Vermont Casting CVR36 - Manuals

Vermont Casting CVR36 – Manual in PDF format online.

Manuals:

Manual

Manual Vermont Casting CVR36

Summary

Page 2 - STR/CVR Series Woodburning Fireplaces; Safety Information; Description; disclaims any responsibility for the following; Drafts; framing the fireplace. The gas line must; Listed; Table of Contents

2 STR/CVR Series Woodburning Fireplaces 7412961 Safety Information PLEASE READ THIS MANUAL BEFORE INSTALLING AND USING FIREPLACE.IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible ﬁre hazard and will voi...

Page 3 - STR Series Woodburning Fireplace; CVR Series Woodburning Fireplace

3 STR/CVR Series Woodburning Fireplaces 7412961 STR Series Woodburning Fireplace Fig. 1 STR Series speciﬁcations and framing. 12" 9 �� " A D E 36" 21" 37" 7 �� " 7 �� " Gas Line Access FP702A STR SPECS 9/24/98 added note 9/21/99 Outside Air 14 �� " 12" C 12...

Page 4 - STR/CVR Series Woodburning Fireplace; STR Fireplace; hearth dimensions; Side Width

4 STR/CVR Series Woodburning Fireplaces 7412961 FP701 STR/CVR Series Woodburning Fireplace Fig. 3 STR/CVR Parts Identiﬁcation. FP701 STR/CVR Parts ID 5/18/98 STR Fireplace CVR Fireplace Gas Line Access Outer Dome Outside Air Access Ledge Brackets Header Standoffs Flue Damper Control (Inside) Flue Da...

Page 5 - Chase Installation

5 STR/CVR Series Woodburning Fireplaces 7412961 Chase Installation Insulation methods shown are optional for cold climate, not a requirement for unit operation. FP704 Fig. 4 Fireplace and chase parts identiﬁcation. FP704 STR (from FP528) 7/28/98 Termination Cap Storm Collar Pan Flashing Draftstop Fi...

Page 6 - Chimney Requirements - Offset Installations; 0 ̊ Elbow Offsets; Illustration Key; total; MBUF; OFFSET; RISE

6 STR/CVR Series Woodburning Fireplaces 7412961 Chimney Requirements - Offset Installations 0 0 0 0 0 3" 11" 1 0 0 0 0 8 ¹⁄₄ " 20" 0 1 0 0 0 11 ¹⁄₄ " 25 ¹⁄₄ " 2 0 0 0 0 13 ¹⁄₂ " 29 ¹⁄₄ " 1 1 0 0 0 16 ¹⁄₂ " 34 ¹⁄₄ " 0 0 1 0 0 20 ¹⁄₄ " 40 ³⁄₄ " 2 1 0 0 0...

Page 7 - Planning Information; Mounting the Fireplace; must; Planning the Chimney Run; Never; The Ten Foot Rule

7 STR/CVR Series Woodburning Fireplaces 7412961 Planning Information Preplanning an installation is very important to ensure safety and to save time and money. An installer must predetermine where a ﬁreplace will be set and how the chimney system will be run. NOTE: STR33/36 and CVR36 models use CFM ...

Page 8 - Insulating Fireplace Enclosure for Cold; If you live in a cold climate, it is not required but; highly recommended; that you insulate fireplace; very important; for outside wall installations over; before; WHEN INSTALLING A FIREPLACE; Installation; Chimney Supports; must not; Support provided by elbow

8 STR/CVR Series Woodburning Fireplaces 7412961 Insulating Fireplace Enclosure for Cold Climates If you live in a cold climate, it is not required but highly recommended that you insulate ﬁreplace enclosure to eliminate cold air penetration as much as possible.Insulate base of ﬁreplace with a non-co...

Page 9 - Framing; Framing should be positioned to accommodate; Maintain; REPORT TO YOUR DEALERS ANY; Straight-Up Chimney Installation; Elbow

9 STR/CVR Series Woodburning Fireplaces 7412961 Framing Framing can be constructed before or after the ﬁreplace is set in place, however, most installers build the frame before setting the ﬁreplace.Frame ﬁreplace with 2 x 4 lumber or heavier materi-als. Refer to framing dimensions in Figures 1, 2, 3...

