Multiquip ST2010 Series - Manuals

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 5 safety infOrMatiOn general SaFeTY CauTion „ never operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protecti...

page 6 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) safety infOrMatiOn pump SaFeTY danger „ never operate the equipment in an explosive atmosphere or near combustible materials. An explosion or fi re could result causing severe bodily harm or even death. Warning ...

page 8 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) speCifiCatiOns Table 1. Specifications model ST-2010/ST-2010a/ ST-2010Cul ST-2010b ST-2010TCul Type Submersible Pump Submersible Pump Submersible Trash Pump Impeller Cast Ductile Iron Cast Ductile Iron Cast Duct...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 9 diMensiOns ST2010TCul ST2010, ST2010a, ST2010b, ST2010Cul Figure 1. ST2010 Series Dimensions 23.82 in. (605 mm.) 10.23 in. (260 mm.) 3.14 in. (80 mm.) 5.11 in. (130 mm.) NPT 2 4.52 in. (115 mm.) 3.54 in. (90 mm...

page 10 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) general infOrMatiOn inTroduCTion The Multiquip Model ST-2010 submersible pump is designed to pump water and is used for the draining (de- watering) of well casings construction sites, cofferdams, manholes, tran...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 11 COMpOnents ST2010, ST2010a, ST2010b, ST2010Cul ST2010TCul 6 5 2 3 1 4 7 8 9 Figure 2. Submersible Pump Components Figure 2 shows the location of the basic components for the ST2010 series submersible pumps. Li...

page 12 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) flOat switChes FloaT SWiTCH THeorY Mercury monitoring is a mercury-switch actuated, liquid- level control that has proven to be more economical and longer lasting than other types of liquid-level control system...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 13 flOat switCh (piggy-baCk) FloaT SWiTCH Single or dual control float switches (Figure 6) can be used for the unattended operation of the submersible pump. When using the piggy-back power configuration (plug), t...

page 14 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) flOat switCh (COntrOl bOx) ConTrol box For special remote pumping applications of the submersible pump, a control box (Model CB3 - for ST2010, ST2010A, ST2010CUL, and ST2010TCUL and Model CB6 - for ST2010B) may...

page 16 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) OperatiOn HoSe ConneCTionS Connect a 2-inch hose to the discharge port on the pump as shown in Figure 9. Make sure that the hose is attached correctly to the discharge port. pump poWer ConneCTionS (piggY-baCk C...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 17 COntrOl bOx installatiOn ConTrol box mounTing Mount the control box in an upright vertical position. Make sure the control box is securely fastened to a flat surface, that is free of dust, dirt, moisture or an...

page 18 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) ConneCTing aC poWer To THe ConTrol box 1. The AC power cord (input) should have three wires. Each wire is color coded. The colors are WHITE, BLACK and GREEN. 2. Remove the AC input connector housing from the co...

page 20 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) MaintenanCe lubriCaTion To check the oil level of the mechanical seal perform the following:1. Lay the pump (Figure 12) on its side with the oil plug facing upwards. 2. Remove oil fill plug.3. Visually inspect ...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 21 trOubleshOOting Troubleshooting (pump) Symptom possible problem Solution Pump Fails To Start Incorrect voltage/amps? Check that proper voltage is being supplied to the pump. Also check that there is an adequat...

page 22 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) perfOrManCe Curves GALLONS PER MINUTE LITERS PER MINUTE FT. METERS PUMPING CAPACITY T O T A L HEAD 20 40 60 80 100 0 0 20 30 40 50 60 10 100 200 300 15 10 5 ST2010TCUL GALLONS PER MINUTE LITERS PER MINUTE FT. M...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 23 COntrOl bOx wiring diagraM COIL L1 T1 SUBMERSIBLE PUMP 1 2 3 4 5 6 7 8 STOP FLOAT SWITCH (LOW) T2 PUMP POWER CORD BLACK WHITE GREEN CHASSIS GND. WHITE BLACK BLACK POWER ON LAMP BLACK WHITE BLACK CONTACTOR L2 E...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 25 MOtOr wiring diagraM LEAD WIRES AC POWER CORD U V BLACK (LINE) WHITE (NEUTRAL) GREEN (GROUND) CAPACITOR MAIN COIL AUX.COIL CENTRIFUGAL SWITCH ST-2010, ST-2010A, ST-2010B, ST-2010CUL ELECTRIC MOTOR WIRING DIAGR...

page 26 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) explanatiOn Of COde in reMarks COluMn The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if ther...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 27 suggested spare parts ST-2010 SerieS SubmerSible pump 1 To 3 uniTS qty. p/n description 1 ...........0202010T120 ....... ACCORD WITH GLAND 1............0202010T081 ...... OIL SEAL 1............0202010T112 .......

page 36 —ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) terMs and COnditiOns Of sale — parts paYmenT TermS Terms of payment for parts are net 30 days. FreigHT poliCY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipm...

ST2010 SerieS SubmerSible pump • operaTion and parTS manual — rev. #3 (12/07/12) — page 37 nOtes

OperatiOn and parts Manual Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING United StateS Multiquip Corporate Office MQ Parts Department 18910 Wilmington Ave. Carson, CA 90746 Contact: [email protected] Tel. (800) 421-1244 Fax (310) 537-3927 80...