Viper FANG 20-EU - Manuals

Viper FANG 20-EU – Manual in PDF format online.

Manuals:

Manual

Manual Viper FANG 20-EU

Summary

Page 2 - TABLE OF CONTENTS; SCRUBBERS FANG20-EU / FANG20T-EU 1

USER MANUAL ENGLISH TABLE OF CONTENTS INTRODUCTION .............................................................................................................................................................. 2 MANUAL PURPOSE AND CONTENTS ...............................................................

Page 3 - INTRODUCTION; MANUAL PURPOSE AND CONTENTS

2 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)200 9 - 04 A ENGLISH USER MANUAL INTRODUCTION NOTE The numbers in brackets refer to the components shown in Machine Description chapter. MANUAL PURPOSE AND CONTENTS The purpose of this Manual is to provide the operator with all necessary information to use...

Page 4 - OTHER REFERENCE MANUALS; SPARE PARTS AND MAINTENANCE; SCRUBBERS FANG20-EU / FANG20T-EU 3

USER MANUAL ENGLISH OTHER REFERENCE MANUALS The following Manuals are available: – Service Manual (that can be consulted at Viper Service Centers) – Spare Parts List (see www.vipercleaning.eu ) SPARE PARTS AND MAINTENANCE All necessary operating, maintenance and repair procedures must be performed b...

Page 5 - SAFETY; SYMBOLS

ENGLISH USER MANUAL SAFETY The following symbols indicate potentially dangerous situations. Always read this information carefully and take all necessary precautions to safeguard people and property. The operator's cooperation is essential in order to prevent injury. No accident prevention program i...

Page 7 - MACHINE DESCRIPTION; Name; MACHINE STRUCTURE; Squeegee vacuum hose

6 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)2009-04A ENGLISH USER MANUAL MACHINE DESCRIPTION 1. Vacuum ON/OFF switch2. Brush ON/OFF switch3. Battery level light4. Solution ON/OFF switch5. Solution control knob6. Recovery tank drain hose7. Squeegee assembly8. Brush lift foot pedal9. Solution tank lev...

Page 9 - TECHNICAL DATA; EU

8 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)2009-04A ENGLISH USER MANUAL ENGLISH ACCESSORIES/OPTIONS In addition to the standard components, the machine can be equipped with the following accessories/options, according to the machine speci ﬁ c use: Neoprene squeegee blades For further information co...

Page 10 - ENGLISH; WIRING DIAGRAM (FANG20; Colour codes

ENGLISH WIRING DIAGRAM (FANG20 -EU ) Colour codes BLK Black BLU Blue GRN GreenRED Red WHT White 82089E(1)2009-04A SCRUBBERS FANG20-EU / FANG20T-EU 9 USER MANUAL ENGLISH

Page 12 - USE; BATTERY INSTALLATION; BATTERY CHARGER SETTING; SCRUBBERSFANG20-EU / FANG20T-EU 11

USER MANUAL ENGLISH USE WARNING! On some points of the machine there are some adhesive plates indicating: – DANGER – WARNING – CAUTION – CONSULTATION While reading this Manual, the operator must pay careful attention to the symbols shown on the plates. Do not cover these plates for any reason and im...

Page 13 - BEFORE MACHINE START-UP; INSTALLING PAD DRIVER OR BRUSH; MOUNTING THE SQUEEGEE

12 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)2009-04A ENGLISH USER MANUAL BEFORE MACHINE START-UP PRE-OPERATION CHECKS Sweep or dust mop the surface to be cleaned. Check battery meter to make sure batteries are fully charged. (see BATTERY CHARGING) Check that squeegee is properly installed. Check th...

Page 14 - MACHINE; SCRUBBERS FANG20-EU / FANG20T-EU 13

USER MANUAL ENGLISH MACHINE START AND STOP 1. Set control housing to a comfortable operating height by squeezing together the two thumb levers directly underneath the housing. (see machine components, item #10) 2. Lower squeegee assembly to the floor by releasing the lift lever from its locked posit...

Page 16 - WHILE; SCRUBBERS FANG20-EU / FANG20T-EU 15

USER MANUAL ENGLISH WHILE OPERATING MACHINE 1. Occasionally look through the clear recovery tank lid to see if there is any foam build-up. If excessive foam is found, add defoamer to the recovery tank. 2. Occasionally view the clear tube at the back left of the machine to check the amount of cleanin...

Page 17 - TANK DRAINING

16 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)2009-04A ENGLISH USER MANUAL TANK DRAINING WARNING! If the recovery tank is not drained when the solution tank has been refilled, foam or water may enter the float shut-off mechanism and cause damage to the vacuum motor. Remove the drain hose from the hol...

Page 18 - BATTERY; SCRUBBERS FANG20-EU / FANG20T-EU 17

USER MANUAL ENGLISH BATTERY CHARGING NOTE For the best machine performance, keep batteries charged at all times. Do not let them sit in a discharged condition. CAUTION! Use only approved chargers with the following specifications: z Automatic shut off circuit z Deep cycle charging z Output current o...

Page 19 - DAILY MAINTENANCE; MAINTENANCE; WEEKLY MAINTENANCE

18 SCRUBBERS FANG20-EU / FANG20T-EU 82089E(1)2009-04A ENGLISH USER MANUAL DAILY MAINTENANCE Remove pad driver / brush and clean with approved cleaner. Drain recovery and solution tanks completely and rinse out with clean water. Visually check the recovery tank for debris and cl- ean out as necessary...

Page 20 - SQUEEGEE BLADE CHECK AND REPLACEMENT

USER MANUAL ENGLISH SQUEEGEE BLADE CHECK AND REPLACEMENT Clean the squeegee (Fig. 5) as shown in the previous paragraph. Check that the edge (E, Fig. 5) of the front blade (C) and the edge (F) of the rear blade (D) lay down on the same level, along their length; otherwise adjust their height accordi...

Page 21 - BASIC TROUBLESHOOTING; -EU

N O I T U L O S E S U A C M E L B O R P s e ir e tt a b e c a l p e R r e w o p o N Batteries need to be charged Charge batteries (see Battery Charging) ) s ( e l b a c e s o o l n e t h g i T e l b a c y r e tt a b e s o o L Batteries not connected properly Follow battery installation instructions ...

Page 22 - SCRAPPING; a) Batteries (WET or GEL) already installed and ready to be used; SCRUBBERS FANG20-EU / FANG20T-EU 21

ENGLISH USER MANUAL SCRAPPING Have the machine scrapped by a qualified scrapper. Before scrapping the machine, remove and separate the following materials, which must be disposed of properly according to the Law in force: – Batteries – Brushes/pads – Plastic hoses and components – Electrical and ele...