Raypak RHP 33 - Manuals

Raypak RHP 33 – Manual in PDF format online.

Manuals:

Manual

Manual Raypak RHP 33

Summary

Page 2 - PRODUCT SAFETY SIGNS AND LABELS; An example of a heat pump safety label follows.; AUDIENCE; The audience for this manual is twofold:; WARRANTY CLAIMS; CAUTION

PRODUCT SAFETY SIGNS AND LABELS This manual, as well as the pool/spa heat pump itself, contains product safety signs and labels. Please read these signs and labe ls, as they convey important safety information about hazards that may be potentially present in and around the heat pump. They are classi...

Page 3 - RHP Series Swimming Pool and Spa Heat Pump; OWNER and INSTALLATION MANUAL; CONTENTS; ii

RHP Series Swimming Pool and Spa Heat Pump OWNER and INSTALLATION MANUAL CONTENTS Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 I. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

Page 4 - Introduction; minimize water piping.; WARNING

Introduction This pool/spa heat pump is an electromechanical machine that incorporates a pressurised refrigerant gas in a sealed system. ONLY trained and qualified service personnel should attempt to install or service this equipment. Without proper training and knowledge of such equipment, any atte...

Page 5 - For this purpose, 4 black rubber sound isolation; II. Electrical Connections; Table 1: Typical System Electrical Power Requirements; Model

• Each side of the unit must be located at least 300mm from walls, pipes, or other obstructions for unrestricted air intake and service access. Do not install the unit within 1m of fossil fuel burning heaters. Air intake along the sides of this heat pump could disturb the combustion processof the un...

Page 6 - III. Water Connections; WATER IN; IV. Controls and Indicator Lamps; Water Pressure Switch

III. Water Connections The heat pump inlet and outlet connections are NOT interchangeable. They must be connected as instructed below. 1. Connect the heat pump in the return water line between the pool filter and the pool. See page 10, Plumbing Diagrams. 2. Connect the filter outlet to the fitting m...

Page 7 - Indicator Lamps; Under normal operation; ON

Indicator Lamps : There are 6 indicator lamps located on the unit control panel: • Power (amber lamp): When lit, indicates power is applied to the unit. • Water Flow (green lamp): When lit, indicates normal water flow. • Heat Demand (green lamp): When lit, indicates the actual water temperature is b...

Page 8 - Pool; or; Spa; . If the pool pump is running and the water is; VII. Heat Pump Running Time

NOTE: The heat pump will be OFF when the Remote position is selected on the Pool/Spa selector switch. 4.Allow the heat pump to operate for a few minutes to stabilize operating pressures and to allow various component temperatures to normalize. 5. Verify that the discharge air temperature is approxim...

Page 9 - VIII. Summer Shutdown; IX. Freeze Protection; Remote; Continuous Pump Operation

VIII. Summer Shutdown If you do not plan to use the pool heat pump during the summer months, secure and protect it as follows: 1. From the control panel, turn the control switch to Remote (OFF). 2. Turn the heat pump power switch to OFF. 3. Leave the valves set the way they are unless additional cir...

Page 10 - The cabinet is designed for outdoor use and requires little care.; heat from the air and transferring it to the pool.; Remember that the heat pump only; Set the pool system time clock to permit; 4 hour per day

2. B. Cabinet Care (optional) - The cabinet is designed for outdoor use and requires little care. However, you can clean it if you wish. 1. 2. Wash the cabinet with soap and water. C. Condensate Drainage - The heat pump extracts humidity from the air as it passes through the coil, similar to the way...

Page 11 - B. UNIT IS NOT RUNNING; higher; SERVICE CALL REQUESTS

operation. After the desired temperature is reached, return the system to normal operation. •Is airflow through the unit being obstructed? Restrictions such as shrubbery, tall grass, dirty coils, or any other obstruction to airflow will reduce performance. •Is the pool blanket/cover being used? Unbl...

Page 12 - POWER SUPPLY; Power; since it may be a power problem requiring an electrician.; Water Flow; TIME CLOCK ADJUSTMENT

POWER SUPPLY •Verify that all circuit breakers are reset and working properly.•If the Power lamp on the control panel still does not light, contact the installing dealer, since it may be a power problem requiring an electrician. WATER FLOW •Verify that the filter is clean to provide good flow.•Verif...

Page 13 - Plumbing Diagrams

Plumbing Diagrams For systems with pumps of less than 2 HP(1.5Kw) (under 300 l/min), no external bypass is required. Connections are 50 mm pipe slip. Plumb the heat pump after the filter and before any chlorinators. Water In (from poolor Spa) Water Out (to poolor Spa) Filter For systems with pumps o...

Page 14 - Heat Pump Schematic

Heat Pump Schematic 12 4 3 A B C D 4 3 2 1 D C B A el ti T n oi si ve R re b m u N ez i S A f o t ee h S 3 0 0 2- na J- 7 2 :e ta D : y B n wa r D b d d. tc af o o P\ tc af o o P\ tc a F l o o P\ : C :e li F 1 2 3 4 5 6 7 8 9 0 1 1 1 2 1 3 1 4 1 5 1 6 1 7 1 8 1 9 1 0 2 1 2 2 2 3 2 4 2 1 B T ec af re...

Page 15 - Control Panel Assembly Replacement Parts List

Control Panel Assembly Replacement Parts List 12 4 7 13 11 10 16 11 9 15 2 5 8 14 3 6 1 ITEM QTY DESCRIPTION PART No. 11 Control Panel 21 Contactor Compressor 31 Fan Relay 41 Control Board 24Volt 51 Thermostat 61 Transformer 71 Timer IMC 203 81 Capacitor 91 Pressure Switch Water 10 1 Fuse Block 11 2...

Page 16 - Control Panel Cover Assembly Replacement Parts List

Control Panel Cover Assembly Replacement Parts List 1 4 4 4 7 6 7 6 8 8 5 Front ITEM QTY DESCRIPTION PART No. 11 Control Panel Cover 22 POT 31 Switch Type A403 43 Knob 51 Label Control Panel 62 Lamp Green 72 Lamp Red 82 Lamp Amber 2 3 2 RHP Control Panel Cover 1 Back 13

Page 17 - Heat Pump Assembly Replacement Parts List

Heat Pump Assembly Replacement Parts List - RHP 33 11 15 13 12 5 9 2 9 16 7 7 18 14 6 7 3 17 19 4 10 1 8 Model RHP 33 *See assembly drawing in this manual ITEM QTY DESCRIPTION PART No. 11 Assembly Base 21 Evaporator Coil 31 A ccess Panel 41 Power Input Panel 51 Cover, Top 61 Compressor, Scroll 73 Co...