Page 2 - Diesel engine exhaust and some of; PROPOSITION 65 WARNING
PAGE 2 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) Diesel engine exhaust and some of PROPOSITION 65 WARNING
Page 3 - REPORTING SAFETY DEFECTS
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 3 If you believe that your vehicle has a defect that could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying ...
Page 4 - TABLE OF CONTENTS; Component Drawings; NOTICE
PAGE 4 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TABLE OF CONTENTS DA7000 SERIES GENERATOR Proposition 65 Warning .................................................. 2Reporting Safety Defects ................................................ 3Table Of Contents ..........
Page 5 - PARTS ORDERING PROCEDURES; Ordering parts has never been easier!; Choose from three easy options:; WE ACCEPT ALL MAJOR CREDIT CARDS!; Order via Internet; Order; internet; Order via Fax; Fax
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 5 PARTS ORDERING PROCEDURES www .multiquip .com Ordering parts has never been easier! Choose from three easy options: WE ACCEPT ALL MAJOR CREDIT CARDS! When ordering parts, please supply: ❒ Dealer Account Number ❒ Deal...
Page 6 - SAFETY INFORMATION; SAFETY MESSAGES; DANGER
PAGE 6 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) SAFETY INFORMATION Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety ...
Page 7 - GENERAL SAFETY; GENERATOR SAFETY
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 7 SAFETY INFORMATION GENERAL SAFETY CAUTION NEVER operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective dev...
Page 8 - ENGINE SAFETY
PAGE 8 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) SAFETY INFORMATION ENGINE SAFETY DANGER The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment requires an...
Page 9 - FUEL SAFETY; TOWING SAFETY; Trailer tires should be infl ated to 50 psi cold
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 9 SAFETY INFORMATION FUEL SAFETY DANGER DO NOT start the engine near spilled fuel or combustible fl uids. Diesel fuel is extremely fl ammable and its vapors can cause an explosion if ignited. ALWAYS refuel in a wel...
Page 10 - ELECTRICAL SAFETY; Power Cord/Cable Safety; Grounding Safety
PAGE 10 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) SAFETY INFORMATION ELECTRICAL SAFETY DANGER DO NOT touch output terminals during operation. Contact with output terminals during operation can cause electrocution, electrical shock or burn. T h e e l e c t r i c ...
Page 11 - BATTERY SAFETY; ENVIRONMENTAL SAFETY
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 11 SAFETY INFORMATION BATTERY SAFETY DANGER DO NOT drop the battery. There is a possibility that the battery will explode. DO NOT expose the battery to open fl ames, sparks, cigarettes, etc. The battery contains co...
Page 13 - Effects of Altitude and Heat
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 13 Table 2. Specifi cations (Engine) Engine Kubota Engine Model Z482-EB Z482-E2B-DGDE-2 Z482-E3B-DGDE-2 Tier 1 2 4 Gen. Enclosure Color Orange Orange/White White Type Vertical, water-cooled, 4-cycle diesel engine Bore ...
Page 14 - DIMENSIONS
PAGE 14 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) DIMENSIONS Figure 1. Dimensions
Page 15 - NOTE
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 15 NOTE
Page 16 - INSTALLATION; CONNECTING THE GROUND; Figure 2. Generator Grounding
PAGE 16 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) INSTALLATION CONNECTING THE GROUND The nut and ground terminal on the generator should always be used to connect the generator to a suitable ground. The ground cable should be #8 size wire minimum. At the generator, ...
Page 17 - OUTDOOR INSTALLATION; DO NOT; GENERATOR GROUNDING; EARTH; ALWAYS
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 17 INSTALLATION OUTDOOR INSTALLATION If possible install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide ...
Page 18 - GENERAL INFORMATION
PAGE 18 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) GENERAL INFORMATION FAMILIARIZATION Generator The Multiquip DA7000 Series generators are 6.0 kW (continuous output), 7.0 kW (max output) A.C. generators designed as a portable dual purpose power source for 60 Hz (sin...
