Vermont Casting UE181N - Manuals

Page 2 - ATTENTION

2 3311243 ATTENTION This unvented gas log heater has been certified by CSA and tested to conform to ANSI Z21.11.2 GasFired Room Heaters. Check local codes before installing this log heater. In some areas of the country,unvented gas log heaters are restricted. The installation and provision for combu...

Page 3 - CARBON MONOXIDE POISONING MAY LEAD TO DEATH; operation, and to prevent overheating of the gas valve.

3 3311243 CARBON MONOXIDE POISONING MAY LEAD TO DEATH When used without fresh air, vent free gas logs may give off carbon monoxide, an odorless, poisonousgas. Some people such as pregnant women, people with heart or lung disease and persons at highaltitudes are more affected by carbon monoxide than ...

Page 4 - Provisions for Adequate Combustion and Ventilation Air; per kw) of the aggregate input; WARNING

4 3311243 Provisions for Adequate Combustion and Ventilation Air This heater shall not be installed in a “ CONFINED SPACE” or unusually tight construction unless provi-sions are provided for adequate combustion and ventilation air. The NATIONAL FUEL GAS CODE, ANSI Z223.1/NFPA 54 defines a “CONFINED ...

Page 5 - Fireplace Spacing Requirements; Installation Guidelines; Natural

5 3311243 Fireplace Spacing Requirements The illustration in Figure 2 shows spacing requirementsfor your room with a hood installed (not included). Without a hood, you must maintain a minimum of 32”between the top opening of the firebox and the bottomof a mantel which protrudes out 12”. If you do no...

Page 6 - Unpacking; Remove logs and heater base assembly from; Gas Plumbed on Left Side of Fireplace; Measure the fireplace opening and adjust the hood

6 3311243 ATTENTION: This heater is clean burning. It requiresno outside venting. There is no heat loss out a vent orup a chimney. Heat is generated by realistic flames.This heater is designed for vent-free operation with fluedamper closed. State and local codes in some areasprohibit the use of vent...

Page 7 - Hood Installation for

7 3311243 • If the fireplace has glass doors, remove the glassdoors and frame assembly or the upper doortrack. • If the upper door track has been removed, followthe instructions for Figure 3. If the upper doortrack remains, skip Figure 3 and follow theinstructions for Figure 4. 2. If the upper door ...

Page 8 - FOR YOUR SAFETY - READ BEFORE LIGHTING

8 3311243 Connection to Gas Supply 1. Place the burner assembly (grate and control package) in the fireplace. Center the assembly frontto back and side to side. 2. Install the gas supply fitting to the gas supply pipe. Use pipe thread sealing compound, or Teflon tape,on the iron pipe threads only. D...

Page 9 - Match Lighting

9 3311243 Guidelines After your installer does the test burn, the log setshould be operated either with the chimney open or, inthe absence of a chimney, with a window open approxi-mately 1-2 inches. This operation should last for about2-3 hours to cure the logs and dissipate any residualfumes from t...

Page 11 - Oxygen Depletion System; Maintenance

11 3311243 Oxygen Depletion System For your safety, this appliance is equipped with anoxygen depletion system. This system senses theoxygen in the firebox and switches off the gas supplybefore the amount of oxygen falls below safe levels.(Fig. 12) Pilot ODS Sensor Flame Thermocouple Piezo Ignitor FP...

Page 12 - Description

12 3311243 UC/UE181, UC/UE241 Series Unvented Gas Log Heaters Ref. Description UC/UE181 UC/UE241 1a. Log Assembly - 2 Larger Bottom Logs 4312759 4312760 1b. Log Åssembly - 3 Smaller Top Logs 4312761 4312762 2. Bag of Lava Rock (2 lbs.) (2 per Heater) 20000198 20000198 3. Flexline Gas Connector 33041...

Page 13 - Warranty; Lifetime Limited Warranty on logs in original fireplace only:

13 3311243 Failure to follow all instructions in this owner’s manualwill also void this warranty. CFM Home Products will not be liable for incidental orconsequential damages. Some states do not allow the exclusion or limitation ofincidental or consequential damages, so the aboveexclusion or limitati...

Page 14 - CFM Home Products

2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3 800-668-5323 CFM Home Products