Page 10 - Ceiling Chimney Hole/; inside dimension; of the frame; must be; the same; MODEL; Angle of Chimney at Ceiling

10 STR/CVR Series Woodburning Fireplaces 7412961 Ceiling Chimney Hole/ Possible Obstructions The size of the hole in ceiling will vary with the angle at which the chimney passes through ceiling. Drive a nail up through ceiling at marked chimney cen-ter point. Go to ﬂoor above and see where hole will...

Page 11 - Securing the Fireplace; Safety strips are not required over non-com-; Outside Air Kit; MUST; be installed; BEFORE; the fireplace; Model STR

11 STR/CVR Series Woodburning Fireplaces 7412961 Positioning, Safety Strips, Securing the Fireplace Slide ﬁreplace into position.Lift the ﬁreplace front slightly and slide the metal safety strips under front bottom edge about 1 ¹⁄₂ " (38mm), al- lowing the remainder to extend in front of ﬁrebox....

Page 12 - Installing the Chimney System; Make sure the; Installing the Firestop Spacer; A firestop spacer; Proper Firestop Spacer Installation; is; is not; Elbow Strap

12 STR/CVR Series Woodburning Fireplaces 7412961 Installing the Chimney System Start by attaching the ﬁrst chimney section to the collar on top of the ﬁreplace. Install the pipe as pictured in Figure 16. When you get a good lock, you will hear the pipe clearly snap together. Once sections are snap-l...

Page 13 - The air space dimensions in this manual; DO NOT; put any sealant around the area where the; it may cause a fire hazard.; Chimney supports are generally used in long; A chimney support can-; use an approved; Model 11CF chimney is not approved

13 STR/CVR Series Woodburning Fireplaces 7412961 Locate Chimney Centerpoint on Roof Use same procedure detailed in locating centerpoint of the ﬂue system.Drive a nail up through roof at the centerpoint. This will determine center point on outside of the roof. Cut and Frame Roof Hole Size of roof hol...

Page 14 - horizontal; Install Remainder of Chimney Sections; Ten Foot Rule; Installing Top Housing or Termination; Finishing; Do not; Front View; Air Space Clearances

14 STR/CVR Series Woodburning Fireplaces 7412961 WARNING: DO NOT PACK REQUIRED AIR SPACES WITH INSULATION OR OTHER MATERIALS. Mark an outline of the roof hole around the center of the point nail. NOTE: Hole dimensions given in the chim- ney top installation instructions are horizontal dimen- sions; ...

Page 16 - Side Wall Protection; Examples of wall shield insulation:; STR/CVR Side Wall clearances; STR Series; Model

16 STR/CVR Series Woodburning Fireplaces 7412961 Side Wall Protection All joints (top, bottom and sides) where wall or deco-rative facing material meets ﬁreplace surround must be completely sealed with a noncombustible material. (Figs. 20 and 24) The special wall shield design described in Figure 20...

Page 17 - Hearth Installation; or; a piece of; Minimum Wall Clearances

17 STR/CVR Series Woodburning Fireplaces 7412961 WARNING: HEARTH EXTENSION MUST BE IN-STALLED IN ACCORDANCE WITH FIGURES 24 AND 25. Alternate noncombustible materials may be used providing the (total) thermal resistance (Rt value) of the alternate material employed is greater than or equal to R = 1....

Page 18 - To determine the thickness required for any; new; COMMON MATERIALS AND FACTORS; Example for Common Brick; View A

18 STR/CVR Series Woodburning Fireplaces 7412961 Example of Determining Hearth Extension Equivalents To determine the thickness required for any new mate- rial: COMMON MATERIALS AND FACTORS MATERIAL K* R MINIMUM THICKNESS EH2416 Common Brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** ��...