Page 19 - Figure 3. Generator Components
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 19 COMPONENTS (GENERATOR) Figure 3. Generator Components 1. Fuel Gauge — Indicates the amount of fuel in the fuel tank. 2. Air Outlet Exhaust — Allows engine exhaust to exit the generator into the open air. NEVER block...
Page 20 - Figure 4. Generator Components
PAGE 20 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) Figure 4. Generator Components 17. Fuel drain Plug — Remove this plug to drain fuel from the fuel tank. 18. Frame Ground Lug — Connect a ground strap between this lug and a ground rod. Make sure that the ground rod i...
Page 21 - Figure 5. Kubota Z482 Series; INITIAL SERVICING
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 21 COMPONENTS (ENGINE) Figure 5. Kubota Z482 Series INITIAL SERVICING The engine (Figure 5) must be checked for proper lubrication and fi lled with fuel prior to operation. Refer to the manufacturer's engine manual for...
Page 22 - Single Phase Load — 60 Hz; Table 3. Power Factor By Load; LOAD APPLICATIONS; Extension Cables; Cables should be sized to allow for; OFF
PAGE 22 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) Single Phase Load — 60 Hz Always be sure to check the nameplate on the generators and equipment to insure the wattage, amperage and frequency requirements are satisfactorily supplied by the generators for operating t...
Page 23 - Figure 6. Ground Pin; Extension Cable; place the; position prior to starting the engine.; use power tools or equipment that do not; DEATH; Current In; : Equipment damage can result from low voltage.
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 23 INSPECTION/SETUP GENERAL INSPECTION PRIOR TO OPERATION Ground Power Tools When using power tools or electrical equipment requireing AC power from the generator, make sure power tool cord has a ground pin or is doubl...
Page 24 - Figure 7. Engine Oil Dipstick Removal; Temperature
PAGE 24 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) INSPECTION/SETUP Before Starting 1. Read safety instructions at the beginning of manual. 2. Clean the generator, removing dirt and dust, particularly the engine cooling air inlet. 3. Check the air fi lter for dirt an...
Page 25 - Fuel Check; Figure 10. Fuel Gauge; Operation Freezing Weather; Table 6. Coolant Capacity
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 25 Fuel Check Fill the fuel tank with #2 diesel fuel. DO NOT fi ll the tank beyond capacity. Pay attention to the fuel tank capacity when replenishing fuel. Refer to the fuel tank capacity listed in Table 2. The fuel t...
Page 26 - Figure 12. Fan Belt Tension; BATTERY; Figure 13. Battery Connections
PAGE 26 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) INSPECTION/SETUP CLEANING THE RADIATOR The engine may overheat if the radiator fi ns become overloaded with dust or debris. Periodically clean the radiator fi ns with compressed air. Cleaning inside the machine is da...
Page 28 - OPERATION; Before Starting the Engine; open; Figure 15. Generator Doors; CORRECT; GFCI; Starting the Engine; Figure 18. Starter Switch
PAGE 28 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) OPERATION Before Starting the Engine 1. Open the cabinet door and turn the fuel cock lever (Figure 14) to the “ON” position. Figure 14. Fuel Cock Lever (ON) 2. NEVER operate the generator with the doors open (Figure ...
Page 29 - Idle Control; Output Voltage Verifi cation; main; ON
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 29 OPERATION 4. If the engine does not start within 10 seconds after the key is turned to the START position, wait for about 30 seconds and repeat the procedure as described in step 4. above. 5. When the engine starts,...
Page 30 - Emergency Shutdown; Place starter switch key in
PAGE 30 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) OPERATION/SHUTDOWN 4. The CS-6369 receptacle is a dual voltage receptacle (120/240 volts). Using an external voltmeter as shown in Figure 23, verify that 120/240 VAC is present at the CS-6369 twist-lock receptacle.. ...
Page 31 - Generator Storage; Run the engine until all the fuel is completely consumed.; PREPARATION FOR LONG TERM STORAGE
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 31 Generator Storage For storage of the generating set for over 30 days, the following is required: Run the engine until all the fuel is completely consumed. Drain the fuel tank completely, or add STA-BIL to the fu...
Page 32 - MAINTENANCE; Table 8. Engine Maintenance Schedule; DUSTY
PAGE 32 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) MAINTENANCE Use Table 8as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. Table 8. Engine Main...
