Wells B-44 - Manuals - manualsarea.com

Page 2 - xi

Unless otherwise specified, all commercial cooking equip-ment manufactured by WELLS MFG. CO. is warranted against defects in materials and workmanship for a period of one year from the date of original installation or 18 months from the date of shipment from our factory, whichever comes first, and i...

Page 3 - NOT SUPPLIED

TABLE OF CONTENTS SPECIFICATIONS 1 WARRANTY xi SPECIFICATIONS 1 FEATURES & OPERATING CONTROLS 2 PRECAUTIONS & GENERAL INFORMATION 4 AGENCY LISTING INFORMATION 4 INSTALLATION 5 OPERATION 7 SUGGESTED COOKING TIMES 9 TROUBLESHOOTING SUGGESTIONS 10 MAINTENANCE INSTRUCTIONS 11 PARTS & SERVICE...

Page 4 - FEATURES & OPERATING CONTROLS; ADJUSTABLE LEGS; Remember to dis-engage the support rod before

FEATURES & OPERATING CONTROLS 2 COMMENT The char-broiler is INFINITE SWITCH CONTROLLED. Power is applied to the heating elements based on the control knob position and the amount of energy used. Light will glow when the infinite switch is in any position other that OFF. The char-broiler element ...

Page 5 - Fig. 1 Countertop Electric Charbroiler

FEATURES & OPERATING CONTROLS (continued) 3 Fig. 1 Countertop Electric Charbroiler

Page 6 - PRECAUTIONS AND GENERAL INFORMATION; Installation Instructions.; AGENCY LISTING INFORMATION

PRECAUTIONS AND GENERAL INFORMATION 4 Broilers are intended for use to cook food products for human consumption. No other use is recommended or authorized by the manufacturer or its agents. Broilers are intended for use in commercial establishments, where all users are familiar with the appliance li...

Page 7 - INSTALLATION; DO NOT discard; SETUP; for required clearances.

INSTALLATION NOTE: DO NOT discard the carton or other packing materials until you have inspected the appliance for hidden damage and tested it for proper operation. Refer to SHIPPING DAMAGE CLAIM PROCEDURE on the inside front cover of this manual. 5 UNPACKING & INSPECTION Carefully remove the ap...

Page 9 - OPERATION; PREPARE THE CHAR-BROILER FOR USE; DOWN

OPERATION 7 PREPARE THE CHAR-BROILER FOR USE When using the broiler for the first time, wipe the entire unit with a clean damp cloth or sponge and mild detergent. Rinse thoroughly clean water. Dry with a soft clean cloth. Remove the GRATE and raise the ELEMENT ASSEMBLY. Install the DRIP PAN and add ...

Page 10 - TEMPERATURE CONTROLS; OFF; USING THE CHAR-BROILER; Fig. 6 TEMPERATURE CONTROL

OPERATION (continued) CAUTION: Hot Surface Exposed surfaces can be hot to the touch and may cause burns. IMPORTANT: DO NOT POUR WATER OVER ELEMENTS TO REFILL PAN. DO NOT splash or pour water onto controls, control panels or wiring. 8 TEMPERATURE CONTROLS Each section of the broiler is equipped with ...

Page 12 - TROUBLESHOOTING SUGGESTIONS; SYMPTON; Verify proper voltage

TROUBLESHOOTING SUGGESTIONS 10 SYMPTON POSSIBLE CAUSE SUGGESTED REMEDY Won’t heat- - no indicator lights Not plugged in, or Circuit breaker tripped. Check plug Check / reset circuit breaker One or more section won’t heat—or not hot enough Temperature control not set Set temperature control knob to d...

Page 13 - CLEANING INSTRUCTIONS; PREPARATION; DO NOT spill; not; covered by

CLEANING INSTRUCTIONS PREPARATION Turn both temperature control knobs OFF. Allow broiler to cool completely. Disconnect broiler from electric power. FREQUENCY Daily. TOOLS Steel Brush with scraper Plastic Scouring pad, Soft-Bristled Fiber Brush Mild Detergent, Non-Abrasive Cleanser Clean Soft Cloth ...

Page 14 - THIS PAGE BLANK

Page 15 - Wells Manufacturing Co.; CUSTOMER SERVICE DATA

DESCRIPTION SERVICE PART NO. CORDSET 240V 30A NEMA 6-30P, B-40, B-44 20141 GREASE PAN, B-44 (1 PER UNIT) B-50 (2 PER UNIT) 20174 GREASE PAN, B-40 20202 LEGS, 4”, METAL SET OF 4 20563 GRATE, B-44 (1 PER UNIT) B-50 (2 PER UNIT) 21706 GRATE, B-40 21707 BRUSH, BROILER 21708 IMPORTANT: Use only factory a...