Page 2 - prOpOSitiOn 65 WarninG
page 2 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) prOpOSitiOn 65 WarninG Engine exhaust and some of its constituents, and some dust created of California to cause cancer, birthdefects and other reproductive harm. by power sanding, sawing, grinding, drilling and othe...
Page 3 - nOteS
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 3 nOteS
Page 4 - taBle Of COntentS; NOTICE
page 4 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) taBle Of COntentS WBH16/WBH16e power Buggy Proposition 65 Warning ........................................... 2 Table Of Contents .................................................... 4 Safety Information ...............
Page 5 - Safety infOrMatiOn; saFety messages; danger; Lethal exhaust gas hazards; Symbol; Hydraulic fluid hazards
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 5 Safety infOrMatiOn Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety...
Page 6 - general saFety; keep
page 6 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) Safety infOrMatiOn general saFety Caution never operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective dev...
Page 7 - poWer Buggy saFety
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 7 Safety infOrMatiOn poWer Buggy saFety danger Engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment requires ...
Page 8 - securely
page 8 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) Safety infOrMatiOn do not operate the power buggy at excessive speeds. Reckless operation may cause accidents and severe injury. Slow down when approaching people, wet areas, and going up and down grades. It is the...
Page 9 - engine saFety; Fuel saFety
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 9 Safety infOrMatiOn engine saFety Warning do not place hands or fingers inside engine compar tment when engine is running. never operate the engine with heat shields or guards removed. Keep fi ngers, hands hair ...
Page 10 - clothing or skin; liFting saFety; transporting saFety; environmental saFety
page 10 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) Safety infOrMatiOn alWays recharge the battery in a well-ventilated environment to avoid the risk of a dangerous concentration of combustible gases. If the battery liquid (dilute sulfuric acid) comes into contac...
Page 11 - SpeCifiCatiOnS
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 11 SpeCifiCatiOnS Table 1. specifications (power Buggy) Models WBH16/WBH16E Wheelbase 44 in. (1,117.6 mm) Overall Length 103 in. (2,616.2 mm) Overall Width- Dual Wheels 43.25 in. (1,098.6 mm) Maximum Weight Capacity (D...
Page 13 - DiMenSiOnS; side vieW
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 13 DiMenSiOnS Figure 1. WBH16/WBH16E Dimensions side vieW rear vieW
Page 14 - read and thoroughly; General infOrMatiOn
page 14 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) The MQ Whiteman Power Buggy, Models WBH16 (recoil start) and WBH16E (electric start) are intended for the transportation of concrete, concrete spreading and spot pouring. In addition, the WBH16/WBH16E is designed fo...
Page 15 - COMpOnentS; Components
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 15 COMpOnentS 1. Tub or Bucket — Used for the transportation of material. Tub holds approximately 16 cubic feet (0.59 cubic yards) of water. 2. Handle Bar (steering) — This handle bar is used to steer the buggy. When d...
Page 16 - BaSiC enGine; Engine
page 16 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) BaSiC enGine Figure 3. Honda gX390K1 Engine 1. Fuel Filler Cap — Remove this cap to add unleaded gasoline to the fuel tank. Make sure cap is tightened securely. DO NOT over fill. 2. throttle lever — Used to adjust e...
Page 17 - inSpeCtiOn; BeFore starting; Figure 4. Engine Oil Dipstick Removal; gasoline CHeCK; Oil Type; hot or
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 17 inSpeCtiOn BeFore starting 1. Read safety information at the beginning of manual.2. Clean the machine, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Check the air ...
Page 18 - Figure 7. Hydraulic Sight Glass
page 18 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) parKing BraKe CHeCK Check the brakes as outlined in the maintenance section of this manual. linKage CHeCK Check and make sure that all linkages within the buggy are functioning correctly. steering CHeCK 1. Check and...
Page 19 - OperatiOn; Caution; Figure 11. Throttle Lever
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 19 OperatiOn eleCtriC start (WBH16e only) 1. Before attempting to start the power buggy, make sure that the safety kill switch (Figure 19) is not pushed in. The power buggy will not start with the kill switch engaged. ...
Page 20 - reCoil start; Figure 14. Starter Grip; Figure 15. Parking Brake Lever
page 20 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) OperatiOn 7. Make sure the choke lever is in the OPEN position (Figure 10) before operating the power buggy. Before the buggy is placed into operation, run the engine for several minutes. Check for fuel leaks, and n...
Page 21 - parKing BraKe/direCtion lever; Figure 17. Direction Lever; traveling; Figure 18. Brake Pedal
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 21 parKing BraKe/direCtion lever Before the power buggy can be put into operational use, it is best to perform a test run to make certain that all components are functioning properly.1. Place the buggy on flat solid gr...
Page 22 - emergenCy sHutdoWn; Figure 19. Safety Kill Switch; steering; Figure 20. Steering the Buggy; traveling on a slope; Figure 21. Determining Grade of Slope
page 22 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) OperatiOn emergenCy sHutdoWn The WBH16/WBH16E is equipped with a safety kill switch. This switch is located on the right side of the handle bar.1. Press the power buggy's kill switch (Figure 19) and listen for the e...
Page 24 - MaintenanCe; engine; Figure 24. Hydraulic Oil Tank Filler Cap; HydrauliC drive motors
page 24 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) MaintenanCe engine Refer to the Honda engine owner’s manual for specific information.1. Check engine oil after every 10 hours of operation and maintain proper levels. 2. Drain oil after every 50 hours of operation a...
Page 25 - pump Control lever adjustment; lug nut torque requirements; Figure 25. Lug Nut Torque Sequence; Tire Torque Requirements
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 25 pump Control lever adjustment If the power buggy tends to creep in the forward or reverse direction after you release the speed control lever, the pump control lever requires adjustment.3. Place the machines drive w...
Page 26 - trOuBleSHOOtinG
page 26 — WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) trOuBleSHOOtinG troubleshooting (power Buggy) symptom Possible Problem solution Loss of Power. Speed control cable out of adjustment? Adjust speed control cable. Replace cable if necessary Hydraulic oil level low.? ...
Page 29 - HyDrauliC SySteM DiaGraM
WBH16/WBH16e poWer Buggy • operation and parts manual — rev. #9 (12/03/10) — page 29 HyDrauliC SySteM DiaGraM
Page 30 - OperatiOn Manual; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; Canada
OperatiOn Manual Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2010, MULTIQUIP INC. Multiquip Inc, the MQ logo and the Whiteman logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without...
