Troy-Bilt 540- Manuals

5 19. Shut the engine off and wait until the blade comes to a complete stop before removing the grass catcher or unclog-ging the chute. The cutting blade continues to rotate for a few seconds after the engine is shut off. Never place any part of the body in the blade area until you are sure the blad...

7. Your mower is shipped as a mulcher. To convert to side discharge, make sure grass catcher is off of the unit and rear discharge door is closed.a. On the side of the mower, lift the mulching plug. See Figure 3-7. b. Slide two hooks of side discharge chute under hinge pin on mulching plug assembly....

8 4 Operating Your Lawn Mower Now that you have set up your lawn mower for opera-tion, read this section to become acquainted with its controls and features. This knowledge will allow you to use your new equipment to its fullest potential. Blade Control The blade control is attached to the upper han...

9 4 Operating Your Lawn Mower WARNING The operation of any lawn mower can result in foreign objects being thrown into the eyes, which can damage your eyes severely. Always wear safety glasses while operating the mower or while perform- ing any adjustments or repairs on it. Be sure no one other than ...

10 5 Maintaining Your Lawn Mower WARNING Always stop engine, disconnect spark plug, and ground against engine before performing any type of maintenance on your machine. Do not use a pressure washer or garden hose to clean your unit. These may cause damage to electric components, spindles, pulleys, b...

11 5 Maintaining Your Lawn Mower WARNING When removing the cutting blade for sharpening or replacement, protect your hands with a pair of heavy gloves or use a heavy rag to hold the blade. An unbalanced blade will cause excessive vibration when rotat- ing at high speeds. It may cause damage to mower...

12 For repairs beyond the minor adjustments listed here, contact an authorized service dealer. 6 Trouble Shooting Cause Problem Remedy Engine fails to start 1. Blade control disengaged.2. Spark plug wire disconnected.3. Fuel tank empty or stale fuel.4. Engine not choked. 5. Faulty spark plug.6. Bloc...

13 Safety Labels WARNING DO NOT remove safety (or any) labels from mower for any reason. Safety Labels Found On Your Lawn Mower T O N O D , Y R U J N I F O K S I R E H T E C U D E R O T S S E L N U E T A R E P O R O R E V O C E G R A H C S I D A C S S A R G . E C A L P R E P O R P S T I N I S I R E ...

15 8 Parts List Ref. Part No. Description 1 747-1161A Blade Control 2 749-1092A Upper Handle 3 746-1130 Control Cable, 40” 4 726-0240 Cable Tie 5 664-04011 Grass Bag Assembly 6 747-04080 Grass Bag Frame 7 720-0279 Handle Knob 8 731-05642 Trail shield 9 747-04588 Pivot Rod 10 731-05865 Rear Discharge...

The limited warranty set forth below is given by Troy-Bilt LLC with respect to new merchandise purchased and used in the United States, its posses-sions and territories.“Troy-Bilt” warrants this product against defects in material and workman-ship for a period of two (2) years commencing on the date...

7 7. Your mower is shipped as a mulcher. To convert to side discharge, make sure grass catcher is off of the unit and rear discharge door is closed.a. On the side of the mower, lift the mulching plug. See Figure 3-7. b. Slide two hooks of side discharge chute under hinge pin on mulching plug assembl...

8 4 Operating Your Lawn Mower Now that you have set up your lawn mower for opera-tion, read this section to become acquainted with its controls and features. This knowledge will allow you to use your new equipment to its fullest potential. Blade Control The blade control is attached to the upper han...

12 For repairs beyond the minor adjustments listed here, contact an authorized service dealer. 6 Trouble Shooting Cause Problem Remedy Engine fails to start Engine runs erratic 1. Connect and tighten spark plug wire.2. Clean fuel line; fill tank with clean, fresh gasoline. 3. Clear vent.4. Drain fue...

13 7 Safety Labels WARNING DO NOT remove safety (or any) labels from mower for any reason. Safety Labels Found On Your Lawn Mower T O N O D , Y R U J N I F O K S I R E H T E C U D E R O T S S E L N U E T A R E P O R O R E V O C E G R A H C S I D A C S S A R G . E C A L P R E P O R P S T I N I S I R ...

15 8 Parts List Ref. Part No. Description 1 747-1161A Blade Control 2 749-1092A Upper Handle 3 746-1130 Control Cable, 40” 4 726-0240 Cable Tie 5 664-04011 Grass Bag Assembly 6 747-04080 Grass Bag Frame 7 720-0279 Handle Knob 8 731-05642 Trail shield 9 747-04588 Pivot Rod 10 731-05865 Rear Discharge...

MANUFACTURER’S LIMITED WARRANTY FOR GDOC-100020 REV. A The limited warranty set forth below is given by Troy-Bilt LLC with respect to new merchandise purchased and used in the United States and/or its territories and possessions, and by MTD Products Limited with respect to new merchandise purchased ...

Seguridad-Ensamblaje-Operación-Consejos y Técnicas-Mantenimiento-Solución de problemas-Lista de Partes-Garantías Advertencia: Esta unidad está equipada con un motor de combustión interno y no debe ser utilizada en o cerca de un terreno agreste cubierto por bosque, malezas o hierba excepto que el sis...

Búsqueda y registro del número de modelo Por favor, NO devuelva la unidad al minorista a quien se la adquirió sin contactarse primero con el Departamento de Asistencia al Cliente. Índice ANTES DE COMENZAR A ENSAMBLAR SU NUEVO EQUIPO, por favor localice la placa del modelo en el equipo y copie la inf...

19 1 Indica- dor de pendien- te ADVER- TENCIA No pode en inclina- ciones mayores a 15 grados (elevación aproximada de 2 1/2 pies por cada 10 pies). Una podadora en movimiento podría voltearse y causar lesiones severas. Si en una pendiente opera una podadora ubicado detrás de la misma, es extremada- ...

21 10. Muchas lesiones ocurren como resultado de pasar la cortadora sobre los pies durante una caída provocada por derrapes o tropiezos. No se sostenga de la podadora si se está cayendo, suelte la manija inmediatamente. 11. Nunca tire hacia usted la podadora mientras camina. Si debe retroceder la po...

23 menos que los ganchos del colector de césped estén firmemente asentados en la varilla de pivote y la puerta de descarga posterior descanse firmemente contra la parte superior del colector de césped. 7. Su podadora ha sido enviada como abonadora. Si hace la conversión a descarga lateral, asegúrese...

25 4 Funcionamien- to de la poda- dora ADVERTENCIA Al operar una podadora puede ser que objetos extraños sean arrojados a los ojos, lo cual puede dañarlos gravemente. Utilice siempre gafas de seguridad durante la operación de la poda- dora o mientras la ajusta o la repara. Asegúrese que nin- guna pe...

28 Si debe realizar reparaciones más importantes que las enunciadas aquí, comuníquese con el distribuidor local autorizado. 6 Solución de problemas Causa Problema Remedio El motor no arranca 1. Control de la cuchilla desenganchado.2. Se ha desconectado el cable de la bujía. 3. El tanque de combustib...

La garantía limitada que se extiende a continuación es otorgada por la empresa Troy-Bilt LLC y cubre mercaderías nuevas compradas y utilizadas en los Estados Unidos, sus posesiones y territorios.“Troy-Bilt” garantiza este producto por defectos de materiales y de fabricación por un período de dos (2)...