Wells 1222 1222CA - Manuals

Wells 1222 1222CA – Manual in PDF format online.

Manuals:

Manual

Manual Wells 1222 1222CA

Summary

Page 2 - WARRANTY STATEMENT; xi

712 76580 Owne rs M anual Ho t Wa ter Disp ense r NOTE: For your protection, please note that equipment in this shipment was carefully inspected and packaged by skilled personnel before leaving the factory. Upon acceptance of this shipment, the transportation company assumes full responsibility for ...

Page 3 - Meets Canadian standards; APPLICABILITY; This manual applies to the following Wells Bloomfield products:

MODEL VOLTS 1ø 50/60Hz WATTS AMPS 1ø POWER SUPPLY CORD 1222 120 1800 15.0 NEMA 5-15P 1222CA k 120 1500 12.8 1225 k 208 4000 19.0 1226 k 240 4000 16.5 NEMA 6-30P 1 TABLE OF CONTENTS SPECIFICATIONS Thank You for purchasing this Wells Bloomfield appliance. Proper installation, professional operation an...

Page 4 - FEATURES AND OPERATING CONTROLS

FEATURES AND OPERATING CONTROLS 2 712 76580 Owne rs M anual Ho t Wa ter Disp ense r

Page 5 - PRECAUTIONS AND GENERAL INFORMATION; Failure to heed this warning can result in electrical shock.; AGENCY LISTING INFORMATION

PRECAUTIONS AND GENERAL INFORMATION 3 WARNING: ELECTRIC SHOCK HAZARD All servicing requiring access to non-insulated components must be performed by qualified service personnel. Do not open any access panels which require the use of tools. Failure to heed this warning can result in electrical shock....

Page 6 - INSTALLATION; READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION; PLUMBER’S INSTALLATION INSTRUCTIONS; line. Flush water line before connecting to appliance.; EQUIPMENT DAMAGE; Water supply inlet line

INSTALLATION 4 READ THIS CAREFULLY BEFORE STARTING THE INSTALLATION REFER TO EXPLODED VIEWS PAGE 14 FOR COMPONENT NAMES/NUMBERS. Unpack the unit. Inspect all components for completeness and condition. Ensure that all packing materials have been removed from the unit. LEVELING THE UNIT Two Gallon Dis...

Page 7 - SHOCK HAZARD; water hammer arrester; ELECTRICIAN’S INSTALLATION INSTRUCTIONS; Fig. 2 Water Supply Installation

INSTALLATION (continued) 5 NOTE: This equipment must be installed to comply with applicable federal, state and local plumbing codes and ordinances. CAUTION: SHOCK HAZARD Dispenser must be properly grounded to prevent possible shock hazard. DO NOT assume a plumbing line will provide such a ground. El...

Page 8 - OPERATION; Fig. 3 Dispenser Operation Diagram; WATER HEATER

OPERATION 6 Fig. 3 Dispenser Operation Diagram A. START-UP For initial start-up, or if the dispenser has not been used for an extended period of time: • Be sure the water supply is properly connected and the water supply valve is turned ON . • Be sure the WATER TANK IS FILLED. IMPORTANT: Fill the wa...

Page 9 - BURN HAZARD

CLEANING INSTRUCTIONS PROCEDURE: Clean Hot Water Dispenser PRECAUTIONS: Disconnect dispenser from electric power. Allow dispenser to cool. FREQUENCY: Daily TOOLS: Mild Detergent, Clean Soft Cloth or Sponge Bristle Brush 1. Disconnect dispenser from electric power. Allow to cool before cleaning. 2. W...

Page 10 - TROUBLESHOOTING SUGGESTIONS; SUGGESTED REMEDY

TROUBLESHOOTING SUGGESTIONS SUGGESTED REMEDY Check power supply cord Check / reset circuit breaker Press switch to "ON" Adjust thermostat for desired temperature Allow to cool hi-limit will self-reset Examine wiring & connectors, controller, power board and heating element Repair/replace...

Page 11 - SERVICING INSTRUCTIONS

SERVICING INSTRUCTIONS CAUTION: SHOCK HAZARD Opening access panels on this dispenser may expose uninsulated electrical components. Disconnect dispenser from electrical power before removing any panel. ACCESS PANELS REAR PANEL: Remove rear panel to access hot water tank, thermostat, heating elements,...

Page 12 - TEMPERATURE ADJUSTMENT; OFF; REPLACE THERMOSTAT

SERVICING INSTRUCTIONS (continued) TEMPERATURE ADJUSTMENT Check temperature at discharge of faucet. Remove thermostat access button plug to access thermostat. Turn thermostat shaft clockwise to increase temperature. REMOVE TANK LID ASSEMBLY Unplug dispenser or turn circuit breaker OFF . Turn OFF wat...

Page 13 - REPAIR HOT WATER FAUCET

SERVICING INSTRUCTIONS (continued) IMPORTANT: When replacing heating element, also replace seal gaskets. NOTE: Any abrasion or roughness on the flat end of the seat cup will require replacing the seat cup: REPLACE HEATING ELEMENT Remove tank lid assembly as detailed on page 10. Remove two hex nuts h...

Page 14 - PROCEDURE: Delime the Water Tank

CAUTION: CHEMICAL BURN HAZARD Deliming chemicals may be caustic. Wear appropriate protective gloves and goggles during this procedure. Never siphon deliming chemicals or solutions by mouth. This operation should only be performed by qualified and experienced service personnel. IMPORTANT: DO NOT spil...

Page 15 - EXPLODED VIEWS AND PARTS LISTS; SERVICE KITS; Faucet & Shank Complete

EXPLODED VIEWS AND PARTS LISTS 13 SERVICE KITS FAUCET REPAIR KITS 84686 Faucet & Shank Complete 8700-25 L Seat Cup (only) SOLENOID REPAIR KITS 83612 Solenoid Complete, Single 120V (1222, 1222CA) 83760 Solenoid Complete, Single 240V (1225, 1226) 85218 Inlet Fitting Kit (includes cap, fitting, was...

Page 16 - EXPLODED VIEW & PARTS LIST

EXPLODED VIEW & PARTS LIST 14 NOTE: Model 1225/1226 shown. Model 1222/1222CA is similar. 712 76580 Owne rs M anual Ho t Wa ter Disp ense r 38 39 37 1 34 27 2 REQD 36 28 35 31 29 40 18 26 24 22 21 21 20 2 REQD 19 17 16 15 14 13 12 11 10 9 7 8 6 5 4 3 30 2 23 25

Page 18 - WIRING DIAGRAM

WIRING DIAGRAM 16 2-GALLON MODELS 1222 and 1222CA 712 76580 Owne rs M anual Ho t Wa ter Disp ense r 7 7 9 10 12 13 6 8 3 2 5 4 11 1 BLACK WHITE GREEN WHITE WHITE WHITE GREEN WHITE WHITE WHITE BLACK BLACK BLACK BLACK BLACK BLACK BLACK HOT WATER READY LIGHT (AMBER) POWER LIGHT (GREEN) THERMOSTAT WATER...

Page 20 - Genuine Parts; Wells Bloomfield proudly supports CFESA; WELLS BLOOMFIELD, LLC

Genuine Parts Protect - YOU - All - Ways SERVICE TRAINING - QUALITY SERVICE SERVICE TRAINING - QUALITY SERVICE CUSTOMER SATISFACTION CUSTOMER SATISFACTION Wells Bloomfield proudly supports CFESA Commercial Food Equipment Service Association Commercial Food Equipment Service Association PRINTED IN UN...