Page 33 - Maintenance; Figure 29. Engine Oil Drain Plug; Oil Filter Cartridge; Figure 30. Oil Filter Cartridge; Engine Air Cleaner; The air cleaner employed on the; Figure 31. Air Cleaner; NEVER
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 33 MAINTENANCE Maintenance Perform the scheduled maintenance procedures as defi ned by Table 8 and below: Engine Oil Every 100 hours: Change engine oil after the fi rst 50 hours of operation and 100 hours thereafter. A...
Page 34 - Figure 33. Fuel Filter Disassembly; Radiator; Flushing Out Radiator and Replacing Coolant; Figure 35. Coolant Drain Plug
PAGE 34 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) Cleaning the Fuel Filter Every 100 hours: Clean fuel fi lter every 100 hours of operation or once a month to remove dust or water. 1. Place fuel cock lever (Figure 32) in the close position. 2. Disconnect fuel lines ...
Page 35 - RADIATOR CLEANING; Figure 36. Radiator Cleaning; WARNING; GENERATOR STORAGE; negative
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 35 2. Flush the radiator by running clean tap water through radiator until signs of rust and dirt are removed. DO NOT clean radiator core with any objects, such as a screwdriver. 3. Check hoses for softening and kinks....
Page 36 - Figure I. Adjustable Channel; Wheel Bearings; Figure II. Wheel Hub Components; Replace seals that have nicks, tears or wear.; Wheel Hub Adjustment
PAGE 36 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) MAINTENANCE (TRAILER) TRAILER MAINTENANCE The following trailer maintenance guidelines are intended to assist the operator in preventive maintenance. Adjustable Channel Your trailer may be equipped with an adjustable...
Page 37 - crawl under the trailer unless it is on fi rm; Leaf Suspension; Figure III. Leaf Suspension Components; Check suspension regularly.
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 37 MAINTENANCE (TRAILER) DANGER NEVER crawl under the trailer unless it is on fi rm and level ground and resting on properly placed and secured jackstands. The possibility exists of the trailer falling thus causing equ...
Page 38 - TRAILER GUIDELINES; COMMON CAUSES FOR LOSS OF TRAILER
PAGE 38 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES The following guidelines are intended to assist the operator in the operation and handling of a trailer. Safety precautions should be followed at all times when operating a trailer. Failure to read...
Page 39 - DRIVING CONDITIONS
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 39 TRAILER GUIDELINES DRIVING CONDITIONS When towing a trailer, you will have decreased acceleration, increased stopping distance, and increased turning radius (which means you must make wider turns to keep from hittin...
Page 40 - INOPERABLE BRAKES, LIGHTS OR MIRRORS; TRAILER VIN TAG; Figure A. Vehicle VIN Tag
PAGE 40 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES INOPERABLE BRAKES, LIGHTS OR MIRRORS Be sure that the brakes and all of the lights on your trailer are functioning properly before towing your trailer. Check the trailer taillights by turning on yo...
Page 41 - Figure B. VIN Tag Location; GAWR; : The maximum gross weight that an axle cansupport.; GVWR; : The maximum allowable gross weight of the trailer; PSIC; : Some information that comes with the
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 41 TRAILER GUIDELINES Figure B. VIN Tag Location The trailer VIN Tag contains the following critical safety information for the use of your trailer. GAWR : The maximum gross weight that an axle cansupport. It is the lo...
Page 42 - SAFETY CHAINS; Ball Hitch Coupler; BALL HITCH COUPLER; Figure C. Ball Hitch Coupler; Gross Vehicle Weight Rating; . IT IS ESSENTIAL THAT THE HITCH BALL BE
PAGE 42 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES SAFETY CHAINS If the coupler connection comes loose, the safety chains can keep the trailer attached to the tow vehicle. With properly rigged safety chains, it is possible to keep the tongue of the...
Page 43 - Coupling the Trailer to the Tow Vehicle (Ball Coupler); Replace worn or damaged hitch ball.; Figure D. Ball Hitch Coupling Mechanism
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 43 TRAILER GUIDELINES Rock the ball to make sure it is tightened to the hitch, and visually check that the hitch ball nut is solid against the lock washer and hitch frame. Wipe the inside and outside of the coupler...
