Multiquip QP2E - Manuals

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 5 PARTS ORDERING PROCEDURES www .multiquip .com Ordering parts has never been easier! Choose from three easy options: WE ACCEPT ALL MAJOR CREDIT CARDS! When ordering parts, please supply: R Dealer Account Number R Dealer ...

PAGE 6 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) SAFETY INFORMATION FOR YOUR SAFETY AND SAFETY OF OTHERS! Safety precautions should be followed at alltimes when operating this equipment. Failureto read and understand the safety messagesand operating instructions could...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 7 SAFETY INFORMATION „ NEVER touch the hot exhaust manifold, muffler or cylinder. Allow these parts to coolbefore servicing engine or pump. Neveroperate the engine with heat shields orguards removed. „ ALWAYS allow the en...

PAGE 8 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) SAFETY INFORMATION ■ NEVER run engine without air cleaner. Severe engine damage may occur. ■ ALWAYS ensure pump is on level ground before use. ■ NEVER pump volatile, explosive, flammable or low flash point fluids.These ...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 9 SAFETY INFORMATION REFUELING MAINTENANCE SAFETY ■ NEVER lubricate components or attempt service on a running machine. ■ ALWAYS allow the machine a proper amount of time to cool before servicing. ■ Keep the equipment in ...

PAGE 10 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) SPECIFICATIONS/DIMENSIONS (PUMP) Specifi cations (Pump) Table 1. Model QP2E Type Centrifugal Pump Suction and Discharge Size 2.00 in (51 mm) Maximum Pumping Capacity 158 gallons/minute (600 liters/minute) Max. Lift 25 ...

PAGE 12 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) GENERAL INFORMATION DESCRIPTION The QP2E Centrifugal Pump is designed to handle all types of clear water applications. It is ideal for residential use such as dewatering basements and swimming pools. Both the suction a...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 13 PUMP COMPONENTS Figure 2 shows a typical application using the QP2E centrifugal pump. Please note that this pump is intended for the removal of clean water. QP2E Pump Application Figure 2. Pump 1. — A 2-inch centrifuga...

PAGE 14 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) BASIC ENGINE 1 2 3 4 5 6 8 7 9 10 Robin Engine Components Figure 3. The engine (Figure 3) must be checked for proper lubrication and fi lled with fuel prior to operation. Refer to the manufacturer's engine manual for i...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 15 INSPECTION BEFORE STARTING Read safety instructions at the beginning of manual. 1. Clean the pump, removing dirt and dust, particularly the 2. engine cooling air inlet, carburetor and air cleaner. Check the air fi lter...

PAGE 16 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) OPERATION SETUP Place pump as near to water as possible, on a fi rm 1. fl at, level surface. To prime pump, remove fi ll cap (Figure 2) and fi ll pump 2. casing with water. If the pump casing is not fi lled with water ...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 17 OPERATION Place the throttle lever (Figure 9) halfway between fast 12. and slow. Throttle Lever Figure 9. Grasp the starter grip (Figure 10) and slowly pull it out. 13. The resistance becomes the hardest at a cer tain ...

PAGE 18 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) MAINTENANCE PUMP VACUUM TEST To perform the pump vacuum test do the following: Remove the pump fi ll cap (Figure 2), and fi ll the pump 1. with water. Star t the engine as outlined in the initial star t-up 2. section, ...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 19 MAINTENANCE Pump Vacuum Tester Figure 11. NOTICE Vacuum test may be performed without water fl owing through the discharge port. However, it is recommended to have water fl owing to prevent any heat-up.

PAGE 20 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) ENGINE MAINTENANCE Perform engine maintenance procedures as listed in Table 6: Inspection/Maintenance Table 6. DESCRIPTION (3) OPERATION BEFORE FIRST MONTH OR 10 HRS FIRST 25 HRS EVERY 3 MONTHS OR 25 HRS EVERY 6 MONTHS...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 21 MAINTENANCE Perform the engine maintenance procedures as indicated below: DAILY Thoroughly remove dirt and oil from the engine and 1. control area. C l e a n o r r e p l a c e t h e a i r c l e a n e r e l e m e n t s ...

PAGE 22 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) MAINTENANCE PUMP STORAGE For storage of the pump for over 30 days, the following is required: Drain the fuel tank completely. 1. Run the engine until the fuel in the carburetor is 2. completely consumed. Completely dra...

PAGE 24 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) Engine Troubleshooting Table 7. Symptom Possible Cause Solution Diffi cult to start. Fuel is available but no SPARK at spark plug. Spark plug bridging? Check gap, insulation or replace spark plug. Carbon deposit on spa...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 25 TROUBLESHOOTING Pump Troubleshooting Table 8. Symptom Possible Cause Solution Pump does not take on water. Not enough priming water in the housing? Add water. Engine speed too low? Increase throttle. Strainner plugged?...

PAGE 26 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) EXPLANATION OF CODE IN REMARKS COLUMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are an...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 27 SUGGESTED SPARE PARTS QP2E PUMP WITH ROBIN EX130D51111 ENGINE 1 to 3 units Qty. P/N Description 2 KIT204 .......................KIT, PUMP 2 0631211100ASSY .....CAP, FLOODING WITH O-RING 2 0480350300 ...............O-RI...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 45 ROBIN EX130D51111 ENGINE — CARBURETOR ASSY. NO. PART NO. PART NAME QTY. REMARKS A 2766230130 CARBURETOR ASSY .......................................1................INCLUDES ITEMS W/ # 1# 1066253808 THROTTLE VALVE 1 2#...

QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) — PAGE 53 ROBIN EX130D51111 ENGINE — ACCESSORIES ASSY. NO. PART NO. PART NAME QTY. REMARKS 10 27790301H0 ACCESSORY TOOL KIT 1

PAGE 54 — QP2E CENTRIFUGAL PUMP • OPERATION AND PARTS MANUAL — REV. #0 (02/12/09) TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Terms of payment for parts are net 30 days. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments are...

Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING © COPYRIGHT 2008, MULTIQUIP INC. Multiquip Inc and the MQ logo are registered trademarks of Multiquip Inc. and may not be used, reproduced, or altered without written permission. All other trade...