Vermont Casting SC42 - Manuals

5 Majestic Fireplaces ® SR/SC Series Chase Installation Insulation methods shown are optionalfor cold climate, not a requirement forunit operation. FP554 Fig. 5 Fireplace and chase parts identification. ;; ;; ; ; ; ; ; ; ; ; TERMINATION CAP STORM COLLAR PAN FLASHING DRAFTSTOP FIRESTOP STANDOFF NAILI...

6 Majestic Fireplaces ® SR/SC Series Chimney Requirements - Offset Installations 0 0 0 0 0 3" 11" 1 0 0 0 0 8 ¹⁄₄ " 20" 0 1 0 0 0 11 ¹⁄₄ " 25 ¹⁄₄ " 2 0 0 0 0 13 ¹⁄₂ " 29 ¹⁄₄ " 1 1 0 0 0 16 ¹⁄₂ " 34 ¹⁄₄ " 0 0 1 0 0 20 ¹⁄₄ " 40 ³⁄₄ " 2 1 0 0 0 21 ³⁄₄ ...

7 Majestic Fireplaces ® SR/SC Series Planning Information Preplanning an installation is very important to ensuresafety and to save time and money. An installer mustpredetermine where a fireplace will be set and how thechimney system will be run. Mounting The Fireplace A fireplace may only be mounte...

8 Majestic Fireplaces ® SR/SC Series ■ 1. Insulating Fireplace Enclosure For Cold Climates If you live in a cold climate, it is not required buthighly recommended that you insulate fire-place enclosure to eliminate cold air penetrationas much as possible. Insulate base of fireplace with a non-combus...

9 Majestic Fireplaces ® SR/SC Series ■ 2. Framing Framing can be constructed before or after the fire-place is set in place, however, most installers build theframe before setting the fireplace. Frame fireplace with 2 X 4 lumber or heavier materials.Refer to framing dimensions in Figures 1, 2, 3 or ...

11 Majestic Fireplaces ® SR/SC Series Note: Safety strips are not required over non-combus-tible floors where all supports at the base of thefireplace are non-combustible. Four (4) nailing flanges are supplied with the fireplace(found on the fireplace hearth). To level the box andsecure it firmly in...

12 Majestic Fireplaces ® SR/SC Series Continue installing the pipe as required until pipe isinstalled up through the ceiling. At this point, you mustinstall a firestop spacer. Installing the Firestop Spacer in the Ceiling Hole A firestop spacer is used to keep pipe spaced properlyand required for sa...

14 Majestic Fireplaces ® SR/SC Series ■ 7. Installing Top Housing Or Termination Follow the installation instructions provided with theVermont Castings, Majestic Products chimney termina-tion you have selected. Installing Chimney In a Chase Refer to Figure 5, Page 5 for an illustration of a typicalc...

15 Majestic Fireplaces ® SR/SC Series Side Wall Protection Adjacent combustible side walls that are within theminimum dimensions shown in Figure 23 of fireplaceopening must be protected with Vermont Castings,Majestic Products Wall Shield Model SP40 or aspecifically built wall shield described below....

16 Majestic Fireplaces ® SR/SC Series ■ 9. Hearth Installation A hearth extension is required to protect a combustiblefloor in front of the fireplace. Refer to Figure 23 forminimum dimensions and mounting detail. Note: Hearth Extension must not cover the airinlet opening of a fireplace. The hearth e...

17 Majestic Fireplaces ® SR/SC Series COMMON MATERIALS AND FACTORS MATERIAL K* R MINIMUM THICKNESS EH2416 Common Brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** (Majestic Products Company) R Value is for ¹⁄₂ inch. * Units of K = BTU/SQ FT/HR/˚F/IN** Thickness of Listed Material FP533ADD Example of D...

18 Majestic Fireplaces ® SR/SC Series ■ 10. Installing Line For Gas Logs Vermont Castings, Majestic Products fireplaces aredesigned to accept a 1/2 inch gas line for installation ofan approved gas appliance. (Vermont Castings,Majestic Products manufactures a wide variety of gaslogs for use in Vermon...

20 Majestic Fireplaces ® SR/SC Series The following accessories for this appliance are available from your local Vermont Castings, Majestic Productsdistributor. Should you need additional information beyond what your distributor can furnish, contact: VermontCastings, Majestic Products, 410 Admiral B...

21 Majestic Fireplaces ® SR/SC Series Chimney Components Round Top Termination Top used to terminate chimney at roof. RLTSK8 (Flashing not included.) Round Top Termination - Top used to terminate chimney at chase. RLTSK8L Extended (Flashing not included.) Flashing Metal finishing required around Con...

22 Majestic Fireplaces ® SR/SC Series Chimney Collar Enclosure Installs on the "over the chimney collar" of the CCE-SK fireplace; provides outside air to assist in coolingthe chimney system. Attic Insulation Shield Used to prevent insulation from coming in AIS-SK contact with the chimney sys...

23 Majestic Fireplaces ® SR/SC Series ™ LIMITED WARRANTY & 30 YEAR PROTECTION PLAN For MAJESTIC FIREPLACES ® PRE-ENGINEERED Fireplace Systems Vermont Castings, Majestic Products warrants its MAJESTIC FIREPLACES® Pre-Engineered Fireplace (“Fireplace”) and VermontCastings, Majestic Products suppli...

24 Majestic Fireplaces ® SR/SC Series © Vermont Castings, Majestic Products 410 Admiral Blvd. • Mississauga, Ontario, Canada L5T 2N6 • 905-670-7777 www.majesticproducts.com • www.vermontcastings.com Vermont Castings, Majestic Products