Multiquip M2870300504 - Manuals

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 9 1 DCA-70SSIU (60 Hz) — SAFETY MESSAGE ALERT SYMBOLS ALWAYS place the Engine ON/OFF switch in the OFF position and remove the ignition key when the pump is not inuse. ALWAYS wear approved respiratory protection. ALWAYS wear...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 11 1 DCA-70SSIU (60 Hz) — RULES FOR SAFE OPERATION POWER CORD (POWER ON) WET HANDS During operation of this generator, thereexists the possibility of electrocution, electrical shock or burn, which can cause severe bodily har...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 13 1 Emergencies ■ ALWAYS know the location of the nearest fire extinguisher. ■ ALWAYS know the location of the nearest and first aid kit. ■ ALWAYS know the location of the nearest phone or keep a phone on the job site, in c...

PAGE 14 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) The DCA-70SSIU (60 Hz) SuperSilent ™ Generator is equipped with a number of safety decals (Figures 2 & 3). These decals are provided for operator safety and maintenance information. The illustration below and on the p...

PAGE 16 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) Figure 4. Typical Generator Grounding Application DCA-70SSIU (60 Hz) — INSTALLATION

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 17 1 Outdoor Installation Install the generator in a area that is free of debris,bystanders, and overhead obstructions. Make sure thegenerator is on secure level ground so that it cannot slide orshift around. Also install th...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 19 1 DCA-70SSIU (60 Hz) — MAJOR COMPONENTS Figure 5. Major Components 4 e l b a T . s t n e n o p m o C r o j a M r o t a r e n e G . O N M E T I N O I T P I R C S E D 1 y l b m e s s A r e lf f u M 2 y l b m e s s A e n i g...

PAGE 20 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) NOTE PAGE

PAGE 22 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) Figure 7. Engine Operating Panel DCA-70SSIU (60 Hz) — ENGINE OPERATING PANEL

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 27 1 DCA-70SSIU (60 Hz) — LOAD APPLICATION Single Phase Load Always be sure to check the nameplate on the generatorand equipment to insure the wattage, amperage, frequency,and voltage requirements are satisfactorily supplied...

PAGE 28 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) Voltage Selector Switch The voltage selector switch (Figure 16) is located above the output terminal panel’s Hard Wire Hook-up Panel . It has been provided for ease of voltage selection. Voltage Selector Switch Locking Bu...

PAGE 32 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — PRE-SETUP Figure 31. Engine Oil Dipstick When checking the engine oil, be sure to check if the oil isclean. If the oil is not clean, drain the oil by removing the oildrain plug, and refill with the sp...

PAGE 40 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — MAINTENANCE Generator Storage For longe term storage of the generator the following isrecommended:  Fill the fuel tank completely. Treat with a fuel stabilizerif necessary.  Completely drain the oil...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 41 1 DCA-70SSIU (60 Hz) — MAINTENANCE Jacket Water Heater and Internal Battery Charger120 VAC Input Receptacles (OPTIONAL) This generator can be optionally equipped with two 120 VAC,20 amp input receptacles located on the ou...

PAGE 44 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) Tires/Wheels/Lug Nuts T i r e s a n d w h e e l s a r e a ver y i m p o r t a n t a n d c r i t i c a lcomponents of the trailer. When specifying or replacing thetrailer wheels it is important the wheels, tires, and axle ...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 45 1 NEVER use an pneumatic air gun to tighten wheel lug nuts. Figure 60. Wheel Lug Nuts Tightening Sequence DCA-70SSIU (60 Hz) — TRAILER MAINTENANCE NOTE Lug Nut Torque Requirements It is extremely important to apply and ma...

PAGE 46 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — TRAILER WIRING DIAGRAM Figure 61. Trailer/Towing Vehicle Wiring Diagram

PAGE 48 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — GENERATOR WIRING DIAGRAM Figure 62. Generator Wiring Diagram

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 49 1 DCA-70SSIU (60 Hz) — ENGINE WIRING DIAGRAM Figure 63. Engine Wiring Diagram

PAGE 52 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) EXPLANATION OF CODE IN REMARKS COLUMN How to read the marks and remarks used in this parts book. Items Found In the “Remarks” Column Serial Numbers-Where indicated, this indicates a serialnumber range (inclusive) where a ...

DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) — PAGE 53 1 DCA-70SSIU (60 Hz) — SUGGESTED SPARE PARTS Part number on this Suggested Spare Parts listmay supercede/replace the P/N shown in the textpages of this book. NOTE DCA-70SSIU (60 Hz) WHISPER WATTGENRATOR W/ISUZU FF4BG1T DI...

PAGE 60 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — ENGINE AND RADIATOR ASSY. ENGINE AND RADIATOR ASSY.

PAGE 64 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — OUTPUT TERMINAL ASSY. OUTPUT TERMINAL ASSY. THE SERIAL NUMBER MAY BE REQUIRED. ADD THE FOLLOWING DIGITS AFTER THE PARTNUMBER WHEN ORDERING ANY PAINTED PANEL TOINDICATE COLOR OF UNIT: 1-ORANGE 5-BLACK ...

PAGE 80 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) DCA-70SSIU (60 Hz) — NAME PLATE AND DECALS ASSY. NAMEPLATE AND DECALS ASSY.

PAGE 82 — DCA-70SSIU (60 Hz) — OPERATION AND PARTS MANUAL — REV. #1 (01/06/09) TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Terms of payment for parts are net 10 days. FREIGHT POLICY All parts orders will be shipped collect orprepaid with the charges added to the invoice.All shipments are F.O....

PARTS AND OPERATION MANUAL OPERATION AND PARTS MANUAL Your Local Dealer is: MQ POWER A Division of Multiquip Inc.POST OFFICE BOX 6254CARSON, CA 90749310-537-3700 • 800-421-1244FAX: 310-632-2656E-mail: [email protected]: www.mqpower.com Manufactured for Multiquip Inc. b y DENYO CO., LTD, ...