Page 19 - Installing Line for Gas Logs; Local codes may require removal of flue damper; Fireplace Top View; WARNING: DO NOT OPERATE AN; If installing an unvented gas log set, refer to statement below:

19 STR/CVR Series Woodburning Fireplaces 7412961 Installing Line for Gas Logs Majestic Fireplaces are designed to accept a 1/2" (13 mm) gas line for installation of an approved gas ap-pliance. (CFM Corporation manufactures a wide variety of gas logs for use in Majestic ﬁreplaces.) Be sure to hav...

Page 20 - Damper Handle Push Nut

20 STR/CVR Series Woodburning Fireplaces 7412961 5a 1, 2, 3 4a 6 7 a b c d 8 9 10 11 961 CVR parts 5/17/00 djt 5b 4b e 12 13 14 CFM Corporation reserves the right to make changes in design, materials, speciﬁcations, prices and discontinue colors and products at any time, without notice. 961 CVR36/42...

Page 22 - Gl; Accessories; Model Number

22 STR/CVR Series Woodburning Fireplaces 7412961 Gl ass Door Bi-Fold door set Brushed Brass ﬁnish 33GDKBB - STR33 36GDKBB - STR36, CVR36 42GDKBB - STR42, CVR42 Black ﬁnish 33GDKBK - STR33 36GDKBK - STR36 42GDKBK - STR42 Polished Brass ﬁnish 33GDKDP - STR33 36GDKDP - STR36 42GDKDP - STR42 Pewter ﬁnis...

Page 23 - Chimney Components

23 STR/CVR Series Woodburning Fireplaces 7412961 Chimney Components Round Top Termination Round termination to be used with SK8 chimney RLTSK8 system. (Flashing not included.) Round Top Termination Round termination to be used with 11CF chimney RLTCF11 system. (Flashing not included.) Long Round Top...

Page 24 - Firestop; FOR CANADIAN; Canada

24 STR/CVR Series Woodburning Fireplaces 7412961 Firestop Required at each ﬂoor level of chimney SKFS2A — SK8 installation. (Plus attic on multi-story installation.) (8" straight ﬂue) SKFS6A — SK8 (8" 30˚ inclined ﬂue) FS2A (Model 11CF) (straight ﬂue) FS6A (Model 11CF) (30˚ inclined ﬂue) Chi...

Page 27 - LIMITED WARRANTY & 30 YEAR PROTECTION PLAN; For MAJESTIC FIREPLACES

27 STR/CVR Series Woodburning Fireplaces 7412961 LIMITED WARRANTY & 30 YEAR PROTECTION PLAN For MAJESTIC FIREPLACES ® PRE-ENGINEERED Fireplace Systems CFM Corporation warrants its MAJESTIC FIREPLACES® Pre-Engineered Fireplace (“Fireplace”) and the CFM Corpora-tion supplied ﬁregrate, glass doors,...

Page 28 - CFM Corporation

2695 Meadowvale Blvd. • Mississauga, Ontario, Canada L5N 8A3 800-668-5323 • www.cfmcorp.com CFM Corporation

Vermont Casting Manuals

Vermont Casting BFC36 Manual
Vermont Casting NVC43 Manual
Vermont Casting DTV38s2 Manual
Vermont Casting 4040 - 4046 Manual
Vermont Casting VCS4106 Manual
Vermont Casting 1656 Manual
Vermont Casting 2951 Manual
Vermont Casting BR42 Manual
Vermont Casting STR36 Manual
Vermont Casting VCPV18TP - 18 Manual
Vermont Casting 2461 Manual
Vermont Casting 7PDVS Manual
Vermont Casting RFSDV24 Manual
Vermont Casting BREF30, BREF36, BREF42, BREF30NH, BREF36NH, BREF42NH, BREF36R, BREF42R Manual
Vermont Casting DEF33CE Manual
Vermont Casting CDW247001 Manual
Vermont Casting 3225 Manual
Vermont Casting 410 Manual
Vermont Casting ICVCTK02 Manual
Vermont Casting SC42 Manual