Page 44 - Attaching Safety Chain; Uncoupling the Ball Hitch
PAGE 44 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES Attaching Safety Chain Visually inspect the safety chains and hooks for wear or damage. Replace worn or damaged safety chains and hooks before towing. Attach the safety chains so that they: • Cross...
Page 45 - PINTLE HITCH COUPLER; Figure F. Pintle Hitch Coupler; Pintle Coupler and Pintle Hook; Gross; Replace worn or damaged pintle hitch hook.
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 45 TRAILER GUIDELINES PINTLE HITCH COUPLER A pintle eye coupler (Figure F) connects to a pintle-hook hitch that is located on or under the rear bumper of the tow vehicle. This system of coupling a trailer to a tow vehi...
Page 46 - Coupling Trailer to Tow Vehicle (Pintle Coupler); TIRE SAFETY
PAGE 46 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES Raise the bottom surface of the coupler to be above the top of the pintle hitch hook. Use the tongue jackstand to support the trailer tongue. Wood or concrete blocks may also be used. Coupling Tr...
Page 47 - Determining Load Limit of Trailer; Tighten lug nuts before each tow.; Be sure lug nuts are tight before each tow.; Figure H. Trailer Tire Placard; TIRE AND LOADING INFORMATION
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 47 TRAILER GUIDELINES wrench, use a lug wrench (from your tow vehicle) and tighten the nuts as much as you can. Then have a service garage or trailer dealer tighten the lug nuts to the proper torque. Lug nuts are also ...
Page 48 - Determining Load Limit of Tow Vehicle; Figure I. Standard Tire Sidewall Information; Next number
PAGE 48 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES Step 2. Determine the weight of the equipment being loaded on the tow vehicle. That weight may not safely exceed the available equipment load capacity. The trailer’s Tire Information Placard is att...
Page 49 - Note; Table A. Speed Rating; Uniform Tire Quality Grading Standards (UTQGS); Figure J. UTQGS Tire Information
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 49 TRAILER GUIDELINES Next number : This two-digit number is the wheel or rim diameter in inches. If you change your wheel size, you will have to purchase new tires to match the new wheel diameter. Next number : This t...
Page 50 - Tire Safety Tips; Table B. Tire Wear Troubleshooting
PAGE 50 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER GUIDELINES Tires for light trucks have other markings besides those found on the sidewalls of passenger tires. LT : The “LT” indicates the tire is for light trucks or trailers. ST : An “ST” is an indication t...
Page 51 - Wheel Rims; Check to see if the lug nuts are tight after the fi rst 10,; Figure K. Wheel Lug Nuts Tightening Sequence; Lights and Signals; Table C. Tire Torque Requirements; Wheel Size; Check all lights before each tow.; use an pneumatic air gun to tighten wheel
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 51 TRAILER GUIDELINES Wheel Rims If the trailer has been struck, or impacted, on or near the wheels, or if the trailer has struck a curb, inspect the rims for damage (i.e. being out of round); and replace any damaged w...
Page 52 - TRAILER WIRING DIGRAM; Figure 37. Trailer Wiring Diagram
PAGE 52 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TRAILER WIRING DIGRAM Figure 37. Trailer Wiring Diagram
Page 53 - GENERATOR WIRING DIGRAM
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 53 GENERATOR WIRING DIGRAM Figure 38. Generator Wiring Diagram (DA7000 SERIES)
Page 54 - ENGINE WIRING DIGRAM; Figure 39. Engine Wiring Diagram
PAGE 54 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) ENGINE WIRING DIGRAM Figure 39. Engine Wiring Diagram
Page 59 - NOTES
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 59 NOTES
Page 60 - EXPLANATION OF CODE IN REMARKS COLUMN; SAMPLE PARTS LIST; ITEMS; REMARKS Column
PAGE 60 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) EXPLANATION OF CODE IN REMARKS COLUMN The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are ...
