Roberts-Gordon HP 120 V 1 - Manuals

Page 3 - SECTION 4: Typical External Wirin

© 2009 Ro b erts-Gordon LLC All rights reserved. N o part of this work covered b y the copyrights herein may b e reproduced or copied in any form or b y any means - graphic, electronic, or mechanical, including photocopying, recording, taping or information storage and retrieval systems - without th...

Page 5 - TABLE OF FIGURES

TABLE OF FIGURES Fig u re 1: Panel Layo u t .............................................................. 3 Fig u re 2: Terminal Block G u ide ................................................. 4 Fig u re 3: Mo u nting Hole Layo u t ................................................ 5 Fig u re 4: Syst...

Page 7 - What is a ROBERTS GORDON; Section 7; Check Installation Materials; DANGER

SECTION 1: I NTRODUCTION 1 SECTION 1: INTRODUCTION1.1 Safety Yo u r Safety is Important to Us! This symbol is u sed thro u gho u t the man u al to notify yo u of possible fire, electrical or b u rn hazards. Please pay special attention w hen reading and follo w ing the w arnings. Installation, ser v...

Page 8 - See Page; CAUTION; Product Damage Hazard

S YSTEM C ONTROL I NSTALLATION , O PERATION AND S ERVICE M ANUAL 2 1.4.2 Electrical Installation Materials 120 V, 60 Hz, 1 Ø, 20 A, po w er s u pply to the control panel m u st be installed in accordance w ith the most c u rrent National Electrical Code ® , local codes and any site specific diagrams...

Page 9 - Material Specifications; Full Load Current

SECTION 2: S PECIFICATIONS 3 SECTION 2: SPECIFICATIONSFIGURE 1: Panel Layout 2.1 Material Specifications Enclos u re Material: Metal Weight: 6.8 lbs Dimensions: 10.2" x 11.4" x 2.8" (25.4 x 29.0 x 7.1 cm) Protection: Rating IP20 2.2 Electrical Specifications S u pply: 120 V, 60 Hz, 1 Ø, ...

Page 10 - Figure 2; FIGURE 2: Terminal Block Guide

S YSTEM C ONTROL I NSTALLATION , O PERATION AND S ERVICE M ANUAL 4 2.4 Burner Electrical Ratin g s CORAYVAC ® b u rners: 120 V, 60 Hz, 1 Ø 0.3 A VANTAGE ® NP (m u ltib u rner only) b u rners:120 V, 60 Hz, 1 Ø 0.2 A 2.5 Outside Air Supply Blower Electrical Ratin g s O u tside air s u pply blo w er (P...

Page 11 - Figure 3; Pump

SECTION 3: I NSTALLATION 5 SECTION 3: INSTALLATION Installation of the System Control and the associated external electrical w iring m u st be completed by an electrician q u alified in the installation of control systems for heating eq u ipment. 3.1 Preparation Before installing the System Control,...

Page 12 - See Page 10, Figure 8; uration; Contactor Packages; Enclosure IEC metal 8X6X6 NEMA 1

S YSTEM C ONTROL I NSTALLATION , O PERATION AND S ERVICE M ANUAL 6 For the EP-203 (3 Ø), EP-303 (3 Ø), EP-100, EP-201 and EP-301 208/230 V (1 Ø) p u mps, u se the 17 Amp contactor package (P/N 10050011). For the EP-301 p u mps that are operated w ith 120 V (1 Ø) u se the 28 Amp contactor package (P/...

Page 13 - Dia; Electrical Shock Hazard; System Control; Ground

SECTION 4: T YPICAL E XTERNAL W IRING D IAGRAMS 7 SECTION 4: TYPICAL EXTERNAL WIRING DIAGRAMS 4.1 EP-100 or EP-201 120 V 1 Ø Pump External Wirin g Dia g ram The external w iring diagram abo v e sho w s the con- nections for fo u r zones of system b u rners. System b u rners can be either CORAYVAC ® ...

Page 18 - uu; WARNING; Explosion Hazard

S YSTEM C ONTROL I NSTALLATION , O PERATION AND S ERVICE M ANUAL 12 SECTION 5: TROUBLESHOOTING 5.1 Se q uence of Operation a. On demand for heat from the thermostat, the panel w ill send po w er to the p u mp. The p u mp w ill begin operation. b. Once v ac uu m is established, the press u re s w itc...

Page 19 - FIGURE 9: System Control Troubleshootin

SECTION 5: T ROUBLESHOOTING 13 FIGURE 9: System Control Troubleshootin g Chart Contact Ro b erts-Gordon LLC at www.rg-inc.com. Contact Ro b erts-Gordon LLC at www.rg-inc.com. Contact Ro b erts-Gordon LLC at www.rg-inc.com. Contact Ro b erts-Gordon LLC at www.rg-inc.com. Trou b leshoot ends.Contact R...

Page 20 - Item; Transformer

S YSTEM C ONTROL I NSTALLATION , O PERATION AND S ERVICE M ANUAL 14 SECTION 6: REPLACEMENT PARTS FIGURE 10: System Control Internal Components Dia g ram Item Description Part Number 1 F u se 250 mA 10000212 2 Transformer N/A 4 Board Assembly 10090101 Carbon Monoxide Hazard WARNING Use only genuine R...

Page 21 - Replacement Parts Instructions

SECTION 6: R EPLACEMENT P ARTS 15 6.1 Replacement Parts Instructions 6.1.1 F u se 250 mA See Page 14, Figure 10 , Item 1 . This time delay f u se protects the System Control from po w er s u rges, lightning and incorrect w iring. If the f u se needs replacing, the follo w ing steps m u st be taken. ...

Page 23 - SECTION 7: THE ROBERTS GORDON

SECTION 7: T HE ROBERTS GORDON ® S YSTEM C ONTROL W ARRANTY 17 SECTION 7: THE ROBERTS GORDON ® SYSTEM CONTROL WARRANTYROBERTS-GORDON LLC WILL PAY FOR: Within 24 months from date of p u rchase by b u yer or 27 months from date of shipment by Roberts-Gordon LLC ( w hiche v er occ u rs first), replacem...