US Stove Company 24A - Manuals

Page 4 - Inspect and clean flues and chimney regularly.; This Furnace Must Be Installed By A Qualified Installer.; G E N E R A L R U L E S

Page 4 USSC Rules for the Safe Installation and Operation of YourFurnace... Check local codes, the installation must comply withstrict conformance in regard to clearances. The Furnace must be installed on a noncombustiblefloor. Connect the furnace to tile lined inside masonry chim-ney or approved in...

Page 5 - How Your New Furnace Works; WARNING; H O W

USSC Page 5 How Your New Furnace Works Unlike conventional heating (gas, oil, electric), woodor coal heating requires more user attention. Yourfurnace, with its automatic combustion air blower,alleviates the constant need for adjusting the burn-ing rate common to other units on the market. Thefire, ...

Page 6 - Furnace location

Page 6 USSC Furnace location Before you start! It is very important you check with your dealer, localfire department, or building inspector. They will beable to inform you of any state or local codes per-taining to the location and installation of your fur-nace. The ideal location for your furnace i...

Page 7 - Clearance to Combustible Materials; Clearance to Combustibles

USSC Page 7 I N S T I N S T I N S T I N S T I N S TA L L A L L A L L A L L A L L A A A A A T I O N T I O N T I O N T I O N T I O N Your furnace is designed to be added on to existingduct work and operate either with or without anotherheat source such as a gas furnace. The followingdiagrams illustrat...

Page 12 - For the model 30A, insert; Installing collar to top:

Page 12 USSC 10. Install grate frame (if not already installed): Lay the first grate frame on the side supports and slideto the back of the unit. Then install the secondgrate frame to the front as shown in the pictureabove. The smooth ends of the frames should betogether in the middle. For the model...

Page 15 - OPERATION OF YOUR NEW SOILD; 0 BASIC FUNCTIONS OF ELECTRICAL SYSTEM

USSC Page 15 ---- -- -- -- -- -- 1. 2. 3. 4. Relay...electrical switching device,Rheostat...current (voltage) reducer increases ordecreases draft fan R.P.M.Distribution Capacitor: Reduces amps requiredto activate distribution fan.Transformer: Reduces voltage 110 volts to 24 voltsfor thermostat usage...

Page 16 - ASH REMOVAL; MAINTENANCE; CAUTION

Page 16 USSC 5. 6. 7. 8. 9. 10. Push in bypass damper after fire has progressed. Your furnace is capable of putting out many BTU's,so don't fully load your furnace until you have be-come familiar with the operation of the furnace.Keep in mind, a full load will not always give youthe best results for...

Page 17 - BURNING COAL

USSC Page 17 BURNING COAL Your furnace is capable of burning both Bituminousand Anthracite coal. Anthracite is perhaps the bestcoal fuel because its long even burn time, high heatoutput, and cleanliness make it a good choice forthe home. However, keep in mind it is a much moredifficult fuel to use, ...

Page 19 - Domestic Hot Water Coil

USSC Page 19 Whenever the loading door is opened, it should be cracked slightly (for about ten (10) seconds) to allowoxygen to enter and burn any combustible gases that are present before fully opening. Failure to do thiscould result in sudden ignition of the unburned gases when the door is opened. ...

Page 20 - TROUBLE-SHOOTING, PROBLEM SOLVING FOR YOUR FURNACE; T R O U B L E S H O O T I N G

Page 20 USSC TROUBLE-SHOOTING, PROBLEM SOLVING FOR YOUR FURNACE 1. 2. 3. Problem: Smoke puffs from furnace. Solution: Check chimney draft. Check for blocked chim-ney or flue pipe. Use mirror to check chimneyclearance.Check ash pit - if too full, empty.Make sure furnace room is not too airtight.Make ...

Page 22 - KEY; PA R T S L I S T

Page 22 USSC KEY PART # DESCRIPTION QTY. 1 24490 LEFT CABINET SIDE 1 - 25613 LEFT CABINET SIDE (30A) 2 24489 RIGHT CABINET SIDE 1 - 25614 RIGHT CABINET SIDE (30A) 3 24488 CABINET TOP 1 - 25615 CABINET TOP (30A) 4 69542 ASSY., FEED DOOR 1 5 69559 ASSY., ASH DOOR 1 6 89636 DOOR HANDLE 1 7 83835 1/2” W...

Page 24 - KEEP THIS MANUAL IN A SAFE PLACE FOR FUTURE REFERENCE.

Page 24 USSC HOW TO ORDER REP HOW TO ORDER REP HOW TO ORDER REP HOW TO ORDER REP HOW TO ORDER REPAIR P AIR P AIR P AIR P AIR PARTS ARTS ARTS ARTS ARTS THIS MANUAL WILL HELP YOU OBTAIN EFFICIENT, DEPENDABLE SERVICE FROM YOURFURNACE, AND ENABLE YOU TO ORDER REPAIR PARTS CORRECTLY. KEEP THIS MANUAL IN ...