Page 61 - SUGGESTED SPARE PARTS; GENERATORS WITH KUBOTA; Description
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 61 SUGGESTED SPARE PARTS NOTICE Part numbers on this Suggested Spare Parts list may supersede/replace the par t numbers shown in the following parts lists. DA7000 SERIES GENERATORS WITH KUBOTA Z482-EB/Z482-E2B/ Z482-E3...
Page 62 - NAMEPLATE AND DECALS ASSY.; FRONT VIEW
PAGE 62 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) NAMEPLATE AND DECALS ASSY. 36 3 IDLE CONTROL 0 0 0 0 0 HOURS ON OFF WHISPERWATT 7KW AC Model DA-7000SS 7000 WATT DIESEL POWERED AC GENERA TOR STARTER SWITCH RUN HEAT START STOP HOUR METER AC VOLTMETER AC CIRCUITBREAK...
Page 70 - ENGINE AND RADIATOR ASSY.
PAGE 70 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) ENGINE AND RADIATOR ASSY.
Page 71 - PART NAME
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 71 ENGINE AND RADIATOR ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 A5925200004 ENGINE, Z482EB ........................ 1 ........DA7000SS 1 A5924200004 ENGINE, Z482E2BDGDE2 .......... 1 ........DA7000SS 1 A5924200094 E...
Page 77 - MUFFLER
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 77 MUFFLER ASSY. NO. PART NO. PART NAME QTY. REMARKS 1 D2332100003 MUFFLER 1 2 0016908020 HEX. HEAD BOLT 4 3 D2335000003 EXHAUST PIPE 1 4 1526312371 GASKET ............................................................1....
Page 80 - OIL FILTER RETROFIT ASSY.; PART OF
PAGE 80 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) OIL FILTER RETROFIT ASSY. 12 3 4 6 7 8 9 10 13 15 IDLE CONTROL 0 0 0 0 0 HOURS ON OFF WHISPERWATT 7KW AC Model DA-7000SS 7000 WATT DIESEL POWERED AC GENERA TOR STARTER SWITCH RUN HEAT START STOP HOUR METER AC VOLTMET...
Page 91 - BOLT
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 91 KUBOTA Z482-EB/E2B/E3B ENGINE — OIL PUMP ASSY. OIL PUMP ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1685135010 OIL PUMP ASSY. ...............................................1................Z482-EB 010 1685135012 ...
Page 103 - FLAT
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 103 KUBOTA Z482-EB/E2B/E3B ENGINE — OIL FILTER ASSY. OIL FILTER ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 7000015241 CARTRIDGE, OIL FILTER, Z482-EB .................1................REPLACES P/N 1585399170 010 1585...
Page 105 - DIPSTICK AND GUIDE ASSY.
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 105 KUBOTA Z482-EB/E2B/E3B ENG. — DIPSTICK AND GUIDE ASSY. DIPSTICK AND GUIDE ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1685136410 GAUGE, OIL ......................................................1................Z...
Page 107 - MAIN BEARING CASE ASSY.; GASKET, BEARING CASE
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 107 KUBOTA Z482-EB/E2B/E3B ENG. — MAIN BEARING CASE ASSY. MAIN BEARING CASE ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1685104092 ASSY. CASE, MAIN BEARING, Z482-EB/E2B ..1................INCLUDES ITEMS W/@ 010 16851...
Page 119 - STOP
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 119 KUBOTA Z482-EB/E2B/E3B ENG. — STOP SOLENOID ASSY. STOP SOLENOID ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1685160010 SOLENOID, STOP .............................................1................Z482-EB 010 1685...
Page 122 - KUBOTA Z 482-EB ENGINE—INJECTION PUMP COMPONENTS ASSY.
PAGE 122 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) KUBOTA Z 482-EB ENGINE—INJECTION PUMP COMPONENTS ASSY.
Page 133 - COCK
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 133 KUBOTA Z482-EB/E2B/E3B ENGINE — FUEL FILTER ASSY. FUEL FILTER ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1553143010 FILTER, FUEL ASSY. .........................................1................INCLUDES ITEMS W/$...
