Wells 8785-AL - Manuals

Wells 8785-AL – Manual in PDF format online.

Manuals:

Manual

Manual Wells 8785-AL

Summary

Page 2 - WARRANTY STATEMENT; xi

NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the factory. Upon acceptance of this shipment, the transportation company assumes full responsibility for its safe delivery. IF SHIPMENT ARRIVES DAMAGED: 1....

Page 4 - FEATURES AND OPERATING CONTROLS

FEATURES AND OPERATING CONTROLS Fig. 1 Features & Operating Controls 2 IL1705 NOT AVAILABLE ON MODELS 8782 or 8785 AIROT (BREWING POSITION) HOT WATER FAUCET BREW SWITCH POUR-OVER COVER POUR-OVER OPENING “READY TO BREW” LIGHT 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Own...

Page 5 - PRECAUTIONS AND GENERAL INFORMATION; Installation; AGENCY LISTING INFORMATION

PRECAUTIONS AND GENERAL INFORMATION WARNING: ELECTRIC SHOCK HAZARD All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock. W...

Page 6 - INSTALLATION INSTRUCTIONS; READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION; REFER TO EXPLODED VIEWS PAGES 18 thru 21 FOR; LEVELING THE UNIT; EQUIPMENT DAMAGE

INSTALLATION INSTRUCTIONS READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION REFER TO EXPLODED VIEWS PAGES 18 thru 21 FOR COMPONENT NAMES/NUMBERS Unpack the unit. Inspect all components for completeness and condition. Ensure that all packing materials have been removed from the unit. Verify that t...

Page 7 - SHOCK HAZARD; water hammer arrester; See figure 3 at right.

INSTALLATION INSTRUCTIONS (continued) NOTE: This equipment must be installed in compliance with all applicable federal, state and local plumbing codes and ordinances. WARNING: SHOCK HAZARD Brewer must be properly grounded to prevent possible shock hazard. DO NOT assume a plumbing line will provide s...

Page 8 - OPERATION; is

OPERATION Fig. 4 Brewer Operation Diagram START-UP For initial start-up, or if the brewer has not been used for an extended period of time: Be sure spray disk and brew gasket are properly installed in the brew head.For automatic brewers, be sure the water supply is properly connected and the water s...

Page 9 - AUTOMATIC OPERATION; OPEN

OPERATION (continued) WATER HEATER Water temperature is sensed by a thermobulb inserted into the water tank. This temperature signal is fed to the thermostat, which controls line power to the heating element.The setpoint temperature is adjustable at the thermostat.The element is protected from over-...

Page 10 - BREWING COFFEE; BURN HAZARD; C. AUTOMATIC OPERATION; EMPTY

BREWING COFFEE CAUTION: BURN HAZARD Exposed surfaces of the brewer, brew chamber and airpot or server may be HOT to the touch, and can cause serious burns. CAUTION: BURN HAZARD To avoid splashing or overflowing hot liquids, ALWAYS place an empty airpot or server under the brew chamber before startin...

Page 11 - CLEANING INSTRUCTIONS; PROCEDURE: Clean Coffee Brewer

CLEANING INSTRUCTIONS PROCEDURE: Clean Coffee Brewer PRECAUTIONS: Disconnect brewer from electric power. Allow brewer to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush, Bottle Brush 1. Disconnect brewer from electric power. Allow brewer to cool before cleaning...

Page 13 - Fig. 9 Access Panels

SERVICING INSTRUCTIONS ACCESS PANELS TOP PANEL: Remove top panel to access hot water tank, thermostat, heating elements, brew circuit tubing, faucet valve and piping.Top panel is held by two screws at the rear and a retaining lip at the front. FRONT PANEL: Remove front panel to access timer, termina...

Page 14 - TEMPERATURE ADJUSTMENT; Fig. 10 Checking and Adjusting Brew Temperature; Table 1 Boiling Temperature by Altitude

SERVICING INSTRUCTIONS (continued) TEMPERATURE ADJUSTMENT Unplug power cord or turn circuit breaker OFF. Remove top panel.Pull vent tube out of tank lid and insert a thermometer of known accuracy in vent hole. Reconnect brewer to electrical power. Place an empty decanter under brew chamber. Energize...

Page 15 - REPLACE THERMOSTAT; OFF

SERVICING INSTRUCTIONS (continued) 13 IMPORTANT: Water pressure must be between 20 p.s.i and 90 p.s.i. flowing pressure. If water pressure exceeds this value, or if water pressure varies greatly, a pressure regulator must be installed in the water supply line. IMPORTANT: Before setting assembly into...

Page 18 - DO NOT; PROCEDURE: Delime the Water Tank

CAUTION: CHEMICAL BURN HAZARD Deliming chemicals may be caustic. Wear appropriate protective gloves and goggles during this procedure. Never siphon deliming chemicals or solutions by mouth. This operation should only be performed by qualified and experienced service personnel. IMPORTANT: DO NOT spil...

Page 19 - EXPLODED VIEW & PARTS LIST

18 EXPLODED VIEW & PARTS LIST ASSEMBLY,HOT WATER TANK IL1708 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal ITEM PART NO. DESCRIPTION USED ON 13 2C-70134 HOLD-DOWN STRAP ALL 14 2C-73457 NUT, HEX 8-32 KEPS ALL 50 WS-8512-51 THERMOSTAT...

Page 20 - CABINET PLUMBING COMPONENTS

EXPLODED VIEW & PARTS LIST (continued) 19 CABINET PLUMBING COMPONENTS IL1709 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal ITEM PART NO. DESCRIPTION USED ON 8 2V-70104 FORMED TUBE, FAUCET OUTLET ASSEMBLY 10-7/8” LONG 8780, 8782, 878...

Page 21 - ELECTRICAL COMPONENTS

ELECTRICAL COMPONENTS EXPLODED VIEW & PARTS LIST (continued) 20 IL1710 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal IL1612 ITEM PART NO. DESCRIPTION USED ON 31 2E-70733 SWITCH, MOMENTARY ROCKER, BREW 8780, 8782, 8786, 8788 32 2J-72...

Page 22 - CABINET COMPONENTS

EXPLODED VIEW & PARTS LIST (continued) CABINET COMPONENTS 21 IL1711 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal

Page 24 - WIRING DIAGRAM

622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal WIRING DIAGRAM (BROWN 230V) BLACK 14 GA WHITE 14 GA (BLUE 230V) 120VAC, POUR-OVER 1800 WATT MODELS” 8778 8783 8785 1500 WATT (Canadian) MODELS: 8778CA 8783CA 8785CA 120VAC, AUTOMATIC 1800 WA...

Page 26 - NOTES

622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal 622 2M-75854 Owners Manual Gourmet 1000 Airpot/Thermal NOTES