Mr. Heater MHVFB10LPI - Manuals

Page 2 - DANGER; Carbon Monoxide Poisoning:; WARNINGS; IMPORTANT; Fresh Air for

2 Installation instructions and Owner’s Manual This appliance may be installed in an aftermarket* permanently manufactured (mobile) home, where not prohibited by local codes.This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use w...

Page 3 - Figure 1; LOCAL CODES

Installation instructions and Owner’s Manual 3 Product Features Figure 1 SAFETY DEVICE This heater has a pilot with an Oxygen Depletion Sensor (ODS) safety shut off system. The ODS/pilot shuts off the heater if there is not enough fresh air. IGNITION SYSTEM PIEZO: MHVFB10LP – The heater is equipped ...

Page 4 - National Fuel Gas; You must provide additional fresh air. Your options; Figure 2; Ventilation from Outdoors

4 Installation instructions and Owner’s Manual 1. Find the volume of the space by multiplying room length x width x height. Example: Space size 18ft (length) x 18ft. (width) x 8ft. (height) = 2592 If additional ventilation to adjoining room is supplied with grills or openings, add the volume of thes...

Page 5 - INSTALLATION; This heater may also be installed with the hose and; LOCATING HEATER; Figure 4

Installation instructions and Owner’s Manual 5 Code NFPA 54/ ANSI Z223.1, Section 5.3, Air for Com- bustion and Ventilation for required size of ventilation grills or ducts. *IMPORTANT: Do not provide openings for inlet or outlet into attic. If attic has a thermostat-controlled power vent, heated ai...

Page 6 - Figure 5

6 Installation instructions and Owner’s Manual Figure 5 Removing Front Panel of Heater 1. Remove three screws on bottom front of frontpanel. 2. Pull bottom of front panel forward, then down(see figure 6) Figure 6 Attaching Mounting Bracket to Wall Use holes on each end of mounting bracket to attachb...

Page 7 - Figure 9; CONNECTING TO GAS SUPPLY FOR

Installation instructions and Owner’s Manual 7 1. Locate two horizontal slots on back pane of heater (see figure 19). 2. Place heater onto mounting bracket. Slide horizontal slots onto stand-out tabs on mounting bracket. Figure 9 Installing Bottom Mounting Screws 1. Locate two bottom mounting screw ...

Page 8 - CHECKING GAS CONNECTIONS; NEVER bring a refillable propane cylinder; Pressure Testing Heater Gas Connections:; Operating Your Heater

8 Installation instructions and Owner’s Manual run correctly. IMPORTANT: Hold pressure regulator with wrench when connecting it to gas piping and/or fittings. CHECKING GAS CONNECTIONS WARNING: Test all gas piping and connections for leaks after installing or servicing. Correct all leaks at once. WAR...

Page 9 - FOR YOUR SAFETY READ BEFORE LIGHTING; WHAT TO DO IF YOU SMELL GAS; LIGHTING INSTRUCTIONS; Burner Flame

Installation instructions and Owner’s Manual 9 Figure 13 Figure 14 FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life.A. This appliance has a pilot that must be lighted...

Page 10 - TO TURN OFF GAS TO APPLIANCE; To Turn OFF Gas to Appli-; CLEANING AND MAINTENANCE

10 Installation instructions and Owner’s Manual Figure 16 CAUTION: Do not try to adjust heating level by using equipment shutoff valve. WARNING: When running heater, set control knob at “LO” or “HI” locked positions. Poor combustion and higher levels of carbon monoxide may result if heater is operat...

Page 11 - SPECIFICATIONS

Installation instructions and Owner’s Manual 11 Make sure grille guard is in place before running heater. If screen or grille guard is removed for servicing it must be replaced prior to operating the heater. WARNING: Failure to keep the primary air opening(s) of the burner(s) clean may result in soo...

Page 12 - TROUBLESHOOTING; Only a qualified service person should service and repair heater.

12 Installation instructions and Owner’s Manual TROUBLESHOOTING NOTE: All troubleshooting items are listed in order of operation and likely occurrence. WARNING: Only a qualified service person should service and repair heater. CAUTION: Never use a wire needle, or similar object to clean ODS/pilot. T...

Page 13 - OBSERVED SYMPTOM; TROUBLESHOOTING CON’T

Installation instructions and Owner’s Manual 13 TROUBLESHOOTING WARNING: If you smell gas: • Shut off gas supply • Do not try to light any appliance • Do not touch any electrical switch; do not use any phone in your building • Immediately call you gas supplier from a neighbor’s phone. Follow the gas...

Page 14 - PARTS UNDER WARRANTY; Your name; PARTS NOT UNDER WARRANTY; PARTS LIST

14 Installation instructions and Owner’s Manual REPLACEMENT PARTSNote: use only original replacement parts. This will protect you warranty coverage for parts replaced under warranty. PARTS UNDER WARRANTY Contact authorized dealer from whom you pur- chased this product. If they are unable to supply o...

Page 15 - UNVENTED LP-GAS FIRED

Installation instructions and Owner’s Manual 15 ITEM PART NO. DESCRIPTION QTY. MHVFB10LPI 1 70397 Cabinet assembly 1 1-1 70595 Cabinet Top Panel 1 1-2 70592 Cabinet Right Panel 1 1-3 70593 Cabinet back Panel 1 1-4 70591 Cabinet Left Panel 1 2 70594 Lower Front panel assembly 1 3 70312 Reflector Asse...

Page 16 - WARRANTY INFORMATION; Keep this warranty; Sale or cancelled check must be presented.

16 Installation instructions and Owner’s Manual ENERCO GROUP, INC., 4560 W. 160TH ST., CLEVELAND, OHIO 44135216-881-5500 Toll Free Number 1-800-251-0001 www.mrheater.comMr. Heater is a registered trademarks of Enerco Group, Inc. © 2005, Enerco/Mr. Heater. All rights reserved WARRANTY INFORMATION Kee...