Multiquip QPT205SLT - Manuals

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 5 parts OrderinG prOCedures www .multiquip .com Ordering parts has never been easier! Choose from three easy options: We aCCepT aLL MajoR CRedIT CaRdS! when ordering parts, please supply: ❒ dealer account Nu...

page 6 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) saFetY inFOrMatiOn FOR YOUR SAFETY AND SAFETY OF OTHERS! Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety messages and operating in...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 7 saFetY inFOrMatiOn „ NEVER touch the hot exhaust manifold, muffler or cylinder. Allow these parts to cool before servicing engine or pump. Never operate the engine with heat shields or guards removed. „ AL...

page 8 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) saFetY inFOrMatiOn ■ NEVER run engine without air cleaner. Severe engine damage may occur. ■ ALWAYS ensure pump is on level ground before use. ■ NEVER pump volatile, explosive, flammable or low flash point ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 9 saFetY inFOrMatiOn REFUELING MAINTENANCE SAFETY ■ NEVER lubricate components or attempt service on a running machine. ■ ALWAYS allow the machine a proper amount of time to cool before servicing. ■ Keep the...

page 12 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) General inFOrMatiOn appLICaTIoN The QP205SLT/QPT205SLT centrifugal pump is a high pressure pump designed to be used for dewatering applications. The suction por t on the QP205SLT/ QPT205SLT uses a 2-inch d...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 13 puMp COMpOnents Figure 2 shows a typical application using the QP205SLT/QPT205SLT centrifugal pump. Please note that this pump is intended for the removal of clean water. Figure 2. QP205SLT/QPT205SLT Pump...

page 14 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) basiC enGine Figure 3. Engine Controls and Components INITIaL SeRvICINg The engine (See Figure 3) must be checked for proper lubrication and filled with fuel prior to operation. Refer to the manufacturer's...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 15 inspeCtiOn BeFoRe STaRTINg 1. Read safety instructions at the beginning of manual. 2. Clean the pump, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Chec...

page 16 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) set-up BeFoRe STaRTINg 1. R e a d s a fe t y i n s t r u c t i o n s a t t h e beginning of manual. 2. Place pump as near to water as possible, on a firm flat, level surface. 3. To prime pump, remove fill ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 17 OperatiOn This section is intended to assist the operator with the initial start-up of the pump. It is extremely important that this section be read carefully before attempting to use the pump in the fiel...

page 18 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) 6. Grasp the starter grip (See Figure 11) and slowly pull it out. The resistance becomes the hardest at a certain position, corresponding to the compression point. Pull the starter grip briskly and smoothl...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 19 MaintenanCe (puMp) pUMp vaCUUM TeST To perform the pump vacuum test do the following:1. Remove the pump fill cap (See Figure 2), and fill the pump with water. 2. Start the engine as outlined in the initia...

page 20 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) MaintenanCe (puMp) Figure 17. Pump Vacuum Tester

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 21 MaintenanCe (enGine) ENGINE MAINTENANCE Perform engine maintenance procedures as referenced by Table 6 below: Table 6. Engine Maintenance Schedule description (3) operation Before First Month or 10 hrs ev...

page 22 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) MaintenanCe (enGine) MAINTENANCE Perform the engine maintenance procedures as indicated below: daily 1. Thoroughly remove dirt and oil from the engine and control area. 2. Clean or replace the air cleaner ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 23 preparatiOn FOr lOnG-terM stOraGe pUMp SToRage For storage of the pump for over 30 days, the following is required: „ Drain the fuel tank completely. „ Run the engine until the fuel in the injection syste...

page 24 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) trOublesHOOtinG Troubleshooting (pump) Symptom Possible Cause Solution Pump does not take on water. Not enough priming water in the housing? Add water. Engine speed too low? Increase throttle. Strainer plu...

page 28 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) eXplanatiOn OF COde in reMarKs COluMn The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 29 suGGested spare parts QP205SLT/QPT205SLT CENTRIFuGAL PuMP WITH HoNda gx240k1pMT2/gx240U1pMT2 eNgINe 1 To 3 UNITS Qty. p/N description 2............KIT205 .................. KIT, PUMP, MECHANICAL SEAL, SLE...

page 30 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) puMp asseMblY 50 51 55 32 14 42 39 39 42 23 42 41 39 40 23 52 37 57 38 QP205SLT ONLY 56 PUMP KIT OHV 36 54 10 8 4 7 21 44 48 43 16 27 12 29 29 49 47 22 13 11 24 28 53 5 6 9 30 18 31 25 15 35 46 20 2 34 19 ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 35 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. No. paRT No. PART NAME QTY. REMARKS 1 + 16271ZE2000 GASKET, ELBOW 1 1 , 16271ZE2010 ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 37 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. No. paRT No. PART NAME QTY. REMARKS 1 + 14100ZE2W00 CAMSHAFT ASSEMBLY .................

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 41 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. CONTINUED No. paRT No. PART NAME QTY. REMARKS 15 16220ZA0702 SPACER, CARBURETOR 1 16...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 43 No. paRT No. PART NAME QTY. REMARKS 2 16551ZE2000 ARM, GOVERNOR 1 3 16555ZE2000 ROD, GOVERNOR 1 4 16561ZE2000 SPRING, GOVERNOR 1 5 16562ZE2000 SPRING, THROTTLE RETURN 1 6 16570ZE2W00 CONTROL ASSEMBLY........

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 45 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. No. paRT No. PART NAME QTY. REMARKS 2 + 11399ZE2600 COVER ASSY., CRANKCASE ............

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 49 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — CYlinder barrel assY. No. paRT No. PART NAME QTY. RE...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 51 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — CYlinder Head assY. No. paRT No. PART NAME QTY. REMA...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 53 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — Fan COver assY. No. paRT No. PART NAME QTY. REMARKS ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 57 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — Fuel tanK assY. No. paRT No. PART NAME QTY. REMARKS ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 61 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — MuFFler assY. No. paRT No. PART NAME QTY. REMARKS 1 ...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 63 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — pistOn assY. No. paRT No. PART NAME QTY. REMARKS 1 +...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 65 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — reCOil starter assY. No. paRT No. PART NAME QTY. REM...

Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) — page 69 NOTICE + GX240K1PMT2: Model QP205SLT S/N 205SLT-0049 AND BELOW , GX240U1PMT2: Model QP205SLT S/N 205SLT-0050 AND ABOVE. HOnda GX240K1pMt2/GX240u1pMt2 — labels assY. No. paRT No. PART NAME QTY. REMARKS 1 +...

page 70 —Qp205SLT/QpT205SLT CeNTRIFUgaL pUMp • opeRaTIoN aNd paRTS MaNUaL — Rev. #1 (10/11/10) terMs and COnditiOns OF sale — parts PAYMENT TERMS Terms of payment for parts are net 30 days. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All ...

OperatiOn and parts Manual Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2010, MULTIQUIP INC. Multiquip Inc and the MQ logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written ...