Wells 8542-D1 - Manuals

INSTALLATION INSTRUCTIONS READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION REFER TO EXPLODED VIEWS PAGES 18 thru 22 FOR COMPONENT NAMES/NUMBERS Unpack the unit. Inspect all components for completeness and condition. Ensure that all packing materials have been removed from the unit. Verify that t...

INSTALLATION INSTRUCTIONS (continued) NOTE: This equipment must be installed to comply with applicable federal, state and local plumbing codes and ordinances. WARNING: SHOCK HAZARD Brewer must be properly grounded to prevent possible shock hazard. DO NOT assume a plumbing line will provide such a gr...

OPERATION Fig. 4 Brewer Operation Diagram A. START-UP For initial start-up, or if the brewer has not been used for an extended period of time: ♦ Be sure spray disk and brew gasket are properly installed in the brew head. ♦ Be sure the water supply is properly connected and the water supply valve is ...

OPERATION (continued) 7 WATER HEATER Water temperature is sensed by a thermobulb inserted into the water tank. This temperature signal is fed to the thermostat, which controls line power to the heating element. The setpoint temperature is adjustable at the thermostat. The element is protected from o...

BREWING COFFEE CAUTION: BURN HAZARD Exposed surfaces of the brewer, brew chamber and decanter may be HOT to the touch, and can cause serious burns. CAUTION: BURN HAZARD To avoid splashing or over-flowing hot liquids, ALWAYS place an empty decanter under the brew chamber before starting the brew cycl...

CLEANING INSTRUCTIONS PROCEDURE: Clean Coffee Brewer PRECAUTIONS: Disconnect brewer from electric power. Allow brewer to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush. 1. Disconnect brewer from electric power. Allow brewer to cool before cleaning. 2. Remove a...

SERVICING INSTRUCTIONS ACCESS PANELS Each warmer plate has a center stud which screws into a bracket. Warmer plates on Canadian brewers are secured with a nut. Remove button plug on bottom of brewer to access nut on warmer plate. Remove warmer plates by turning counter-clockwise. Solenoid door is he...

SERVICING INSTRUCTIONS (continued) 12 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers TEMPERATURE ADJUSTMENT Unplug power cord or turn circuit breaker OFF. Remove top panel. Pull vent tube out of tank lid and insert a thermometer of known accuracy in vent hole. Reconnect brewer to electrical powe...

SERVICING INSTRUCTIONS (continued) 13 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers IMPORTANT: Water pressure must be between 20 p.s.i and 90 p.s.i. flowing pressure. If water pressure exceeds this value, or if water pressure varies greatly, a pressure regulator must be installed in the water s...

SERVICING INSTRUCTIONS (continued) 14 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers REPLACE HEATING ELEMENT Remove tank lid assembly as described on page 13. Remove two hex nuts holding element to cover. Pull element from mounting holes. Reassemble in reverse order. REPLACE SOLENOID Symptom: Au...

CAUTION: CHEMICAL BURN HAZARD Deliming chemicals are caustic. Wear appropriate protective gloves and goggles during this procedure. Never siphon deliming chemicals or solutions by mouth. This operation should only be performed by qualified and ex-perienced service personnel. IMPORTANT: DO NOT spill,...

Koffee-King™ EXPLODED VIEW & PARTS LIST CABINET & RELATED COMPONENTS 18 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers

Koffee-King™ EXPLODED VIEW & PARTS LIST (continued) HOT WATER TANK ASSEMBLY 20 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers ITEM PART NO. DESCRIPTION USED ON 13 8043-5 HOLD-DOWN STRAP ALL 50 8512-51 86280 THERMOSTAT (BLACK BODY - INCL. SEAL & MOUNTING SCREWS) THERMO (ALT) (GRAY BODY - ...

INTERNAL PLUMBING COMPONENTS Koffee-King™ EXPLODED VIEW & PARTS LIST (continued) 21 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers ITEM PART NO. DESCRIPTION USED ON 8 8540-3 FORMED TUBE, FAUCET OUTLET ASSEMBLY 10-7/8" LONG 8540, 8572, 8574 9 8540-4 FORMED TUBE, FAUCET COIL INLET ASSEMBLY...

Koffee-King™ EXPLODED VIEW & PARTS LIST (continued) ELECTRICAL COMPONENTS 22 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers 45a 45b 45c 45d ITEM PART NO. DESCRIPTION USED ON 2 8572-18 HEATING ELEMENT, WARMER 120V 100W ALL 30 6710-23 SWITCH, WARMER ON/OFF 120V ALL 31 8572-24 8707-55 SWITCH, M...

Koffee-King™ WIRING DIAGRAMS 23 M 611 75804 Owne rs M anual Koffee-K ing™ B rewers

Genuine Parts Protect - YOU - All - Ways SERVICE TRAINING - QUALITY SERVICE SERVICE TRAINING - QUALITY SERVICE CUSTOMER SATISFACTION CUSTOMER SATISFACTION Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association Commercial Food Equipment Service Association PRINTED IN UN...