Mr. Heater TSBF10LP - Manual

Mr. Heater TSBF10LP

Mr. Heater TSBF10LP – Manual, read for free online in PDF format. We hope this helps you resolve any issues you may have. If you have further questions, please contact us through the contact form.

1 Page 1
2 Page 2
3 Page 3
4 Page 4
5 Page 5
6 Page 6
7 Page 7
8 Page 8
9 Page 9
10 Page 10
11 Page 11
12 Page 12
13 Page 13
14 Page 14
15 Page 15
16 Page 16
17 Page 17
18 Page 18
19 Page 19
20 Page 20
21 Page 21
22 Page 22
23 Page 23
24 Page 24
Page: / 24

Table of Contents:

  • Page 2 – DANGER; Carbon Monoxide Poisoning:; WARNINGS; IMPORTANT; Fresh Air for
  • Page 3 – Figure 1; LOCAL CODES; WARNING; National Fuel Gas
  • Page 4 – VENTILATION AIR; Figure 2
  • Page 5 – Ventilation from Outdoors
  • Page 6 – Figure 4; FASTENING HEATER TO WALL; Figure 5; Attach to wall studs; Figure 7; For attaching mounting bracket to wall studs
  • Page 7 – Fold wall anchor as shown in figure 8 below.; Placing Heater on Mounting Bracket; Mark screw locations on wall.; FLOOR MOUNTING AWAY FROM WALL:; A qualified service person must connect
  • Page 8 – CHECKING GAS CONNECTIONS
  • Page 9 – Pressure Testing Heater Gas Connections:; Operating Your Heater; ELECTRICAL WIRING DIAGRAM:; NON-THERMOSTAT MODELS; WHAT TO DO IF YOU SMELL GAS
  • Page 10 – LIGHTING INSTRUCTIONS; Burner
  • Page 11 – TO TURN OFF GAS TO APPLIANCE; THERMOSTAT MODELS
  • Page 12 – THERMOSTAT CONTROL OPERATION; DOES NOT; To Turn OFF Gas to; BURNER FLAME PATTERN
  • Page 13 – CLEANING AND MAINTENANCE; CLEANING ODS/PILOT AND BURNER
  • Page 14 – TROUBLESHOOTING; Only a qualified service person should service and repair heater.
  • Page 15 – OBSERVED SYMPTOM; TROUBLESHOOTING CON’T
  • Page 16 – SPECIFICATIONS
  • Page 17 – REPLACEMENT PARTS; PARTS UNDER WARRANTY; Your name; Usually, we will ask you to return the defective part to the factory.; PARTS NOT UNDER WARRANTY; Equipment Shutoff Valve
  • Page 18 – Thermostat models
  • Page 19 – DESCRIPTION; PARTS LIST
  • Page 21 – NON-Thermostat models
  • Page 22 – ITEM
  • Page 24 – WARRANTY INFORMATION; Keep this warranty
Loading the manual

Installation instructions and Owner’s Manual

1

UNVENTED LP-GAS FIRED ROOM HEATER

Blue Flame Heaters

Plaque Heaters

Model #

Burn Rate

Model #

Burn Rate

MHBF10LP/HSBF10LP/TSBF10LP

10,000 Btu/hr

MHIR10LP/HSIR10LP/TSIR10LP

10,000 Btu/hr

MHBF20LPT/HSBF20LPT/TSBF20LPT 20,000 Btu/hr

MHIR20LP/HSIR20LPT/TSIR20LPT

20,000 Btu/hr

MHBF30LPT/HSBF30LPT/TSBF30LPT 30,000 Btu/hr

MHIRLPT/HSIR30LPT/TSIR30LPT

30,000 Btu/hr

MHIR10LP/

HSIR10LP/

TSIR10LP

ENERCO GROUP, INC., 4560 W. 160

TH

ST., CLEVELAND, OHIO 44135 · 216-916-3000

WARNING:

If the information in this manual is not followed exactly, a fire or explosion may result causing

property damage, personal injury, or loss of life.

- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
- WHAT TO DO IF YOU SMELL GAS

• Shut off gas supply
• Do not try to light any appliance
• Do not touch an electrical switch; do not use any phone in your building.
• Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions.
• If you cannot reach your gas supplier, call the fire department.

- Installation and service must be performed by a qualified installer, service agency, or the gas supplier.

WARNING

: This is an unvented gas-fired heater. It uses air (oxygen) from the room in which it is installed. Provi-

sions for adequate combustion and ventilation air must be provided. Refer to Fresh Air for Combustion and Ventila-

tion section on page 3 of this manual.

WARNING

: Improper installation, adjustment, alteration, service or maintenance can cause injury or property

damage. Refer to this manual for correct installation and operational procedures. For assistance or additional

information consult a qualified installer, service agency, or gas supplier.

MHIR20LPT/

HSIR20LPT/

TSIR20LPT

MHBF30LPT/

HSBF30LPT/

TSBF30LPT

MHBF10LP/

HSBF10LP/

TSBF10LP

MHIR30LPT/

HSIR30LPT/

TSIR30LPT

MHBF20LPT/

HSBF20LPT/

TSBF20LPT

70575 Rev. E 04/07

INSTALLATION INSTRUCTIONS
AND OWNER’S MANUAL

READ INSTRUCTIONS CAREFULLY:

Read and follow all instructions. Place instruc-

tions in a safe place for future reference. Do not allow anyone who has not read
these instructions to assemble, light, adjust or operate the heater.

Installer: Leave this manual with the appliance. Consumer: Retain this manual for future reference.

Serial Number Info on Pg 24

"Loading the manual" means you need to wait until the file loads and becomes available for online reading. Some manuals are very large, and the time they take to appear depends on your internet speed.

Summary

Page 2 - DANGER; Carbon Monoxide Poisoning:; WARNINGS; IMPORTANT; Fresh Air for

2 Installation instructions and Owner’s Manual 70575 Rev. E 04/07 This appliance may be installed in an aftermarket* permanently manufactured (mobile) home, where not prohibited bylocal codes.This appliance is only for use with the type of gas indicated on the rating plate. This appliance is notconv...

Page 3 - Figure 1; LOCAL CODES; WARNING; National Fuel Gas

Installation instructions and Owner’s Manual 3 Product Features Figure 1 SAFETY DEVICE This heater has a pilot with an Oxygen Depletion Sensor(ODS) safety shut off system. The ODS/pilot shuts offthe heater if there is not enough fresh air. IGNITION SYSTEM PIEZO: BF10LP/ IR10LP – The heater is equipp...

Page 4 - VENTILATION AIR; Figure 2

4 Installation instructions and Owner’s Manual 70575 Rev. E 04/07 installed in that space, and an unconfined space as aspace whose volume is not less than 50 cubic feet per1,000 Btu per hour (4.8 m 3 per kW) of the aggregate input rating of all appliances installed in that space.Rooms communicating ...

Other Mr. Heater Models

All Mr. Heater Other