Wells WM-TR II - Manuals

Wells WM-TR II – Manual in PDF format online.

Manuals:

Manual

Manual Wells WM-TR II

Summary

Page 2 - xi

Unless otherwise specified, all commercial cooking equip-ment manufactured by WELLS MFG. CO. is warranted against defects in materials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factory, whichever comes first, and i...

Page 4 - FEATURES & OPERATING CONTROLS; ITEM DESCRIPTION

FEATURES & OPERATING CONTROLS 2 ITEM DESCRIPTION NOTES 1 HEATER SWITCH Controls power to water heater, satellite heater and satellite fill 2 POWER LIGHT Indicates main power available 3 REFILL LIGHT Indicates satellite is being refilled from the main tank 4 HEAT LIGHT Indicates heater element is...

Page 5 - Fig. 2 Features & Operating Controls - Water Max IITM 5 Gallon Satellite

FEATURES & OPERATING CONTROLS (continued) Fig. 2 Features & Operating Controls - Water Max II™ 5 Gallon Satellite 3 ITEM DESCRIPTION NOTES S1 COVER Forms fill funnel, allows access to tank for service S2 COVER HOLDING CLIPS Retains cover in place S3 WATER LEVEL SENSOR Maintains water level i...

Page 6 - must be read and; PRECAUTIONS AND GENERAL INFORMATION

WARNING: Electric Shock hazard All servicing requiring access to non-insulated electrical components must be performed by a factory authorized technician. DO NOT open any access panel which requires the use of tools. Failure to follow this warning can result in severe electrical shock. CAUTION: Risk...

Page 7 - UNPACKING & INSPECTION; Installation; SETUP; SHIPPING DAMAGE; INSTALLATION

UNPACKING & INSPECTION Carefully remove the appliance from the carton. Remove all protective plastic film, packing materials and accessories from the appliance before connecting electrical power or otherwise performing any installation procedure. Carefully read all instructions in this manual an...

Page 8 - PLUMBING LINE CONNECTION; RISK OF DAMAGE

INSTALLATION (continued) PLUMBING LINE CONNECTION If power has been run to the dispenser, verify that the circuit breaker is turned OFF , and that the POWER SWITCH is in the OFF [O] position. Water-Max II™ must be connected to a potable water supply. Connect to a cold water line only. Connecting to ...

Page 9 - ELECTRICAL INSTALLATION; A DEDICATED CIRCUIT OF AT LEAST 40 AMPS IS REQUIRED.; SHOCK HAZARD; qualified technician only

INSTALLATION (continued) ELECTRICAL INSTALLATION NOTICE: A DEDICATED CIRCUIT OF AT LEAST 40 AMPS IS REQUIRED. WIRING AND CONNECTIONS MUST BE INSTALLED AND MAINTAINED IN COMPLIANCE WITH FEDERAL, STATE, AND LOCAL ORDINANCES. The dispenser is factory configured for either 208 volts or 240 volts. The vo...

Page 10 - INSTALLATION START-UP AND CHECKOUT; CAUTION; is

INSTALLATION START-UP AND CHECKOUT Before turning on power or water to Water-Max II™, verify: a. Unit is level, with all legs touching the counter b. Water and electrical connections properly made c. HEATER SWITCH is OFF ( O ) d. Removable SATELLITE is NOT installed on Water-Max II™ at this time Onl...

Page 11 - OPERATION; INSTALLING OR REMOVING SATELLITE TANK; and hot water will begin filling the satellite after 15 - 20 seconds.; To Keep Water in Satellite Hot; BURN HAZARD; hold or place; NEVER; NEVER; attempt to operate

OPERATION Water-Max II™ is used to dispense hot water for food preparation. The SATELLITE TANK stores five gallons of hot water for immediate use. INSTALLING OR REMOVING SATELLITE TANK Drain all water from SATELLITE before attempting to remove from unit. Press the HEATER SWITCH to OFF ( O ) Be sure ...

Page 12 - CLEANING INSTRUCTIONS; DAILY CLEANING

CLEANING INSTRUCTIONS DAILY CLEANING PRECAUTIONS: Press HEATER SWITCH to OFF ( O ). Drain all water from SATELLITE. Remove satellite from Water-Max II™. FREQUENCY: Minimum - Daily, or as required TOOLS: Soft Cloth, Soft Bristle Brush Wipe down the exterior of the Water-MaxII™ with a soft damp cloth....

Page 13 - PERIODIC CLEANING - Delime Internal Heating Tank; Press TANK HEATER SWITCH to; FIRST AID

PERIODIC CLEANING - Delime Internal Heating Tank PRECAUTIONS: Water in main tank is EXTREMELY HOT (around 200ºF) FREQUENCY: Weekly TOOLS: Wells Deliming Solution Bottle (p/n 85377) Plastic Scouring Pad Clean Cloth or Sponge Kay Orange Neutralizer and Delimer (Kay p/n 55905) Begin with the HEATER SWI...

Page 14 - CLEANING INSTRUCTIONS (continued

CONTINUED FROM PAGE 11 After 30 minutes, flush solution from main tank (HEATER SWITCH OFF ): Insert drain hose into a suitable container. Open drain hose clamp and drain valve. Allow all solution to drain. Close drain valve. Reconnect main water supply and allow main tank to fill (approximately 4 mi...

Page 15 - PERIODIC CLEANING - Satellite Tank; Water in satellite is EXTREMELY HOT

PERIODIC CLEANING - Satellite Tank PRECAUTIONS: Water in satellite is EXTREMELY HOT (around 200ºF) Satellite full of water is HEAVY (62 lbs.) Drain water from SATELLITE before moving. FREQUENCY: Weekly TOOLS: Plastic Scouring Pad Clean Cloth or Sponge Kay Orange Neutralizer and Delimer (Kay p/n 5590...

Page 16 - TROUBLESHOOTING SUGGESTIONS; SYMPTOM

TROUBLESHOOTING SUGGESTIONS There are no user serviceable components in the appliance. In all cases of damage or component malfunction, contact your Authorized Wells Service Agency for repairs. 14 SYMPTOM POSSIBLE CAUSE SUGGESTED REMEDY Power light not lit Circuit breaker off or tripped Reset circui...

Page 17 - CUSTOMER SERVICE DATA

DESCRIPTION SERVICE PART NO. TANK, 5 GALLON, MODEL DT-5 22658 DELIMING SOLUTION BOTTLE WITH QUICK DISCONNECT FITTING 22800 DELIMING SOLUTION BOTTLE (ONLY) 22801 PITCHER, PLASTIC, 4 QT. 84501 ASSEMBLY (STRAINER / PRESSURE REGULATOR WITH GAUGE / WATER HAMMER ARRESTOR) 84868 PRESSURE REGULATOR (ONLY) 8...