Page 139 - PULLEY
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 139 KUBOTA Z482-EB/E2B/E3B ENGINE — DYNAMO ASSY. DYNAMO ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1753164010 DYNAMO ASSY. , Z482-EB ........... 1 ........................ INCLUDES ITEMS W/% 010 1753164012 DYNAMO AS...
Page 144 - KUBOTA Z482-EB ENGINE — OIL SWITCH ASSY.
PAGE 144 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) KUBOTA Z482-EB ENGINE — OIL SWITCH ASSY.
Page 151 - WATER
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 151 KUBOTA Z482-EB/E2B/E3B ENGINE — WATER PIPE ASSY. WATER PIPE ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1584172860 PIPE, WATER 1 020 1588172870 PIPE, WATER 1 030 1584191510 STUD 1 040 0275150060 NUT, FLANGE 1 050...
Page 153 - FAN
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 153 KUBOTA Z482-EB/E2B/E3B ENGINE — FAN ASSY. FAN ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1586774112 FAN 1 020 1584174250 PULLEY, FAN 1 030 0175450610 BOLT, FLANGE 4
Page 163 - STARTER SWITCH ASSY.; WASHER
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 163 KUBOTA Z482-EB/E2B/E3B ENGINE — STARTER SWITCH ASSY. STARTER SWITCH ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 3741059110 STARTER SWITCH ASSY. .................................1................INCLUDES ITEMS W/%...
Page 165 - BAFFLE
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 165 KUBOTA Z482-EB/E2B/E3B ENGINE — AIR CLEANER ASSY. AIR CLEANER ASSY. NO. PART NO. PART NAME QTY. REMARKS 010 1556211010 AIR CLEANER ASSY. ........................................1................INCLUDES ITEMS W/@ 0...
Page 167 - ACCESSORIES; EMERGENCY
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 167 KUBOTA Z482-EB/E2B/E3B ENGINE — ACCESSORIES ACCESSORIES NO. PART NO. PART NAME QTY. REMARKS 010 1747260604 EMERGENCY UNIT 1 020 1584464600 COMP. REGULATOR .........................................1................R...
Page 169 - PISTON
DA7000 SERIES GENERATORS • OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) — PAGE 169 PISTON KIT (OPTION) NO. PART NO. PART NAME QTY. REMARKS 010 1685321002 KIT, PISTON, Z482-E2B/E3B.............................1................INCLUDES ITEMS W/% 020% 1685121114 PISTON 1 030% 1685321050 ASSY. PISTON...
Page 170 - TERMS AND CONDITIONS OF SALE — PARTS
PAGE 170 — DA7000 SERIES GENERATORS• OPERATION AND PARTS MANUAL — REV. #5 (01/20/11) TERMS AND CONDITIONS OF SALE — PARTS PAYMENT TERMS Terms of payment for parts are net 30 days. FREIGHT POLICY All parts orders will be shipped collect or prepaid with the charges added to the invoice. All shipments ...
Page 172 - OPERATION AND PARTS MANUAL; Your Local Dealer is:; HERE’S HOW TO GET HELP; PLEASE HAVE THE MODEL AND SERIAL; UNITED STATES; CANADA
OPERATION AND PARTS MANUAL Your Local Dealer is: HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING UNITED STATES Multiquip Corporate Office MQ Parts Department 18910 Wilmington Ave.Carson, CA 90746 Contact: [email protected] Tel. (800) 421-1244Fax (800) 537-3927 800-4...
Multiquip DCA-45SSIU3
Manual
Multiquip MC3PBA (B&S)
Manual
Multiquip DCA-25SSI
Manual
Multiquip HHXG5
Manual
Multiquip DA7000SSA
Manual
Multiquip PS706026
Manual
Multiquip MVC-64H
Manual
Multiquip DCA-25USIXF
Manual
Multiquip WM120SM
Manual
Multiquip DCA-20SPX
Manual
Multiquip MVC-40G
Manual
Multiquip LT6D
Manual
Multiquip GB3LED
Manual
Multiquip TLG-12SPX4
Manual
Multiquip DFG Series
Manual
Multiquip Qp-301ty
Manual
Multiquip DCA-125USJ
Manual
Multiquip WBH16
Manual
Multiquip DA7000SS
Manual
Multiquip qp402h
Manual