by a qualified electrician and connected to a transfer switch as a separately derived system in accordance with NFPA 70, National Electrical Code. The generator shal...

5 — English SYMBOLS Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the product better and safer. SYMBOL NAME DESIGNATION/EXPLANATION Safety Alert Indicates a potential personal inj...

6 — English SYMBOLS Some of the following symbols may be used on this product. Please study them and learn their meaning. Proper interpretation of these symbols will allow you to operate the product better and safer. SYMBOL NAME DESIGNATION/EXPLANATION V Volts Voltage A Amperes Current Hz Hertz Freq...

7 — English SYMBOLS ELECTRICAL EXTENSION CORD CABLE SIZE Refer to the table below to ensure the cable size of the extension cords you use are capable of carrying the required load. Inadequate size cables can cause a voltage drop, which can damage the appliance and overheat the cord. Current in Amper...

8 — English CONTROL PANEL CORD (NOT PROVIDED) See Figure 1. The 25-ft. control panel cord (Model RDEC25) has a 240 Volt, 20 Amp twist lock plug on one end and a 240 Volt, 20 Amp twist lock receptacle on the other end. It also has a 12 Volt DC engine control connector on each end. When using this cor...

9 — English ELECTRICAL Example: Tool or Appliance Running Watts* Additional Starting Watts* Quartz Work Light (1000 Watt) 1000 0 Reciprocating Saw 960 960 Drill (1/2 inch, 5.4 amps) 600 900 Circular Saw (Heavy Duty, 7-1/4 in.) 1400 2300 Demolition hammer 600 1200 4560 Total Running Watts 2300 Highes...

10 — English PRODUCT SPECIFICATIONS ENGINE Engine Type ....................... Yamaha MZ360, 4 Stroke, OHVFuel Volume ................................................................ 8 gal. GENERATOR Rated Voltage .....................................................120V/240VRated Amps ................

11 — English FEATURES RECOIL STARTER GRIP The recoil starter is pulled to start the machine. REMOVABLE CONTROL PANEL The removable control panel can be wall-mounted for use with the RDEC25 control panel cord (not provided) for opera-tion in a variety of locations. ASSEMBLY UNPACKING This product req...

12 — English INSTALLING LEGS See Figure 6.  Locate the following items: Legs with rubber feet (left and right) 6 washers (1/4 in.) 6 lock nuts 4 screws (2 in.) 2 screws (1 in.)  Raise the front end of the generator, where the engine is located, high enough to gain access to the frame bottom; secur...

13 — English OPERATION DANGER: Carbon Monoxide. Using a generator indoors CAN KILL YOU IN MINUTES.Generator exhaust contains high levels of carbon monoxide (CO), a poisonous gas you cannot see or smell. If you can smell the generator exhaust, you are breathing CO. But even if you cannot smell the ex...

14 — English CHECKING/ADDING LUBRICANT See Figure 13. NOTICE: Attempting to start the engine before it has been properly filled with lubricant will result in equipment failure. Engine lubricant has a major influence on engine perfor-mance and service life. For general, all-temperature use, SAE 10W-3...

15 — English OPERATION NOTE: You must push the off switch and hold it until the engine has fully stopped.The removable control panel has two 120 Volt duplex GFCI power outlets with outlet covers. Each duplex outlet has a Test and a Reset push button. NOTE: The GFCI outlets may be shown without their...

16 — English OPERATION LIFTING THE GENERATOR See Figure 20.  Fold the handle to the down position. Never lift or carry this product using the handle. NOTE: This tool is heavy and requires several people to lift. To avoid back injury, keep your knees bent and lift with your legs, not your back, and ...

17 — English MAINTENANCE WARNING: When servicing, use only identical replacement parts. Use of any other parts could create a hazard or cause product damage. Only the parts shown on the parts list are intended to be repaired or replaced by the customer. All other parts should be replaced at an autho...

18 — English SPARK ARRESTOR See Figure 26.  Inspect the spark arrestor for breaks or holes. Replace if necessary. To purchase a replacement spark arrestor contact RIDGID customer service at 1-866-539-1710.  Use a brush to remove carbon deposits from the spark arrestor screen as needed. DRAINING FU...

19 — English CALIFORNIA PROPOSITION 65 WARNING: This product, its exhaust, and other substances that may become airborne from its use may contain chemicals, including lead, known to the State of California to cause cancer, birth defects, or other reproductive harm. Wash hands after handling. BATTERY...

20 — English MAINTENANCE MAINTENANCE SCHEDULE NOTE: If a separate engine manual is provided for this generator, please follow the maintenance schedule provided in the engine manual instead of the maintenance information listed below. Before each use After 1st month or 20 hours of operation Every 3 m...

21 — English TROUBLESHOOTING PROBLEM POSSIBLE CAUSE SOLUTION Engine will not start. No fuel.Stale gasoline or water in gasoline. Lubricant level is low. Fuel valve is OFF.Spark plug faulty, fouled, or improperly gapped.Choke lever is in RUN position.E n g i n e s t o re d w i t h o u t t re a t i n ...

22 — English WARRANTY Proof of purchase must be presented when requesting warranty service.This product is manufactured by One World Technologies, Inc. The trademark is licensed from RIDGID, Inc. All war-ranty communications should be directed to One World Technologies, Inc., attn: Generator Technic...

23 — English WARRANTY YOUR WARRANTY RIGHTS AND OBLIGATIONS The U.S. EPA, Environment Canada, and One World Technolo-gies, Inc., are pleased to explain the evaporative emission control system’s warranty on your small off-road equipment. New equip-ment that uses small off-road engines must be designed...

24 — English WARRANTY Yamaha Motor Corporation, USA hereby warrants that new Yamaha Spark Ignited Small Off Road Engines, hereafter called SORE engines, purchased from an authorized Yamaha SORE engine dealer in the continental United States will be free from defects in material and workmanship for t...

25 — English WARRANTY YAMAHA MOTOR CORPORATION, USA SMALL OFF ROAD ENGINES CALIFORNIA EMISSION CONTROL WARRANTY YOUR WARRANTY RIGHTS AND OBLIGATIONS The California Air Resources Board and Yamaha Motor Corporation, USA are pleased to explain the emission control system warranty on your 2013 Small Off...